MODEL: MX514SPB COBRA LAWN MOWER OWNER’S MANUAL Cobra Garden Machinery Henton and Chattell Ltd., London Road, Nottingham NG2 3HW UK www.cobragarden.co.
CONTENTS SECTION 1 SYMBOLS MARKED ON THE PRODUCT………………………………. 3 SECTION 2 GENERAL SAFETY RULES………………………………………………. 3 SECTION 3 PARTS DESCRIPTION……………………………………………………... 6 SECTION 4 TECHNICAL DATA……………………………………………………………7 SECTION 5 ASSEMBLY………………………… ……………………………………….. 7 SECTION 6 “3 IN 1”…………………………………………………………………………9 SECTION 7 OPERATION INSTRUCTIONS…………………………………………….. 11 SECTION 8 MAINTENANCE INSTRUCTIONS……………………………………..….. 14 SECTION 9 LUBRICATION INSTRUCTIONS…………………………………….……..
WARNING： For your own safety please read this manual before attempting to operate your new mower. Failure to follow instructions can result in serious personal injury. Spend a few moments to familiarise yourself with your mower before each use. 1. SYMBOLS MARKED ON THE PRODUCT Fig. A B.1 Read Operator's Manual. B.2 Keep bystanders away. B.3 Pay attention to the operator's hands and feet to avoid injury. B.4 Fuel is flammable, keep fire away. Do not add fuel with running machine. B.
Training 1. Before using the lawnmower read the instructions carefully. Familiarise yourself with the controls and pay particular attention in learning how to stop the machine in an emergency. 2. Never allow children or people unfamiliar with these instructions to use the lawn mower. Local regulations can restrict the age of the operator. 3. Never mow while people, especially children or pets are nearby. 4.
16. 17. 18. 19. Do not start the engine when standing in front of the discharge chute. Never put hands or feet near or under rotating parts. Keep clear of the discharge opening at all times. Always ensure the engine is fully switched off before picking up/carrying the Lawnmower. Stop the engine and disconnect the spark plug wire, make sure that all moving parts have come to a complete stop and, where a key is fitted remove the key, make sure engine has had time to cool.
3. PARTS DESCRIPTION Fig.1A 1. Upper handle 2. Brake control handle 3. Throttle choke lever 4. Starter handle 5. Rope Guide 6.Locking lever 7. Lower handle 8. Grass catcher 9. Height adjusting lever 10. Deck 11. Sideward flap 12. Spark plug 13. Fuel cap 10. Oil cap 15. Cable clamp 16. Speed adjust lever 17. Self-drive control handle 18. Side discharge channel 19.
4. TECHNICAL DATA Model MX514SPB Engine type Briggs 650E Self-propelled Yes 3 Engine displacement 190 cm Blade width 510mm Rated speed 2800/min Fuel tank capacity 2.0L Grass catcher capacity 60L Net Weight Height adjustment: 35.6kg 25~75mm,7 adjustment MX514SPB Guaranteed Sound pressure level 84.9dB(A)(K=3dB(A)) at the operator’s position (According to EN 836 Annex H & EN ISO 4871) Measured sound power level 94.6dB(A) K=2.
Fig.2D Fig.2E Fig.2G Fig.2H Fig.2F 5.2 ADJUSTMENT FOR AN APPROPRIATE ANGLE A).Pull the locking lever opening; B).Rotating the upper handle centered of the angle adjusting gear for adjusted a appropriate angle into the scope -20º to 20º as the Fig.3 shown; C).Push the locking lever closed to connect the lower handle and the upper handle. Fig.3 5.3 MOUNTING AND DISMOUNTING THE GRASS CATCHER 1. To fit: Raise the rear cover and hitch the grass catcher on rear of mower. (Fig. 4A/Fig.4B/Fig.4C) 2.
5.4 STARTER HANDLE Move the starter handle from the engine to the rope guide. Fig.5A Fig.5B 5.5 HEIGHT OF CUT Apply outward pressure to disengage lever from rack. Move lever forward or back to adjust height. (Fig.6 and see clause 7.9) Fig. 6 5.6 Tool Box The lawn mower has a tool box, you can push the button to open it, and then press the cover to lock it. You can put tools such as spanner, screwdriver in this box. (Fig. 601) Fig. 601 6. “3 IN 1” The lawn mower has 3 in 1 features: 1.
