DOCUMENTATION HANDBOOK PHONTECH CIS 3100 / 3101 / 3102 COMMAND INTERCOM SYSTEM www.jotron.
CIS 310X Handbook contents: SYSTEM / MASTER STATIONS: COMMAND INTERCOM SYSTEM 310X Handbook page: System Description ……...…………………………………………… 08300-007-DE Mechanical Layout, 3100, Master Station 5L ..........................…..… 08300-001-ML Mechanical Layout, 3101, Master Station 10L ..........................…..… 08300-002-ML Mechanical Layout, 3102, Master Station 20L ..........................…..… 08300-003-ML External Connection , 3100, Master Station 5L …...........................
External Connection …................................………………………… 02900-005-EC ..………… 53 ACCESSORIES: 0005, HEADSET Mechanical Layout …........................….………….……………….. 87000-027-ML .………… Internal wiring / External Connection ….....………………………… 87000-027-IW ..………… 54 55 9017, HANDHELD MICROPHONE w/PLUG Mechanical Layout …........................….………….……………….. 96900-017-ML .………… Internal wiring / External Connection ….....………………………… 96900-017-IW ..
Handbook page 3/71 Doc.No.: 08300-007-DE 0 REV No: 081027 ISSUE DATE FINAL DOKUMENTATION REASON FOR ISSUE CD PREPARED CHECKED APPROVED TITLE: CIS SYSTEMS MASTER STATION SERIES 310X VERSION 05827 Description / Beskrivelse This document is the property of PHONTECH and must not be copied or shown to a third person without our written acceptance. In the interest of product improvement, PHONTECH reserves the right to alter specification and design without notice.
Handbook page 4/71 Doc.No.: 08300-007-DE CONTENTS. 1.0 INTRODUCTION / INTRODUKSJON 2.0 GENERAL DESCRIPTION / GENERELL BESKRIVELSE 3.0 FACILITY LIST / FUNKSJONER OG MULIGHETER 4.0 MOUNTING / INSTALLATION / SCREEN CONNECTION. MONTERING / INSTALLASJON OG SKJERM TERMINERING 5.0 CABLE REQUIREMENTS / KRAV TIL KABEL 6.0 SELECTIVE CALLS / SELEKTIVE ANROP 7.0 ALL CALL / ALLEKALL(FELLESANROP) 8.0 BRIDGE WING - EXTERNAL PAGING BROVING - EKSTERNT AKTIVERT ANROP 9.0 PRIORITY / PRIORITET 10.
Handbook page 5/71 Doc.No.: 08300-007-DE 1.0 INTRODUCTION / INTRODUKSJON Eng.: A command intercom system (CIS) consist of one MASTER station (3100 series), most often located on the ships bridge, and distributed SUBSTATIONS (9000 series) in cabins, engine room, engine control room a.s.o. The CIS may also comprise port and starboard side BRIDGE WING stations. The CIS may also be interconnected with the PHONTECH small public address and alarm system (SPA).
Handbook page 6/71 Doc.No.: 08300-007-DE CIS leveres som følger: MASTER STASJONER: - 3100 CIS MASTER STASJON maks. 5 linjer. Forsterker kapasitet 10 W. - 3101 CIS MASTER STASJON. maks. 10 linjer. Forsterker kapasitet 20 W. - 3102 CIS MASTER STASJON. maks. 20 linjer. Forsterker kapasitet 40 W. UNDERSTASJONER/UTSTYR: - 9001 understasjon for lugar/ oppholdsrom. - 9003 understasjon for hodesett med rele. - 9004 oppkallsenhet for høyttaler, værsikker. - 9009 kalleenhet for bærbar høyttaler, værsikker.
Handbook page 7/71 Doc.No.: 08300-007-DE - External loudspeaker output connections. OPTIONS. - Line engagement time out. - Optional extra signal organ output for all lines (up to 10) - Optional line amplifier connection. - Gooseneck/handheld microphone connection. No.: CIS 3100: - Tilkobling for 5 understasjoner. CIS 3101: - Tilkobling for 10 understasjoner. CIS 3102: - Tilkobling for 20 understasjoner.
Handbook page 8/71 Doc.No.: 08300-007-DE FIGURE 1 / FIGUR 1 4.0 MOUNTING / INSTALLATION / SCREEN CONNECTION MONTERING / INSTALLASJON OG SKJERMTERMINERING Eng.: MOUNTING: The master stations 3100/3101/3102 is delivered for flush mounting. On request the units may be delivered with wall-mounting box. (option) Front plate dimensions 3100 and 3101: 3102: Cut- out dimensions for flush-mounting 3100 and 3101: 3102: Depth, all types flush mounted: wall mounted: 144 x 144 mm. (HxW) 144 x 192 mm.
