® charnwood C-SERIES Operating & Installation Instructions
CONTENTS O P E R AT I N G I N S T R U C T I O N S Fuel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Fitting The Riddling Grate . . . . . . . . . . . . . . 4 Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Controlling The Fire . . . . . . . . . . . . . . . . . . . 5 Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Ash Clearance . . . . . . . . . . . . . . . . . . . . . . . 5 Reduced Burning . . . . . . . . . . . . . . . . . . . . . 6 Maintenance . .
OPERATING INSTRUCTIONS ® Congratulations on becoming the owner of a HETAS approved These appliances have been approved by HETAS as intermittent Charnwood C-Series Stove. Your stove has been approved by DEFRA operating appliances for burning dry seasoned wood logs only. to burn wood logs in a smoke control area if it is used in accordance HETAS approval does not cover the use of other fuels either alone or with these instructions.
OPERATING INSTRUCTIONS ® Open the air control fully (boost position) when lighting or when LIGHTING rapid burning is required. It should not be left fully open for long On initial lighting, the stove may smoke and give off an odour as the periods as this can cause over-firing or excessive smoke production. silicon paint with which the firebox is painted reacts to the heat.
OPERATING INSTRUCTIONS ® REDUCED BURNING frayed and replace them when necessary. For reduced burning the fire door must be closed. Servicing When burning wood in areas that are not smoke controlled, load It is recommended that the fire is serviced once a year to keep it in some large logs on the fire and allow to burn for half an hour before first class working order.
OPERATING INSTRUCTIONS ® possible, do not try to fit too much fuel into the firebox. outlet or vertical rear flue connector is used it will generally be possible to sweep the chimney through the appliance. d) Do not completely close the air control. First remove the fuel retainer and the throat plate. Then sweep the It is always more difficult to keep the glass clean when running the chimney ensuring that soot is removed from all horizontal surfaces stove very slowly for long periods.
OPERATING INSTRUCTIONS ® then be cleaned. If the chimney fire does not go out when the above action is taken then the fire brigade should be called immediately. After a chimney fire the chimney should be carefully examined for any damage. Expert advice should be sought if necessary. CO ALARM Your installer should have fitted a CO alarm in the same room as the appliance. If the alarm sounds unexpectedly, follow the instructions given under “Warning Note” above.
INSTALLATION INSTRUCTIONS ® UNPACKING THE STOVE appliances, flues and chimneys must also be observed. The stove arrives bolted and shrink-wrapped to its pallet.
INSTALLATION INSTRUCTIONS ® Fig. 4. Vertical Register Plate With Bricked Up Fireplace either square or round and MUST NOT BE LESS THAN 125 mm (5") for C-Four and C-Five or 150mm (6") for C-Six, C-Seven and C- Soot Door In Side or Rear Of Chimney Eight. If an existing chimney is to be used it must be swept and checked, it must be in good condition, free from cracks and blockages, and Register Plate should not have an excessive cross sectional area.
INSTALLATION INSTRUCTIONS ® Fig. 7. Horizontal Register Plate With Optional Vertical Rear Flue Connector be more in length than the flue diameter. The stove comes with the blanking plate fitted to the top flue outlet. The seal for the top outlet is a 180mm dia ring of rope seal. The seal Alternative Soot Door Positions for the rear outlet is a length of adhesive backed fibre webbing supplied with instructions.
INSTALLATION INSTRUCTIONS ® SOOT DOORS areas have been "authorised" in Regulations and that appliances used to burn solid fuel in those areas (other than "authorised" fuels) have It is possible to pass a 16 inch diameter sweeps brush through the been exempted by an Order made and signed by the Secretary of appliance but in most back outlet installations it will be necessary to State or Minister in the devolved administrations. have a soot door to enable the chimney to be swept.
14 A.J WELLS & SONS LTD Bishops Way, Newport, Isle of Wight PO30 5WS, United Kingdom A Division of A.J.Wells & Sons Limited Registered in England No. 03809371 CE Certificate for compliance with EN13240:2001 and UK HETAS requirements. EN13240:2001 C SERIES ROOMHEATERS FIRED BY SOLID FUEL C Four C Five C Six C Seven C Eight BR080-CPD-2011 NR080-CPD-2012 CR080-CPD-2012 ER080-CPD-2012 DR080-CPD-2012 WOOD LOGS WOOD LOGS WOOD LOGS WOOD LOGS WOOD LOGS Emission of CO in combustion products: 0.
