INSTALLATION INSTRUCTIONS MCB1U (Shown installed to CPA Series extension column as example only) LCB1U (Shown installed to 1-1/2" NPT column as example only) Back-to-Back Flat Panel Ceiling Mounts Spanish Product Description German Product Description Portuguese Product Description Italian Product Description Dutch Product Description French Product Description MCB1U / LCB1U
MCB1U / LCB1U Installation Instructions DISCLAIMER Milestone AV Technologies and its affiliated corporations and subsidiaries (collectively "Milestone"), intend to make this manual accurate and complete. However, Milestone makes no claim that the information contained herein covers all details, conditions or variations, nor does it provide for every possible contingency in connection with the installation or use of this product.
Installation Instructions MCB1U / LCB1U DIMENSIONS MCB1U 20.82 528.9 DIMENSIONS: INCHES [MILLIMETERS] LCB1U 24.38 619.1 MAX MOUNTING PATTERN WIDTH 26.83 681.
MCB1U / LCB1U Installation Instructions LEGEND Tighten Fastener Adjust Apretar elemento de fijación Ajustar Befestigungsteil festziehen Einstellen Apertar fixador Ajustar Serrare il fissaggio Regolare Bevestiging vastdraaien Afstellen Serrez les fixations Ajuster Loosen Fastener Remove Aflojar elemento de fijación Quitar Befestigungsteil lösen Entfernen Desapertar fixador Remover Allentare il fissaggio Rimuovere Bevestiging losdraaien Verwijderen Desserrez les fixations Retirez
Installation Instructions MCB1U / LCB1U TOOLS REQUIRED FOR INSTALLATION #2 3/32" (included) 1/8" (included) 5/32" (included) M5 (included) 1/2" or 13mm PARTS [Interface Bracket Hardware Kit] (2 bags total - quantities listed per bag) A (8) M4x16mm E (6) M5x20mm C (6) M4x25mm B (6) M4x20mm I (6) M8x20mm J (6) M8x30mm M (8) L (8) .750x.344x.500 .750x.323x.
MCB1U / LCB1U Installation Instructions INSTALLATION 4. Install and tighten two 5/16" set screws (X) through side of mount (DD) and against column. (See Figure 2) WARNING: FAILURE TO PROVIDE ADEQUATE STRUCTURAL STRENGTH FOR THIS COMPONENT CAN RESULT IN SERIOUS PERSONAL INJURY OR DAMAGE TO EQUIPMENT! It is the installer’s responsibility to make sure the structure to which this component is attached can support five times the combined weight of all equipment.
Installation Instructions 3. Install two 5/16" x 1" self-tapping screws (U) through two 5/16" flat washers (V), bottom stop collar (BB), and into installed column. 4. Install and tighten 5/16" x 3/4" set screw (X) into bottom stop collar (BB). (See Figure 3) 5. Install and tighten two 5/16" x 3/4" set screws (X) through side of mount (DD) and against column.
MCB1U / LCB1U Installation Instructions Attaching Displays to Ceiling Mount 1. Ensure that the latch mechanisms on interface brackets (FF) are already lowered. (See Figure 5) 2. While supporting both sides of display, lower display onto ceiling mount, hooking top of interface brackets onto front of ceiling mount.
Installation Instructions MCB1U / LCB1U Tilt The ceiling mounts allow -5° to 20° tilt. The ceiling mount can be locked at 0°, 5°, 10° and 15° tilt. 4. Loosen two tilt friction screws (located each side). (See Figure 10) 5. Adjust tilt as required. Note specific degrees of tilt. (See Figure 10) 6. Tighten two tilt adjustment screws if NOT using the 0°, 5°, 10° or 15° settings. 7. Repeat for other mounting rail on opposite side of mount.
MCB1U / LCB1U Installation Instructions Installing Covers 1. Install two interface bracket covers (GG) over the top and bottom of each interface bracket. (See Figure 13) NOTE: Be sure to line up tabs inside the bracket covers with 2 3 (W) x 4 holes on sides of interface brackets. (See Figure 13) 1 (GG) 1 (EE) Figure 14 Figure 13 2. Install one side cover (EE) onto side of ceiling mount using two 10-24 x 1/2" flat head screws (W). (See Figure 14) 3. Repeat for other side of ceiling mount. 4.
Installation Instructions MCB1U / LCB1U 11
MCB1U / LCB1U Installation Instructions USA/International Europe Chief Manufacturing, a products division of Milestone AV Technologies 8800-002402 Rev00 2013 Milestone AV Technologies, a Duchossois Group Company www.chiefmfg.com 11/13 Asia Pacific A P F A P F A 6436 City West Parkway, Eden Prairie, MN 55344 800.582.6480 / 952.225.6000 877.894.6918 / 952.894.6918 Franklinstraat 14, 6003 DK Weert, Netherlands +31 (0) 495 580 852 +31 (0) 495 580 845 Office No.