Handbook page 9/71 Doc.No.: 08300-007-DE The master station location/ orientation with regards to the operator must be taken especially into consideration. Please note the gooseneck mic (if installed) is "close talk". A close talk microphone has the ability to reduce surrounding noise to a minimum. The drawback is that the operator has to speak no more than 5-10 cm away from the microphone. SCREEN CONNECTION.
Handbook page 10/71 Doc.No.: 08300-007-DE FIGURE 2 / FIGUR 2 Eng.: The cable outer screens is to be terminated as shown. Conductive type of cable ties is recommended to obtain best possible screen connections. No.: Kabelens ytterskjerm skal termineres som vist. Festebånd av ledende materiale bør benyttes for å oppnå best kontakt mellom skjerm og chassis. 5.0 CABLE REQUIREMENTS / KRAV TIL KABEL Eng.: To substations: one pair, twisted, outer screen. If extra signal organ: one pair extra.
Handbook page 11/71 Doc.No.: 08300-007-DE Consult drawings 97301-007-EC (CIS 3100), 97301-002-EC (CIS 3101) and 97301-013-EC (CIS 3102) for further cabling information. No.: Til understasjoner: ett par revolvert, utvendig skjermet. Ved ekstra signal organ: et ekstra par. Til broving: to par, individuelt revolvert, utvendig skjerm. Kraft kabler: ett par, jord. Minimum tverrsnitt alle typer: 0,75 mm2. VIKTIG: FOR Å SIKRE UFORSTYRRET DRIFT, IKKE KOMBINER SIGNAL KABLER MED KABLER FOR ANNET UTSTYR SOM F.EKS.
Handbook page 12/71 Doc.No.: 08300-007-DE 6.3 A SUBSTATION ANSWER THE CALL FROM THE MASTER / UNDERSTASJONEN SVARER PÅ ANROP FRA HOVEDSTASJON Eng.: When the attention tone is heard in the loudspeaker and / or the extra signal organ is activated: - Press the talk-key and answer the call. - Keep the TALK key pressed all time during the conversation. No.: Når oppmerksomhetstonen høres i høyttaleren / eller ekstra signal giver aktiveres: - Trykk på TALK knappen for å svare oppkallet.
Handbook page 13/71 Doc.No.: 08300-007-DE 6.7. TERMINATING THE CONVERSATION / AVSLUTTE SAMTALEN Eng.: The conversation is terminated by de-activating the line: - Operate the line key once more. The line indicator led turn green half-light intensity. (backlight) No.: Samtalen avsluttes ved å legge linjen ut igjen: - Trykk linjeknappen en gang til. Lysdioden skifter til grønt baklys (hvilestilling). 7.0. ALL CALL / ALLEKALL Eng.
Handbook page 14/71 Doc.No.: 08300-007-DE - The master station normally has first priority. - If the external emergency paging is enabled this will have an intermediate first priority and override existing calls. After this first priority override activation the master station regains priority and can place calls of any type. No.: - Hovedstasjonen har normalt første prioritet.
Handbook page 15/71 Doc.No.: 08300-007-DE Current drain / strømtrekk: 2 A max. Line capacity / linjekapasitet: Power amp. capacity / forsterkerkapasitet: 10 lines. 20 W total Up to 10 W per line. Frequency range / frekvens område: Distortion / forvrengning: Better than 400-6000 Hz (-3dB) Better than 2.5% typ.
Handbook page 16/71 Doc.No.: 08300-007-DE 14.0 SYSTEM BOARD 97301-001 (CIS 3100/3101) STRAPPING AND CONNECTION POINT LOCATIONS / LOKALISERING AV LINKER OG KONTAKTPUNKTER. J2 Terminal / pin No. - J2 Terminal / pin. nr.
Handbook page 17/71 Doc.No.: 08300-007-DE FIGURE 3 / FIGUR 3 ST 3 PROGRAM SELECTOR NORM OPEN CLOSED WHEN STB BW INPUT IS USED F. ALLCALL ST1 CLOSED WHEN EXT. MIC. IS USED ST2 CLOSED WHEN INTERNAL MIC IS USED CONNECTION PIN 7/8 FOR EXT. MIC PTT CONNECTION PIN 5/6 FOR EXT. MIC 1 ST2 ST1 ST3 1 + ST5 ST7ST6 ST4 + + MICROCONTROLLER RESET ALWAYS OPEN + + + + + 1 file:\..\strapbes.drw PHONTECH 97301-001.MK.1.
