Installation Sheet
Pg. #3
1. Wooden Joist
2. Approved (CSA for Canada
and UL for U.S.) ceiling fan box
(not provided)
3. Ceiling
4. J-Hook
5. Rubber Gasket
6. Screws & Lock Washers
(set of 4)
7. Mounting Bracket c/w Ground
Wire
8. Outlet Box Screws (not provided)
9. Rubber Ring
10. Lock Pin
11. Hemisphere Jam Screw
12. Hemisphere
13. Upper Motor Housing Screws
& Lock Washers (set of 3 or 4)
14. Downrod c/w Ground Wire
15. Ceiling Canopy
16. Rubber Bushing
17. Bolt
18. Motor Assembly
19. Jam Screws
20. Cotter Pin
21. Flat Washer
22.
With Downrod
Without Downrod
1.
2.
3.
4.
5.
6.
7.
8.
10.
11.
12.
13.
14.
15.
17.
18.
15.
16.
18.
19.
20.
21.
ASSEMBLY DRAWING
Pg. #10
Fig. 1
9.
TROUBLESHOOTING
TROUBLE
SUGGESTIONS
- Check fuses and circuit breakers.
1. Fan will not start - Check wiring connections to fan.
- Check wiring connections in switch housing.
CAUTION: Turn power off for last two items.
2. Fan sounds noisy - Check to make sure that all screws in motor housing are snug.
- Check to make sure that blade bracket screws are tight.
- Check to make sure that marrettes in switch housing
are not rattling against wall of switch housing.
- If fan has a light kit make sure switch housing
screws and set screws are tight.
- Some fan motors are sensitive to signals from solid
state variable controls. If solid state controller is
used, change to an alternative control.
- Allow a 24- hour break- in period to eliminate most noises.
3. Fan wobbles - Check that all blades are screwed firmly into blade brackets.
or shakes
excessively.
- Check that blade brackets are secured firmly to motor.
- Check distance from tip of blades to ceiling.
- Check distance between blade tip to blade tip. All
measurements should be equal.
Loosen blade
screws and position blade until even then re-tighten.
- Check that the downrod hemisphere notch is engaged in canopy.
- Check to make sure that jam screws in downrod are tightened.
- Make sure canopy and mounting bracket are
tightened
securely
to wooden joist.
- Make sure warpage has not occurred in wooden
blades.
Stamped Blade
Brackets
29.
26.
28.
27.
25.
24.
23.
Light Kit
22.
Flat Washer
Fibre Washer
Blade
29.
Motor Screw
Blade Bracket
Blade Bracket Screws
Hex Nut
23.
24.
25.
26.
27.
28.