Data Sheet
Code Mercenaries
8
LL
LL
EE
EE
DD
DD
--
--
WW
WW
aa
aa
rr
rr
rr
rr
ii
ii
oo
oo
rr
rr
00
00
44
44
8. Absolute maximum ratings
Input Voltage (Vin relative to GND): 0 V to 36 V
Input Current: 4.5 A (average)
SDA, SCL pin input voltage (relative to GND): -0.3 V to 5.5 V
DMX pin input voltage (relative to GND): -10 V to 15 V
Storage temperature: -55°C to +115°C
Ambient temperature with power applied (no output driven): -40°C to +85°C
ESD: 2000 V (human body model)
Absolute maximum ratings must not be exceeded or permanent damage to the LED-Warrior04 may
result.
8.1. Operating conditions
8.2 Thermal precautions
When operating at elevated ambient temperature,
vertical mounting in an air volume sufficiently
large to allow convection is recommended to
reduce surface temperature of the regulator.
Additional cooling measures can help to further
reduce the regulator temperature and increase long
term reliability.
No part of the module surface may exceed 95°C
during operation.
8.3 Failure modes
The most common failure mode seen when the
LED-Warrior04 is destroyed due to a departure
from maximum operating conditions is that it goes
into an inert status. Though it is not impossible that
a failure can lead to an internal short circuit.
8.4 Recommended safety measures
Failure current limiting by a fuse dimensioned for
the application or by a power source that is current
limited is recommended.
Parameter Min Typ Max Unit Remarks
V
in
I
in
Operating Voltage
Operating Supply Current
732
4500
V
mA
t
op
I
idle
V
i2c
V
DMX
Operating temperature
Idle mode current
-10
Voltage on I2C pins
Voltage on DMX pins
0
-7
15
60
5
12
°C
mA
in still air
V
in
=24 V, all channels off
V
V
relative to GND
R
DMX
I
aux
V
out
I
out
Termination resistor on DMX
Available current on I2C connector
Output voltage on each channel
Output current on each channel 80
I
outerr
P
out
P
idle
Output current error
Output power for each channel
Idle power consumption 250
120
30
V
in
-2.5
1000
Ω
mA
enabled by jumper
Vout = 5 V
V
mA
varies with LEDs
programmable
±20 ±40
25
400
mA
W
deviation from set value
independent for each channel
mW all channels off, no bus traffic
V1.1.3 January 24th 2020