Datasheet

ITW CHEMTRONICS
®
MSDS #2500-A
Page 2 of 2
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Green Paste Solubility in Water: Negligible
Odor:
Mild Specific Gravity: 1.2
pH:
NA Evaporation Rate: <1
Vapor Pressure:
<0.1 mmHg @ 20°C (Butyl acetate=1)
Percent Volatile:
< 0.5% Boiling Range: >200°F (>93C)
SECTION 10: STABILITY AND REACTIVITY
Stability:
Stable under normal conditions.
Conditions to Avoid:
Storage above 120°F, exposure to light, loss of dissolved air, loss of polymerization, inhibitor, contamination with incompatible materials.
Incompatibility:
Avoid strong oxidizing agents, copper, copper alloys, carbon steel, iron and rust. Avoid strong acids and bases. Also avoid caustics, amines, alkalis
and mercaptans.
Products of Decomposition:
Carbon monoxide, carbon dioxide, oxides of nitrogen and aldehydes
Hazardous Polymerization:
Will not occur.
Conditions to avoid:
Polymerization initiators include peroxides, strong oxidizers or bases. Contamination with strong acids, amines or mercaptans. SECTION 11:
TOXICOLOGICAL INFORMATION
LD50 LD50 LC50 (ppm)
Ingredients (rat) Oral
(rbt) Dermal (rat) Inhalation
Silver (metallic) NA NA NA
Epoxy Resin >10,000 mg/kg >20,000 mg/kg NA
Modified Epoxy Ester NA NA NA
Cancer Information: No ingredients listed as human carcinogens by NTP or IARC
Reproductive effects: none Teratogenic effects: none Mutagenic effects: none
SECTION 12: ECOLOGICAL INFORMATION
Environmental Impact Information
Avoid runoff into storm sewers and ditches which lead to waterways. Water runoff can cause environmental damage.
REPORTING
US regulations require reporting spills of this material that could reach any surface waters. The toll free number for the US Coast Guard National Response Center is:
1-800-424-8802
SECTION 13: DISPOSAL CONSIDERATIONS
Dispose of in accordance with all federal, state and local regulations. Water runoff can cause environmental damage.
SECTION 14: TRANSPORTATION INFORMATION
Air and Ground Shipments:
Adhesives, sealants
Not Regulated
SECTION 15: REGULATORY INFORMATION
SECTION 313 SUPPLIER NOTIFICATION
This product contains no chemicals subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To- Know Act of 1986 (40
CFR 372).
This information should be included on all MSDSs copied and distributed for this material.
TOXIC SUBSTANCES CONTROL ACT (TSCA).
All ingredients of this product are listed on the TSCA Inventory.
WHMIS:
Class D2B
This product has been classified according to the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR.
SECTION 16: OTHER INFORMATION
Normal ventilation for standard manufacturing practices is usually adequate. Local exhaust should be used when large amounts are released.
To the best of our knowledge, the information contained herein is accurate. However, all materials may present unknown hazards and should be used with caution. In
particular, improper use of our products and their inappropriate combination with other products and substances may produce harmful results which cannot be
anticipated. Final determination of the suitability of any material is the sole responsibility of the user. Although certain hazards are described herein, we cannot
guarantee that these are the only hazards that may exist.