Instruction Manual

www.climacoolcorp.com
22
PreStartUp R-410A PkgAirCool Rev. 0
ProjectName:_________________________  Date:___________________
Address:  _________________________
_________________________


YES NO

1.
Aremodulesconnectedproperly“perCodesandInstallationManual?    ____ ____

(Installation,Operation&Maintenance Manualisavailableatwww.climacoolcorp.com)
2. Istherea60Ͳ80meshstrainerontheevaporatorinletwater?       ____ ____

(FillwatertoChillerbeingsuretopassthrough60Ͳ80meshstrainer.)

3. Ischilledwatersystemfilled,flushedandallairpurgedfromsystem?________

(Allairmustbepurgedfromsystempriortostartup.SeeFillingtheWaterSysteminIO&M)

4. Areallpumpstestedandoperational?________

5. ArerequiredGPM’s(verifiedbypressuredifferential)suppliedtotheChiller?    ____ ____

(SeeprojectspecificationsorselectionandperformancesheetsavailablefromClimaCoolSalesRep)

6. Pressuredifferentialflowsensor/switchsettotripondropbelowrequiredflows? ____ ____

(Settotriponlowflow(lessthan75%flow),notpumpon/off.)

7. HaveallChillercouplingconnectionsbeenleaktested?____ ____

8. Istherewaterpresentlycirculatingthroughchiller?____ ____

9. Verifiedthattemperaturesensorsandvoltage/phasemonitorhavebeeninstalled?  ____ ____

10. Verifiedpowersupplyagreeswithchillernameplate?____ ____

11. Ispower
andcommunicationwiringcompletetoeachmodule?____ ____

12. Verifythatwiringanddevicesmeetwithapprovedelectricalsubmittaldrawings?____ ____

13. IsrequiredloadavailabletorunmultiplecompressorsatstartͲup?    ____ ____ 

14.Iscondenserfunctionaltomaintaincondenserrequiredoperation?   ____ ____
 (Thisincludesmaintaining“minimum”inlettemperature.See“OperationalLimitations”inIO&M”.)

Ifyouchecked“No”toanyquestionabove,providethelinereferencenumberandthedateofscheduledcompletion
below.PleasenoteallconditionsmustbecompletepriortothestartͲupdate.
__________________________________________________________________________________________________
_
__________________________________________________________________________________________________
_
*ThisformmustbecompletedandsubmittedtoClimaCoolCorp.two(2)weekspriortofinalschedulingofanyStartͲup.
Note:IfanyoftheaboveitemsarenotcompleteattimeofstartͲup,backchargeswillbeassessedforadditionalcosts.

ContractorName:___________________________
Address:___________________________
___________________________
Phone:___________________________  _________________________________
(AuthorizedSignature)

PreStartͲUpCheckList* (PackagedAirͲCooled)

EͲmail[e-mail]
orFaxto:405Ͳ745Ͳ2072