Use and Care Guide
INSTALL DRAIN CAP
13
Install cap lanyard around drain plug. Screw drain cap
(C-5) on drain plug.
OPERATION
The pumping system draws solution from the tank, through the strainer and to
the pump. The pump forces the solution under pressure to the spray wand.
The pump has a pressure switch which will shut the pump off when it reaches
60 PSI.
Pressure may be regulated by opening or closing the bypass
valve located on the top of the tank. The more it is opened, the
lower the pressure will be.
Regularly inspect the suction supply screen on the inside of the tank.
Flush with water to clear any accumulated debris.
AFTER SPRAYING
After use, ll the sprayer part way with water. Start the sprayer and allow clear
water to be pumped through the plumbing system and out through the spray
wand.
Rell the tank about half full with plain water and use a chemical neutralizer
and repeat cleaning instructions. Flush the entire sprayer with the neutralizing
agent. Follow the chemical manufacturer’s disposal instructions of all wash or
rinsing water.
WARNING: Some chemicals will damage the pump valves if allowed to soak untreated for a long period of time. Always ush the pump with water after
use. Do not allow chemicals to sit in pump for extended times of idleness. Follow chemical manufacturers instructions on disposal of all waste water from
the sprayer.
WINTER STORAGE
Drain all water and chemical out of sprayer, paying special attention to pump and valves. These items are especially prone to damage from chemicals
and freezing weather.
The sprayer should be winterized before storage by pumping a solution of RV antifreeze through the entire plumbing. Proper care and maintenance
will prolong the life of the sprayer.
2E
C-5
— VALVE OPERATION
To Spray Wand
Relief Hose to
top of tank
This lever adjusts the system
pressure by relieving liquid
back to the tank. Adjusting this
lever will increase or decrease
pressure to the Spray Wand or
the Spray Boom
Pump
This lever turns the Spray
Boom on and off
To Spray Boom (if equipt)
Bypass Valve