STREAM USERS MANUAL REV C GUZZLE H2O LLC WWW.GUZZLEH2O.COM INFO@GUZZLEH20.
STREAM USERS OPERATION MANUAL AND MAINTENANCE MANUAL STREAM USERS MANUAL TABLE OF CONTENTS CONTENTS PAGE TABLE OF CONTENTS 1 HAZARD WARNING 2 STREAM WATER FILTRATION AND PURIFICATION KIT BOM 3 SYSTEM OVERVIEW 4 BATTERY CHARGING 5 VERIFY UV LIGHT FUNCTION 6 INITIAL SET UP 7 OPERATION - PRESSURIZED WATER FROM FAUCET 8 OPERATION - NATURAL WATER SOURCE 9 CHANGING CARBON BLOCK FILTER 10 STREAM SPECIFICATION AND CAPACITIES 12 FREEZING TEMPERATURES / LONG TERM STORAGE PREP 13 TIPS AND TR
STREAM USERS MANUAL WARNING MICROBIOLOGICAL HAZARD Human consumption of untreated water can lead to exposure to harmful microorganisms and an increased risk of gastrointestinal illness. Operating this filtration and purification device incorrectly increases your risk of exposure to harmful microorganisms and increases your risk of gastrointestinal illness. Reduce your chances of becoming sick by following the warnings and instructions in the operator’s manuals.
STREAM USERS MANUAL STREAM WATER FILTRATION AND PURIFICATION KIT KIT INCLUDES: STREAM FILTRATION/PURIFICATION UNIT CARBON BLOCK FILTER CARTRIDGE INLET HOSE (RED) OUTLET HOSE (CLEAR / BLUE) PRESSURE REGULATOR SCOUT 4” PREFILTER MESH BAG O-RING SPARES KIT BATTERY CHARGER 12V OR 110/240V PAGE 3
STREAM USERS MANUAL STREAM SYSTEM OVERVIEW The Stream uses a three stage process to filter and purify drinking water. The first stage is the 1 micron prefilter on the intake hose. This stage physically removes larger sediment particles. The second stage is an activated carbon block 0.5 micron filter. This stage physically removes particles large than 0.5 microns, and it chemically filters and absorbs bad taste, ordors, chlorine, lead, mercury, VOCs, sediment, and cysts.
STREAM USERS MANUAL BATTERY CHARGING To reduce the risk of fire or electric shock, carefully follow these instructions: 1) Plug battery charger into charging port on STREAM and plug charger into 110/240v (50/60Hz) OR 12v plug (if using 12v charger). Do not use other battery charging devices with this equipment other than those supplied by Guzzle H2O and indicated for use with the Stream. CHARGING PORT 2) Charger will cut off power automatically if battery is full.
STREAM USERS MANUAL VERIFY UV LIGHT FUNCTION Confirm that the UV light is funcitoning by obeserving the glow of the LED UV light through the clear hose. Momentarily switch on the Stream to illuminate the UV light. It may be necessary to bring the Stream to a darkend area to observe the glow. It may also be easier to see UV light if there is no water in the system.
STREAM USERS MANUAL INITIAL SETUP 1) Charge system battery. (See CHARGING). 2) Plug RED intake hose into RED quick connect. Push firmly until connectors click. 3) Plug BLUE / CLEAR outlet hose into BLUE quick connect. Push firmly until connectors click.
STREAM USERS MANUAL OPERATION – PRESSURIZED WATER FROM FAUCET 1) Thread hose fitting (3/4” GHT) on red intake hose on to pressure regulator. Failure to use pressure regulator may lead to flow rates that are too high for adequate disinfection. 2) Thread PRESSURE REGULATOR onto water faucet. 3) Press power button to start flow of water. On initial set up it may take up to 60 seconds for air to purge from system. NOTE: Pump will not run when operating in pressurized water mode.
STREAM USERS MANUAL OPERATION – UNPRESSURIZED WATER SOURCE 1) p Assemble the prefilter: 6&287 35(),/7(5 $66(0%/< 6/,'( 2 5,1* &$575,'*( 2 5,1* 2172 35(),/7(5 &25( 7+5($' &$3 2172 35(),/7(5 6/((9( $1' 7,*+7(1 %< +$1' '2 127 29(57,*+7(1 35(),/7(5 &25( 2 5,1* 7+5($' 2172 675($0 ,17$.( +26( 0,&521 35(),/7(5 &$575,'*( 2 5,1* &$3 2) Submerge prefilter in water source. 3) Push power button to start the flow of water.
STREAM USERS MANUAL INSTALLING OR CHANGING THE CARBON BLOCK FILTER WHEN TO CHANGE THE CARBON BLOCK FILTER CARTRIDGE: Carbon block filter cartridge should be changed after 1000 gallons of use, or once per year. Actual capacity may vary depending upon quality of water filtered. Reduced water flow rate through the Stream is an indication that the carbon block filter cartridge should be changed. The carbon block filter cartridge may be visually inspected through the clear filter housing.
STREAM USERS MANUAL HOW TO INSTALL THE CARBON BLOCK FILTER CARTRIDGE (CONT): 3) Place a new carbon block filter element in the cannister. Continue to hold the Stream with the lid side down. Ensure top and bottom gaskets are in place, and filter cartridge is centered on mounting posts. Make sure cannister o-ring is properly seated and cartridge gaskets are in place. Thread the cannister onto the filter housing base. Tighten cannister firmly, making sure o-ring seats and seals.
STREAM USERS MANUAL PRODUCT SPECIFICATIONS AND CAPACITIES MAXIMUM FLOW RATE; TAP WATER: 1.1 GALLONS (4 LITRES) / MIN MAXIMUM FLOW RATE; PUMPING WATER: .7 GALLONS (2.7 LITRES) / MIN BATTERY RUN TIME: 50 MINUTES TREATED WATER CAPACITY, PER BATTERY CHARGE, TAP WATER: 90 GALLONS TREATED WATER CAPACITY, PER BATTERY CHARGE, PUMPING WATER: 32 GALLONS FLOW RATES AND CAPACITIES ARE FOR IDEAL CONDITONS.
STREAM USERS MANUAL FREEZING TEMPERATURE / LONG TERM STORAGE PREP STREAM MAY BE DAMAGED BY FREEZING TEMPERATURES DUE TO ICE EXPANSION WATER MUST BE REMOVED FROM STREAM TO PREVENT DAMAGE FROM ICE EXPANSION. 1) Follow inital set up instructions to install inlet and outlet hoses. Allow inlet hose to ingest air. (Do not submerge or connect inlet hose to water source.) DO NOT install PRESSURE REGULATOR or PREFILTER to inlet hose. 2) Open lid. 3) Push power button to turn on STREAM. Pump should run.
STREAM USERS MANUAL TIPS AND TROUBLE SHOOTING ALWAYS USE PRE FILTER when operating the STREAM with natural sources of water. Ingesting large debris, rocks, or sand can damage pump. ALWAYS USE PRESSURE REGULATOR when operating the STREAM with pressurized water. Excess pressure increases the flow rate and will result in lower rates of filtration and disinfection. PUMP PULSING ON AND OFF IS NORMAL. The pump may cycle on and off as it builds up pressure against the carbon block filer.
STREAM USERS MANUAL END OF MANUAL GUZZLE H2O LLC WWW.GUZZLEH2O.COM INFO@GUZZLEH20.
