Troubleshooting Manual
Table Of Contents
- Table of Contents
- Machine Will Not Start………………………….…….………...2
- Wash Pump Runs – Timer Will Not Cycle………….………...3
- Machine Cycles, Normal Wash Pump Will Not Run………...4
- Machine Will Not Turn Off……………………………………...5
- Dishwasher Will Not Drain, Drain Bill Not Lifting…………….6
- Drain Will Not Close, Drain Ball Will Not Fall………………...7
- Chemical Pumps Will Not Run …………………..….………...8
- Machine Will Not Fill With Water – Machine Runs ………….9
- Machine Only Fills During The Wash Cycle ………………..10
- Machine Only Fills When Fill Switch is Used…………...…..11
- Fill Valve Only Runs During the Wash Cycle……………....12
- Machine Only Fills When Fill Switch is Used…………...….13
- Fill Water Will Not Shut Off… ……………………………..…14
- Wash Tank Heater Is Not Getting Hot……………………....15
- Booster Heat Not Getting Hot (Final Rinse)……………...…16
- Machine Will Not Start
- Wash Pump Runs – Timer Will Not Cycle
- Machine Will Not Turn Off
- Dishwasher Will Not Drain, Drain Bill Not Lifting.
- Drain Will Not Close, Drain Ball Will Not Fall
- Chemical Pumps Will Not Run
- Machine Will Not Fill With Water – Machine Runs
- Machine only Fills During The Wash Cycle
- Machine Only Fills When Fill Switch is Used
- Fill Valve only Runs During the Wash Cycle
- Fill Water Will Not Shut Off
- Wash Tank Heater Is Not Getting Hot
- Booster Heat Not Getting Hot (Final Rinse)
Chemical Pumps Will Not Run
Parts and Service Manuals Are Available At:
www.cmadishmachines.com/products.html
Chemical Pumps Will Not Run
Detergent-Rinse Aid-Sanitizer
Check Voltage
Detergent
Micro Switch
Cam In Timer
(Blue Wire)
Check Voltage
Rinse Aid
Micro Switch
Cam In Timer
(Blue Wire)
Check Voltage
Sanitizer
Micro Switch
Cam In Timer
(Blue Wire)
No Voltage
Voltage Okay
Check
Ice-Cube
Relay
Replace
Detergent
Micro Switch
Replace
Rinse Aid
Micro Switch
Replace
Sanitizer
Micro Switch
Check
Timer motor
Connections
Voltage Okay
Replace
Detergent
Micro Switch
Replace
Rinse Aid
Micro Switch
Replace
Sanitizer
No Voltage
Check/Replace
Prime Switch
Micro Switch