Installation Guide

 31-11127-2
Conversion to Propane (LP) or Natural Gas
WARNING
Explosion Hazard
'HDWKRUVHULRXVLQMXU\FDQUHVXOWIURPIDLOXUHWRIROORZ
these instructions.
Ŷ 6HUYLFHE\DTXDOLILHGVHUYLFHWHFKQLFLDQRQO\
Ŷ 6KXWRIIJDVVXSSO\DQGGLVFRQQHFWSRZHUEHIRUH
VHUYLFLQJ
Ŷ 5HFRQQHFWDOOJURXQGLQJGHYLFHVDIWHUVHUYLFH
Ŷ 5HSODFHDOOSDUWVDQGSDQHOVEHIRUHRSHUDWLQJ
The pressure regulator and the burner orifices are
factory set for natural gas. To operate the rangetop
ZLWKSURSDQH/3JDVWKHUHJXODWRUDQGEXUQHURULILFHV
PXVWEHFRQYHUWHGE\IROORZLQJWKHVHLQVWUXFWLRQV
WARNING
'RQRWRSHUDWHWKHFRRNWRSEHIRUH
FRQYHUWLQJWKHEXUQHURULILFHVIRUWKHJDVWREHXVHG
)DLOXUHWRGRVRFRXOGFDXVHKLJKIODPHVDQGWR[LF
IXPHVZKLFKFDQUHVXOWLQVHULRXVLQMXU\
1
ORIFICE HOLDER
The rangetop orifice holder
is attached to the under side
of the rangetop near the gas
inlet.
1RWDOORULILFHVSURYLGHG
ZLOOEHXVHG8VHRQO\WKH
orifices specified in the
instructions for your rangetop.
TOOLS YOU WILL NEED FOR
CONVERSION
2
CONVERT THE REGULATOR
'LVFRQQHFWDOOHOHFWULFDOSRZHUDWWKHPDLQFLUFXLW
EUHDNHURUIXVHER[
$ 5HPRYHWKHUHDUYHQW
WULPRQUDQJHVRQO\WR
access the regulator.
The rangetop regulator is
on the left bottom corner.
% 6KXWRIIWKHJDVVXSSO\
E\FORVLQJWKHPDQXDOVKXWRIIYDOYHLQWKHXQLWRU
DWWKHZDOO
& &RQYHUWWKHSUHVVXUHUHJXODWRU
Ŷ8QVFUHZWKHFDSZLWKSOXQJHU
Ŷ3ODFH\RXUWKXPEDJDLQVWIODWVLGHRIWKHSOXQJHU
DQGSUHVVGRZQWRVQDSWKHSOXQJHURXWRIWKHFDS
Ŷ&DUHIXOO\ORRNDWWKHSOXQJHUWRORFDWHWKH1$7RU
SURSDQH/3SRVLWLRQ
Ŷ7XUQWKHSOXQJHU
RYHUVRWKDWWKH
desired gas is
VKRZLQJQHDUWKH
bottom.
Ŷ6QDSWKHSOXQJHU
EDFNLQWRWKHFDS
Ŷ6FUHZWKHFDSEDFN
onto the regulator.
3
CHANGE BURNER ORIFICES
INSTALLATION TIP: )LUVWUHPRYH
all orifices and then start replacing
WKHP7KLVZLOOKHOSWRSUHYHQWWKH
possibility that some may not be
replaced.
$ 5HPRYHWKHEXUQHUJUDWHV
burner caps and burner heads.
% /RRVHQWKHWRSEXUQHURULILFHV
XVLQJDPPQXWGULYHU8VH
small pliers to carefully lift out
the orifices.
The main orifice is
ORFDWHGORZLQWKH
FHQWHURIWKHEXUQHU
ZKLOHWKHVLPPHU
orifice is located
higher beside the
center of the burner.
Installation
Instructions
6DIHW\*ODVVHV
6PDOO)ODW+HDG6FUHZGULYHU
WRPPRU´WLSVL]H
PPORQJ
&UHVFHQW:UHQFK
´DQGPP1XWGULYHUV 6PDOO3OLHUV
´'HHSZHOO
6RFNHW:UHQFK
3KLOLSV
6FUHZGULYHU
DOWN
FOR OFF
NAT
LP
LP
NAT
LP
NAT
NAT
LP
*DVNHWCap
3OXQJHU
3URSDQH/3
3RVLWLRQ
1$7
3RVLWLRQ
3UHVVXUH5HJXODWRU
0DLQ
Orifice
6LPPHU
Orifice
%XUQHUFDS
%XUQHU
head
%XUQHUEDVH
6SDUN
igniter
Griddle
Orifice
Grill
Orifice
%XUQHU2ULILFHV
Rangetop Regulator