Corp. ICED TEA MODULAR BREWER AND DISPENSER SYSTEM FTC-5, FTC-10

11
PROBLEM PROBLEM CAUSES REMEDIES
NO WATER WHEN BREW
SWITCH IS ACTIVATED
A) DISPENSER UNPLUGGED
B) CIRCUIT BREAKER OFF OR TRIPPED
C) POWER SWITCH OFF
D) INOPERATIVE DISPENSE SWITCH
E) INOPERATIVE TIMER
F) HOT WATER TANK NOT FULL
G) WATER SUPPLY OFF
H) INLET SCREEN PLUGGED
I) INOPERATIVE INLET WATER VALVE
J) LOOSE ELECTRICAL CONNECTION
A) PLUG IT IN
B) RESET BREAKER
C) PRESS “RED” POWER SWITCH
D) REPLACE SWITCH
E) REPLACE TIMER
F) REFER TO TANK FILLING INSTRUCTIONS
G) TURN ON WATER
H) REMOVE SCREEN AND CLEAN
I) REPALCE WATER VALVE
J) CHECK ALL ELECTRICAL CONNECTIONS FOR
CONTACT
WATER DOES NOT SHUT OFF A) LEAKING INLET WATER VALVE
B) BREW SWITCH STUCK
C) FAULTY TIMER
A) REPLACE VALVE
B) REPLACE SWITCH
C) REPLACE TIMER
WATER LEAKS FROM TANK
VENT TUBE
A) DILUTION TUBE BLOCKED OR LIMED UP
B) VACUUM TEE PLUGGED
A) REMOVE TUBE AND
CHECK FOR BLOCKAGE
B) REMOVE TEE AND
CHECK FOR BLOCKAGE
WATER FROM SPRAY HEAD
NOT HOT
A) HEATER SWITCH IN “OFF” POSITION
B) INOPERATIVE THERMOSTAT
C) INOPERATIVE HEATING ELEMENT
D) INOPERATIVE HIGH LIMIT
E) LOOSE ELECTRICAL CONNECTION
A) TURN ON SWITCH
B) REPLACE THERMOSTAT
C) REPLACE HEATING ELEMENT
D) REPLACE HIGH LIMIT
E) CHECK ALL ELECTRICAL CONNECTIONS
TEA TOO WEAK A) TOO MUCH WATER (IN EXCESS OF 3 GALLONS)
B) ADJUSTOR ASSEMBLY OUT OF ADJUSTMENT
C) BREW WATER NOT ENOUGH
D) SPRAY HEAD LIMED UP
A) TURN TIMER COUNTER-CLOCKWISE AND REBREW.
REPEAT UNTIL DESIRED STRENGTH IS ACHIEVED
B) REFER TO ADJUSTOR ASSEMBLY INSTRUCTIONS
C) TURN UP THERMOSTAT
D) REMOVE SPRAY HEAD AND DELIME.
WHEN REPLACING SPRAY HEAD. TIGHTEN
ONLY WITH FINGERS
TEA TOO STRONG A) NOT ENOUGH WATER (LESS THAN 3 GALLONS) A) TURN TIMER KNOB COUNTER-CLOCKWISE
AND RE-BREW. REPEAT UNTIL DESIRED
STRENGTH IS ACHIEVED
WATER BOILS A) MALFUNCTIONING THERMOSTAT
B) THERMOSTAT NOT CONTACTING TANK
A) REPLACE THERMOSTAT
B) TIGHTEN RETAINING NUTS
FUNNEL OVERFLOWS A) ADJUSTER ASSEMBLY SET TOO HIGH
B) BREW FUNNEL CLOGGED
A) REFER TO ADJUSTOR ASSEMBLY INSTRUCTIONS
B) REMOVE RESTRICTOR SCREEN ASSEMBLY &
CLEAN
TROUBLE SHOOTING GUIDE FOR FTC BREWERS