GRX-1175R Remote Control Golf Cart User Manual
Remote Control Golf Cart User Manual Index 1 Introduction 2 Identification – main components 3 Assembly 4 Handle and LED display 5 Operating functions and modes 6 Handset operation 7 Drive wheels 8 Use and maintenance 9 Troubleshooting 10 Safety 11 Contact details Page 1 of 17
Remote Control Golf Cart User Manual 1 Introduction Thank you for purchasing this golf cart. Please read this manual carefully before use. After unpacking please keep the carton and all internal sections in safe storage. In the unlikely possibility that you need to return the whole unit due to a defective component, you will need to repack the unit in the original manner to ensure safe and secure transit. Check all components are included in the package – • Main cart frame.
Remote Control Golf Cart User Manual 2 Main component identification 1 LCD Display 5 Central hinge lock 9 Drive Wheel 2 Handle 6 Bag strap 10 Stabilizer wheel 3 Bag strap 7 Lower bag support 11 Motor/Gearbox 4 Upper Bag Support 8 Front wheel assembly 12 Battery Page 3 of 17
Remote Control Golf Cart User Manual 3 Assembly Take cart and all of component parts out of carton Slide and hold the knob on the centre hub cap and push the wheel fully on to the axle Pull spring bolt then install support wheel .
Remote Control Golf Cart User Manual Pull the lock device and then raise the frame support (wishbone) into the upright position Lift the main frame upwards to meet the frame support. Engage the slots in the hinge with the metal bar on the frame support.
Remote Control Golf Cart User Manual Lift the upper handle frame up and over the central locking hinge. Depress the metal catch and ensure that the hinge is locked in position around the frame support bar. Ensure that the locking catch is fully engaged by pulling the upper part of the catch outwards if necessary. Pull down the upper bag support. The cart is now ready to receive the battery and golf bag.
Remote Control Golf Cart User Manual Put the battery into the battery case.
Remote Control Golf Cart User Manual After playing or when the under voltage indicator is on: Disconnect the battery lead going to the controller Remove the battery case and the battery from the cart or move the cart next to the AC outlet To prolong the service life of the battery, Please: Charge the battery after every use of the cart Charge the battery frequently. When the cart is not in use for an extended period if time, you should charge the battery once a month.
Remote Control Golf Cart User Manual 5 Operating functions and Modes 1 On/Off. Depress the on/off switch for 3 seconds then release till the LED display illuminates. 2 Press and hold for 3 seconds to turn the cart OFF. Display units. Alter between Metric and Imperial units of speed and measurement. Click the left-hand red button to make the change. 3 Mode Selection. Click the right-hand red button to change progressively between operational modes.
Remote Control Golf Cart User Manual MODE 2 Displays distance traveled during a particular period. In this mode the hand transmitter can instruct the cart to go forward – to stop – turn left or right – but not to reverse MODE 3 Preset Distance Control. Cart will travel for the distance pre-set into the panel. When in this mode, turn the central round red knob progressively to input required distance - then press this same button to start the cart. The speed can be adjusted whilst it is running.
Remote Control Golf Cart User Manual MODES 6 – 7 – and 8 - please see section at end – above Troubleshooting. 6. Handset Operation Five buttons in the middle of the remote control transmitter. The left direction arrow turns the cart to the left The right direction arrow turns the cart to the right The “Up” direction button makes the cart walking forward. It also provides acceleration.9 step to accelerate forward. Press this button each time, golf caddies accelerate once, reach to top speed.
Remote Control Golf Cart User Manual Start Up Remote System When using the remote function first time, you must establish the connection between handset and controller. During the first 3 seconds when you start the golf cart, press any button on the handset until golf cart starts moving. The remote system will then be active. Adjustment function： The two top buttons marked with SET and SAVE are be used if it is necessary to adjust the alignment of the cart.
Remote Control Golf Cart User Manual Transmitter use • Your transmitter has been designed for ease of use whether you are left or right handed. • Take time to practice the difference between a single touch of a key and a prolonged push especially with left and right functions. • Never store the transmitter in a pocket with metal or sharp objects, or loose change. Never allow the transmitter to get immersed in water.
Remote Control Golf Cart User Manual When the voltage of the battery is too low to operate the cart (below 10.8 volts) the controller will cut power supply to the motors. In order to push the cart manually it is necessary to move the wheels out by one notch on the drive axle. If you want to pull the cart you will also need to change the wheels over to the other side of the cart. Securely locate part A (the drive coupling) into part B (the wheel hub) for the normal drive connection.
Remote Control Golf Cart User Manual 7) If the battery is to be stored – for instance over winter – and not used it can be disconnected. If disconnected for storage always recharge the battery completely at intervals – at least once every 30 to 45 days. Allowing the charge of the battery to drop to a completely exhausted state can shorten the life of the battery. 8) Do NOT charge the battery with a different charger than the unit supplied with the cart.
Remote Control Golf Cart User Manual Please reduce the weight of the load and minimize this situation. 9 Troubleshooting The following is general information for the customer. If you have a persistent problem always call the service department. It will always help if you can tell them the sequence and condition of the LED lights. Indication Possible cause With the ON/OFF switch turned ON – Bad wire connection.
Remote Control Golf Cart User Manual Waste electrical products must not be disposed of with the household waste. This tool should be taken to your local recycling centre for safe treatment 11． ．Contact details: http://www.carttek.com Cart-Tek Golf Carts Bend, Oregon 866-356-2278 email: carttek@mac.