- Only move at a walking pace. - Regularly clean mulching wedge, housing inner side and mowing blade. Starting Operation ONE: Retrofitting for mulching mower WARNING: only with a stopped engine and standstill cutter. 1. Raise the rear cover and remove the grass catcher. 2. Push the mulching wedge into the deck. Lock the mulching wedge with the button into the opening on the deck. (Fig 7A/Fig 7B/Fig.7C) 3. Lower the rear cover again. Fig.7A Fig.7B Fig.
-Lift rear cover and remove the mulching wedge. 2. Removing the side discharge channel for side discharge: -Lift the sideward flap and remove the side discharge channel. -The sideward flap automatically closes the discharge opening on the housing by mean of spring force. -Regularly clean the sideward flap and discharge opening. 3. Mount the grass catcher: -To fit: Raise the rear cover and hitch the grass catcher on rear of mower. -To remove: Grasp and lift the rear cover, remove grass catcher. 7.
Do not tilt the lawn mower when starting the engine. Start the mower on a level surface, free of high grass or obstacles. Keep hands and feet away from the rotating parts. Do not start the engine when standing in front of the discharge opening. 7.3 OPERATION PROCEDURES During operation, tightly hold the brake handle with both hands. Note: During operation, when the brake handle is released, the engine will stop and thus stopping the lawnmower from operating. 7.
cutting in thick grass it may be necessary to use one of the slowest speeds in order to get a clean well mowed cut. When mowing long grass you may have to cut the lawn in two passes, lowering the blade another 1/3 of the length for the second cut and perhaps cutting in a different pattern than was used the first time. Overlapping the cut a little on each pass will also help to clean up any stray clippings left on the lawn.
Fig.13 8. MAINTENANCE INSTRUCTIONS SPARK PLUG Use only original replacement spark plug. For best results, replace the spark plug every 100 hours of use. 9. LUBRICATION INSTRUCIONS CAUTION: DISCONNECT SPARK PLUG BEFORE SERVICING. 1. WHEELS-Lubricate the ball bearings in each wheel at least once a season with a light oil. 2. ENGINE-Follow engine manual for lubrication instructions. 10. CLEANING CAUTION: Do not hose engine. Water can damage engine or contaminate the fuel system. 1. Wipe deck with dry cloth.
CAUTION: Be sure to disconnect and ground the spark plug wire before working on the cutting blade to prevent accidental engine starting. Protect hands by using heavy gloves or a rag to grasp the cutting blades. Tip mower as specified in separate engine manual. Remove the hex bolt and washer, which holds the blade and blade adapter to the engine crankshaft. Remove the blade and adapter from the crankshaft. WARNING: Periodically inspect the blade adapter for cracks, especially if you strike a foreign object.
area. 11. STORAGE INSTRUCTIONS (OFF SEASON) The following steps should be taken to prepare the lawn mower for storage at the end of the mowing season. 1. Drain the fuel from the engine by running the engine until it stops. a) Start the engine and let it run until it has used up all remaining petrol and stalls. b) Remove the spark plug. Use an oilcan to fill approx. 20 ml oil into the combustion chamber. Operate the starter to evenly distribute the oil in the combustion chamber. Replace the spark plug.
12. TROUBLESHOOTING PROBLEM PROBABLE CAUSE CORRECTIVE ACTION Engine does not Throttle choke not in the correct position Move throttle choke to the correct position start. for the prevailing conditions. Fuel tank is empty. Fill the tank with fuel: refer to the ENGINE MANUAL. Air filter element is dirty. Clean air filter element: refer to the ENGINE MANUAL Spark plug loose. Tighten spark plug to 25-30Nm. Spark plug wire loose or Install spark plug wire on spark plug. disconnected from plug.
13. WARRANTY This product is warranted in accordance with legal regulations for a 24 month period effective from the date of purchase by the first user. This product will not be covered if used in a commercial application.
15. EC-DECLARATION OF CONFORMITY EC Declaration of Conformity We herewith declare, Cobra Garden Machinery Henton & Chattell Ltd, London Road, Nottingham NG2 3HW United Kingdom that the following machine complies with the appropriate basic safety and health requirements of the EC Directive based on its design and type, as brought into circulation by us.
