Owner's manual

Model 702G/O Advanced gas/oil burners — Instruction manual
Carlin part number MN702GO Rev. 06/23/14
– 6 –
Where appliance instructions differ from this manual, follow the appliance instructions.
2. Prepare site • assemble burner • mount burner
Vent system
Vent/chimney sizing
1. Followalllocalcodeswhensizingtheventandchimney.
2. Refertotheappliancemanufacturer’smanual,whenavailable,forventing
recommendations.
Prepare vent/chimney
1. Secureallmetalventjointswithscrews,followingtheventmanufacturer’s
instructions.Sealalljointsintheventsystemandchimney.Repairma-
sonrychimneyliningandrepairallmortarjointsasneeded.
2. Wheredraftuctuationsarelikely,installadouble-actingbarometricdraft
regulatorintheventpiping.(Thedampermustbelocatedinthesame
spaceastheappliance.)Installamanualresetspillswitchinthetopof
thedraftregulatoroutlet.Wiretheswitchintotheappliancelimitcircuitto
shutofftheappliance/burnerifsustaineddowndraftshouldoccur.Refer
totheappliancemanufacturer’sinstructionmanualforrecommendations
regardingtheneedforabarometricdraftregulator.
3. Providesupportfortheventpiping.Donotresttheweightofanyofthe
ventpipingontheapplianceueoutlet.
Clearances
Check codes, standards and the equipment
manual
• Verifythattheburner/appliancewillmaintainallclearancestocombustible
wallsoroor and allclearancesrequired for service/maintenanceas
requiredintheappliancemanualandapplicablecodes.
Inspect, repair and/or replace vent
system
 Donotinstallthisburnerunlessyouhaveveried
theentireventsystemandtheapplianceareingood
conditionandcomplywithall applicable codes.
And...
 Theventandchimneymustbesizedandcon-
structedinaccordancewithallapplicablecodes.If
intendedforusewithanoilburneraswell,thevent
systemmustcomplywithrelevantcodesforboth
gasandoilring.
 Theventsystemmustnotbepressurizedunless
theventpipingandventsystemaredesignedac-
cordingly.Theventmustprovidedraftatalltimes
(negativepressureinvent).
 Donotinstalloruseanexistingmanualdamperin
theventconnectororvent.
 Donotconnecttheapplianceventconnectortoa
chimneyorventservingareplace,incineratoror
solid-fuel-burningapparatus.
 Inacoldclimate,donotventintoamasonrychimney
thathasoneormoresidesexposedtotheoutside.
Installalistedstainlesssteellinertoventtheue
products.
 Adefectiveventsystemcouldresultinsevereper-
sonalinjury,deathorsubstantialpropertydamage.
Figure 1 Vent and vent connector installations, typical