OPERATOR’S MANUAL AERATOR MODEL: TA-25D POWERSTEER AERATORS (S.N. 1140064404 and Above) 1028 Street Road • P.O. Box 38 Southampton, PA 18966 U.S.A. Ph.
TABLE OF CONTENTS INTRODUCTION ...........................................................1 Thank You ...............................................................1 Read This Manual ...................................................1 Warranty .................................................................1 Measurements.........................................................1 Serial Numbers........................................................1 Ordering Part...........................................
INTRODUCTION THANK YOU Thank you for purchasing a CLASSEN Aerator READ THIS MANUAL Read this manual carefully in its entirety. It contains safety, operating, maintenance, and adjustment instructions for your Aerator. By following the operating and maintenance instructions you will prolong the life of your equipment and maintain its maximum efficiency. Failure to do so could result in personal injury or equipment damage.
SAFETY PRECAUTIONS TRAINING OPERATIONAL SAFETY 1. Regard the unit as a piece of power equipment and teach this regard to all who operate this unit. 1. Carefully read and follow all caution decals. (See Pg. 5.) 2. Operate only in daylight or good artificial light. 2. Read the instructions carefully. Be familiar with the controls and the proper use of the equipment. 3. Never allow children, teenagers or people unfamiliar with these instructions to use this piece of equipment. 3.
OPERATION PREPARATION 1. Carefully read this manual and operate Aerator correctly. TO OPERATE AERATOR 1. Start engine. (See “Starting Engine” section.) 2. Always check machine on level ground. 3. Visually check all moving parts and all fasteners, if loose or broken, tighten or replace. Check for broken or bent tines, replace if necessary. 4. Lubricate all fittings after every four hours of using machine, using a pressurized gun with standard lithium base lubricant (see “General Maintenance” section).
GENERAL MAINTENANCE AERATOR MAINTENANCE Model TA-25D (See Fig. 3.) TO KEEP THE AERATOR IN GOOD OPERATING CONDITION, PERFORM THE FOLLOWING: • When replacement parts are required, use genuine Classen parts or parts with equivalent characteristics including type, strength, and material. Failure to do so may result in product malfunction and possible injury to the operator and/or bystanders. • Any warning decal that becomes illegible should be replaced immediately. (See Pg. 5.
AERATOR STORAGE SAFETY DECALS WARNING SAFETY WARNING: TO PREVENT POSSIBLE EXPLOSION OR IGNITION OF VAPORIZED FUEL, DO NOT STORE EQUIPMENT WITH FUEL IN TANK OR CARBURETOR OR NEAR OPEN FLAME (I.E. FURNACE, WATER HEATER, PILOT LIGHT). STORAGE INSTRUCTIONS Before the Aerator is put into storage for any period exceeding 30 days, the following steps should be taken. 1. Drain all fuel from fuel tank and fuel lines. 2. Start engine and run until all fuel is used from carburetor float bowl. 3.
2 YEAR LIMITED SERVICE AND WARRANTY POLICY Schiller Grounds Care, Inc. 1028 Street Road • Southampton, PA 18966 Telephone: 1-800-366-6268 TWO YEAR LIMITED WARRANTY Effective April 1, 2007 For the period of two years from the date of purchase, CLASSEN will repair or replace for the original purchaser free of charge, any part or parts found upon the examination of our factory authorized service station, or by the factory in Southampton, PA to be defective in material or workmanship.