C-FOUR DIMENSIONS (mm) ® 82 114 154 131 373 405 Plan View 140 i/d to suit 125mm (5") flue pipe Optional Vertical Rear Flue Adapter Standard Model 416 613 144 560 458 84 45 267 386 64 OD 61 ID 416 763 710 Store Stand 608 195 150 386 Front 262 Side 14 Rear
C-FIVE DIMENSIONS (mm) ® 82 114 153 130 430 398 Plan View 140 i/d to suit 125mm (5") flue pipe Optional Vertical Rear Flue Adapter 485 Standard Model 611 144 560 458 65 292 455 79 76 Store Stand 485 796 745 643 250 185 455 Front 292 Side 15 Rear
C-SIX DIMENSIONS (mm) ® 88 131 169 146 441 398 Plan View Standard Model 441 670 156 i/d to suit 150mm (6") flue pipe Optional Vertical Rear Flue Adapter 161 615 505 119 411 63 292 79 To suit 80mm ducting Store Stand 441 855 690 800 185 411 Front 292 Side 16 Rear
C-SEVEN DIMENSIONS (mm) ® 85 130 169 146 440 398 Optional Vertical Rear Flue Adapter 156 i/d to suit 150mm (6") flue pipe Standard Model 564 160 670 615 505 292 534 59 76 79 OD Store Stand 564 855 800 690 244 185 529 292 Front Side 17 Rear
C-EIGHT DIMENSIONS (mm) ® 88 133 169 146 398 443 500 Optional Vertical Rear Flue Adapter 156 i/d to suit 150mm (6") flue pipe 163.
C-FOUR PARTS LIST ® Issue N 7 6 7 7 7 8 Optional Grate Kit 51 53 42 13 37 11 44 47 48 49 46 12 52 7 45 15 7 43 9 40 41 38 19 3 39 15 31 17 25 14 10 30 5 16 29 20 34 24 28 27 26 18 23 33 21 32 22 36 35 Item Part No. Description Item Part No.
C-FIVE PARTS LIST ® Issue H 61 59 45 21 Optional Grate Kit 19 7 10 20 11 11 54 9 53 18 57 55 8 56 52 11 50 48 51 60 46 27 12 39 13 14 6 49 23 22 15 47 16 33 17 4 25 41 38 28 36 24 42 35 26 40 34 37 31 29 30 44 32 43 Item Part No. Description Item Part No.
C-SIX PARTS LIST ® Issue L 6 11 Optional Grate Kit 9 47 51 54 52 7 57 58 42 18 8 53 10 49 17 15 16 56 48 50 12 46 13 43 14 5 3 19 24 21 36 20 34 45 44 22 35 32 30 31 25 33 28 38 26 39 23 37 41 40 27 29 Item Part No. Description Item Part No.
C-SEVEN PARTS LIST ® Issue F Optional Grate Kit 49 60 59 20 44 53 19 54 6 18 51 7 10 17 55 8 9 47 11 13 56 26 50 52 48 58 45 46 12 14 5 38 36 37 15 3 35 27 16 40 32 23 30 25 41 33 39 31 34 22 43 24 42 21 Item Part Number Description 1* 1a* 2* 3 4* 5 6 7 8 9 10 11 12 13 14 15 16 17 17a* 18 19 20 21 22 23# 24 25 26 27 28 29 30 008/ER003 008/ER038 008/FW29 006/ER019 008/ER044 004/KV23 010/ER031 004/XV30 008/FFB004 010/ER036 011/ER030/S 010/ER029 010/ER028 004/DY22 01
C-EIGHT PARTS LIST ® Issue F 9 11 7 6 8 10 Optional Grate Kit 9 47 18 58 42 53 54 49 57 17 15 51 16 52 50 56 48 46 45 5 12 3 44 43 24 13 37 29 21 14 36 20 34 19 32 35 22 41 38 23 40 39 33 30 31 25 28 27 26 Item Part No. Description Item Part No.
REV.C-Series v2 09.14 your premier dealer charnwood BISHOPS WAY, NEWPORT, ISLE OF WIGHT PO30 5WS, UNITED KINGDOM T: + 4 4 ( 0 ) 19 8 3 5 3 7 7 7 7 • F : + 4 4 ( 0 ) 19 8 3 5 3 7 7 8 8 • C O N TA C T U S AT W W W. C H A R N W O O D . C O M ® A D i v i s i o n o f A . J . We l l s & S o n s L i m i t e d Re g i s t e r e d i n E n g l a n d N o .
