Manual

www.climacoolcorp.com
28
Malfunction – Low Head Pressure Chart
3RVVLEOH&DXVH 5HPHG\
,QVXIÀFLHQWUHIULJHUDQWFKDUJHWRDGHTXDWHO\ÁRRG
FRQGHQVHU
$GGUHIULJHUDQW
/$&IDLOVWRFORVHGXHWR
D)RUHLJQPDWHULDOLQYDOYH
E/RVVRIDLUFKDUJHLQHOHPHQW
6HH%HORZ
D&DXVH/$&WRRSHQE\UDLVLQJFRQGHQVLQJUHFHLYHU
SUHVVXUHDERYHYDOYHVHWWLQJE\F\FOLQJFRQGHQVHUIDQ,I
IRUHLJQPDWHULDOGRHVQRWSDVVWKURXJKYDOYHUHSODFH/$&
E5HSODFH/$&
/$
&
UHFHLYHUSRUW
I
DLOVWRRSHQGXHWR
D/HVVWKDWSVLSUHVVXUHGURSDFURVVLQOHWWRUHFHLYHUSRUW
E,QWHUQDOSDUWVGDPD
J
HGE\RYHUKHDWLQ
J
ZKHQLQVWDOOHG
6
HH%HORZ
D&KHFN/$&FDXVHVUHPHGLHV
E5HSODFH/$&
'LVFKDUJHOLQHWR/$&UHVWULFWHG 5HPRYHUHVWULFWLRQLQÀWWLQJVRUOLQH
'LUW\FRQGHQVHUFRLO
&OHDQFRLO
$LURQFRQGHVHUEORFNHGRII &OHDQDLUHDDURXQGFRQGHQVHU
7RRPXFKUHIULJHUDQWFKDUJH 5HPRYHFKDUJHXQWLOSURSHUKHDGSUHVVXUHLVPDLQWDLQHG
8QGHUVL]HGUHFHLYHU &KHFNUHFHLYHUFDSDFLW\DJDLQVWUHIULJHUDQWUHTXLUHGWR
PDLQWDLQGHVLUHGKHDGSUHVVXUH
1RQFRQGHQVLEOHVDLULQV\VWHP 3XUJHIURPV\VWHP
%\SDVVLQJKRWJDVZKHQQRWUHTXLUHGGXHWR
D,QWHUQDOSDUWVRIWKH,QOHWWRUHFHLYHUSRUWRIWKH/$&DUH
GDPDJHGE\RYHUKHDWLQJZKHQLQVWDOOHG
E,ISUHVVXUHGURSDFURVVWKHFRQGHQVHUDVVRFLDWHGSLSLQJ
DQG/$&H[FHHGVSVLXQGHUIXOOORDGFRQGLWLRQV
6HH%HORZ
D5HSODFH/$&
E&RQWDFW)DFWRU\
/LTXLGSRUWRUOLTXLGOLQHSOXJJHG 5HPRYHEORFNDJHLQSRUWRUOLTXLGOLQH
&RQGHQVHUIDQVQRWUXQQLQJ 5HSDLURUUHSODFHIDQPRWRU
0DOIXQFWLRQ+LJK+HDG3UHVVXUH
WARNING: Serious injury could result from an explosion
caused by the rapid expansion of trapped liquid refrigerant
subjected to high temperature. ALWAYS OPEN OR VENT
THE SYSTEM BEFORE APPLYING HEAT TO REMOVE SYSTEM
COMPONENTS. Break the element charging cap tube on
valve dome by hand or with a clean cut tool. DO NOT use
side cutters, which may seal the opening.
Installation Precautions
1.
Do not overcharge — see charging procedures on
pages 26.
2. Be sure that the piping does not allow liquid refrigerant
to be trapped in sections where hydrostatic pressure
can develop.
3. Be sure that the receiver is large enough to hold the
entire charge during “warm” operation.
4. Do not overheat — see brazing procedures on page 25.
5. “Caution:” on page 25.
6. “Caution:” on page 27.