Amplifier Installation & Operating Manual

ManualsBrandsCarson ManualsAmplifierSA-400-73 PG

TB0322B Page 1 of 8 10/18/03

Carson Manufacturing Co., Inc.

5451 North Rural Street

Indianapolis, IN 46220

Phone: (888) 577-6877 Fax: (317) 254-2667

www.carsonsirens.com

TECHNICAL BULLETIN

RADIO

HORN

MAN

WAIL

ELP

PHASER

SIREN

SA400

OFF

INSTALLATION AND

OPERATING MANUAL

SA-400-73 WITH SQUARE FLAT SIREN BUTTON

(OLD VERSION)

SA-400-73 14V

SA-400-73 28V

SA-400-73 PG (Positive GND)

Carson is a trademark of Carson Manufacturing Company, Inc.

Sound Hazard - Sound level from siren speaker (>120dBA @ 10 feet) may cause hearing damage.

Do not operate siren without adequate hearing protection for you and anyone in immediate vicinity.

(Ref. OSHA 1910.95 for occupational noise exposure guidelines)

Summary of content (8 pages)

PAGE 1
Carson Manufacturing Co., Inc. 5451 North Rural Street Indianapolis, IN 46220 Phone: (888) 577-6877 Fax: (317) 254-2667 www.carsonsirens.com TECHNICAL BULLETIN RADIO SIREN HORN SA400 PA VOL MAN WAIL YELP ON OFF PHASER INSTALLATION AND OPERATING MANUAL SA-400-73 WITH SQUARE FLAT SIREN BUTTON (OLD VERSION) SA-400-73 14V SA-400-73 28V SA-400-73 PG (Positive GND) Carson is a trademark of Carson Manufacturing Company, Inc.
PAGE 2
SA-400-73 (old version) INPUT POWER: SIREN MODE OUTPUT POWER: AUDIO MODE OUTPUT POWER: SIREN FREQUENCY: CYCLE RATES: AUDIO RESPONSE: SPECIFICATIONS 11-16 Volts DC, 8 Amps DC per 100W Speaker (SA-400-73 14,PG) 22-32 Volts DC, 4 Amps DC per 100W Speaker (SA-400-73 28) 15 VDC input, 100W speaker(s) (SA-400-73 14,PG) 30 VDC input, 100W speaker(s) (SA-400-73 28) One speaker - 105 Watts RMS Two speakers - 180 Watts RMS Rating not available for 58W or 80W speakers 14 VDC input, 100W speaker(s) (SA-400-73 14,PG
PAGE 3
INSTALLATION Proper installation of the unit is essential for years of safe, reliable operation. Please read all instruction before installing the unit. Failure to follow these instructions can cause serious damage to the unit or vehicle and may void warranties. SAFETY PRECAUTIONS For the safety of the installer, vehicle operator, passengers and the community please observe the following safety precautions.
PAGE 4
ELECTRICAL CONNECTIONS Disconnect vehicle battery before making any electrical connections. Electrical connections to the amplifier are made using the wiring harness supplied. If the amplifier needs service the connector can be easily removed without unwiring the harness. The power supply for the amplifier must be capable of delivering peak currents up to 50 amps for adequate short circuit protection and reliable operation. The preferred source is directly at the vehicle battery.
PAGE 5
OPERATION Sound Hazard - Sound level from siren speaker (>120dBA @ 10 feet) may cause hearing damage. Do not operate siren without adequate hearing protection for you and anyone in immediate vicinity. (Ref. OSHA 1910.95 for occupational noise exposure guidelines) RADIO SIREN HORN SA400 PA VOL MAN WAIL YELP ON OFF PHASER The OFF/ON Toggle Power Switch controls the siren power. The siren may be left on any time the vehicle is in operation.
PAGE 6
RADIO VOLUME ADJUST The RADIO VOLUME ADJUST is a one time setting which depends on the radio connected and its normal volume. The siren cover must be removed to access the adjustment. The cover is held in place by a snap-fastener on the back of the unit. While holding the case on the sides press hard with your fingers on the back of the unit. The chassis will slide out the front. Switch siren to RADIO mode and turn on the power.
PAGE 7
SERVICE This unit is designed to provide years of reliable service under even the worst conditions. Many times there may appear to be a problem with the unit when the true problem is in the speaker(s) or improper installation. The following chart shows typical symptoms and possible causes. A blown rear panel fuse doesn't necessarily mean that the unit is bad. If a speaker or speaker lead is shorted this fuse will blow before the unit is damaged. Disconnect the SPKR leads and replace the fuse.
PAGE 8
PARTS 9 4 8 1 RADIO 7 12 SIREN HORN SA400 PA VOL MAN WAIL YELP ON OFF PHASER 11 5 3 6 13 Item 1 3 4 5 6 7 8 9 11 12 13 Part # CP3529 CP3966 CP3571 ES00026-02 CP2560 CP3547 ES00026-03 CP3408 CP4852 CP4853 CP3530 #73 LAMP E85 LAMP 4133 SOCKET CP3570 CP3633 SR3055 2FA53-73 CP3548 CP4119 TB0322B Description Bezel, front panel for SA-400-73 (Membrane switch hole) Bolt, mounting, 1/4-20 X 3/8 (2 required) Bracket, mounting Cable, internal chassis plug wiring harness Cable, external wiring har