8802695/8729895 8790886/8802248 8804837/8804473
ISO 8098 WARNING! This bike is only suitable for use by riders (including any panniers and/or luggage) with a wight or less than (1) 30kgs (66 lb) for 12in bike, (2) 40kgs (88 lb) for 14in bikes and (3) 50kgs (110 lb) for 16in bikes. WARNING! The bicycle is not suitable for the fitting of a luggage carrier and a child seat. The bicycle is not designed for public roads use. IMPORTANT! It is the responsibility of parents or guardians to ensure the safety of this bicycle including when used.
Part Saddle clamp nuts Pedals Front wheel nuts Rear wheel nuts Cable pinch bolt Torque(Nm) 16-18 Nm 40 Nm 22-25 Nm 25-29 Nm 6-8 Nm
Replaced worn brake blocks or brake pads immediately!
ADJUSTING CHAIN TENSION Most children’s bikes have one gear and as a result the chain tension is very important. The chain should be able to move approximately 12mm(6mm up and 6mm down)at the mid-point between the front and rear gear sprockets. Chain Adjustment WARNING:The chain must remain on the sprockets.If the chain comes off the sprockets, the coaster brake will not operate. 30 WARNING:Do not attempt chain repairs.If there is a problem with the chain, have a bicycle service shop make any repairs.
Lubrication Information Note: The frequency of maintenance should increase with use in wet or dusty conditions. Do not over lubricate- remove excess lubricant to prevent dirt build up. Never use a degreaser to lubricate your chain(WD-40 TM ). WARNING: Do not over lubricate.If lubricant gets on rims,tires or brake shoes, it will reduce control and braking performance and may require a longer stopping distance.Injury to the rider can occur.