Installation & Assembly

10.Pipes: In rows where there is a pipe or other vertical object through the subfloor, make
sure the object lines up exactly where two boards will meet on the short ends. Take care
to measure carefully before cutting, so the two boards end at the middle of the object.
Use a drill or hole bit that is the diameter of the pipe or object, plus 1/2 inch (12.7mm) for
expansion/contraction. Click the two short sides of the boards together, then drill the
hole centered on the joint between the boards as shown. Now you can separate the two
boards and install as normal. See Diagrams 6A – 6C.
Transitions, moldings, and wall base:
All transition pieces should be attached to the subfloor with a high quality construction adhesive, available at
most Home Centers and Hardware stores. Place a generous bead of adhesive under the part of the transition
that will sit directly on the subfloor, and then press the transition firmly in place. Be sure the transition sits
firmly in the adhesive, and take care not to get any adhesive on the flooring. Remove any adhesive from the
surface immediately with mineral spirits and buff off any residue with a dry soft cloth. It may be necessary to
place heavy weights on the transition until the adhesive dries to ensure it will lay flat. Never attach the
transitions directly to the flooring.
Finishing the Job:
Inspect your work, as it will cost you more if you have to come back to do a repair later. Replace original
baseboards, or install matching hardwood baseboard. Install matching transitions as needed or
recommended by your dealer or installer. It is not recommended or necessary to seal this floor after
installation. Protect your floor from scratches by using felt pads on chair legs or furniture feet. Plastic
rollers/castors can damage your flooring; if necessary try to replace with softer rubber wheels/castors. When
moving heavy items like refrigerators, use at least two sheets of 1/4" Masonite or plywood while moving
(sliding the appliance from one sheet to the next) to protect the flooring against scratching and denting.
Congratulations!
You have just installed a beautiful and elegant Floor!