Handbook page 18/71 Doc.No.: 08300-007-DE 15.0 SYSTEM BOARD 97301-011 (CIS 3102) STRAPPING AND CONNECTION POINTS LOCATION / LOKALISERING AV LINKER OG KONTAKTPUNKTER. J3 Terminal / pin No. - J3 Terminal / pin. nr. 1&2 3&4 5&6 7&8 Function / Equipment Volume potensiometer Unit loudspeaker Microphone TALK activator Funksjon / tilkoblet utstyr Volum potensiometer Apparat høyttaler Mikrofon element Tale knapp Ref. strap descriptions under chapter 14.0 Ref. link beskrivelser under kapittel 14.
Handbook page 19/71
Handbook page 20/71
Handbook page 21/71
Handbook page 22/71
Handbook page 23/71
Handbook page 24/71
Handbook page 25/71
Handbook page 26/71
Handbook page 27/71
Handbook page 28/71
Handbook page 29/71
Handbook page 30/71
Handbook page 31/71
Handbook page 32/71
Handbook page 33/71
Handbook page 34/71
Handbook page 35/71
Handbook page 36/71
Handbook page 37/71
Handbook page 38/71
Handbook page 39/71
Handbook page 40/71
Handbook page 41/71
Handbook page 42/71
Handbook page 43/71
Handbook page 44/71
Handbook page 45/71
Handbook page 46/71
Handbook page 47/71
Handbook page 48/71
Handbook page 49/71
Handbook page 50/71
Handbook page 51/71
Handbook page 52/71
Handbook page 53/71
Handbook page 54/71 PHONTECH
Handbook page 55/71
Handbook page 56/71
Handbook page 57/71
Handbook page 58/71
Handbook page 59/71
Handbook page 60/71
Handbook page 61/71
Handbook page 62/71 HP-10(T) ISO 9001 CERTIFIED N-3770 Kragerø NORWAY Phone: ........ (47) 35 98 56 00 Fax: ............ (47) 35 98 56 10 E-mail: .............. dnh@dnh.no Web-site: ....... www.dnh.no DNH WW Ltd. England Phone:….(44) 1908 275 000 Fax:……..(44) 1908 275 100 E-mail:………dnh@dnh.co.uk DNH GmbH Germany Phone:…..….(49) 040 6569 30-0 Fax:……...…(49) 040 6569 30-30 E-mail:…………………dnh@dnh.de DNH France Phone:……(33) 1 5380 0276 Fax:…….…(33) 1 4588 1594 E-mail:…..…etienne@dnh.
Handbook page 63/71 ISO 9001 CERTIFIED HP-15(T) N-3770 Kragerø NORWAY Phone: ........ (47) 35 98 56 00 Fax: ............ (47) 35 98 56 10 E-mail: .............. dnh@dnh.no Web-site: ....... www.dnh.no DNH WW Ltd. England Phone:….(44) 1908 275 000 Fax:……..(44) 1908 275 100 E-mail:………dnh@dnh.co.uk DNH GmbH Germany Phone:…..….(49) 040 6569 30-0 Fax:……...…(49) 040 6569 30-30 E-mail:…………………dnh@dnh.de DNH France Phone:……(33) 1 5380 0276 Fax:…….…(33) 1 4588 1594 E-mail:…..…etienne@dnh.no DNH Speakers Inc.
Handbook page 64/71 HP-20(T) 44 ISO 9001 CERTIFIED N-3770 Kragerø NORWAY Phone: ........ (47) 35 98 56 00 Fax: ............ (47) 35 98 56 10 E-mail: .............. dnh@dnh.no Web-site: ....... www.dnh.no DNH WW Ltd. England Phone:….(44) 1908 275 000 Fax:……..(44) 1908 275 100 E-mail:………dnh@dnh.co.uk DNH GmbH Germany Phone:…..….(49) 040 6569 30-0 Fax:……...…(49) 040 6569 30-30 E-mail:…………………dnh@dnh.de DNH Speakers Inc. USA Phone:………….(1) 484 494 5790 Fax:……………..(1) 484 494 5793 E-mail:…dnh@dnhspeakers.
Handbook page 65/71
Handbook page 66/71
Handbook page 67/71
Handbook page 68/71
Handbook page 69/71
Handbook page 70/71 DSP-15 EExmN(T) ISO 9001 CERTIFIED N-3770 Kragerø DNH WW Ltd. NORWAY England Phone: .........(47) 35 98 56 00 Fax:.............(47) 35 98 56 10 E-mail: ...............dnh@dnh.no Web-site: ........ www.dnh.no Phone:….(44) 1908 275 000 Fax:……..(44) 1908 275 100 E-mail:………dnh@dnh.co.uk DNH GmbH Germany Phone:…..….(49) 040 6569 30-0 Fax:……...…(49) 040 6569 30-30 E-mail:…………………dnh@dnh.de DNH Speakers Inc. USA Phone:………….(1) 484 494 5790 Fax:……………..
www.jotron.
