Installation Guide

ManualsBrandsBV ManualsBathUltra-Quiet 90 CFM, 0.8 Sone Bathroom Ventilation and Exhaust Fan

INSTRUCTIONS

BATHROOM F

Table of contents

General information and parts

..................................................................

Description, sizes and wiring diagram

...................................................

Specications and dimensions

................................................................. 4

General safety information and warnings

............................................. 5

Installation I (joist mounting)

.......................................................................

Installation II (in existing ceiling)

................................................................

Maintenance and limited warranty

..........................................................

READ AND SAVE THESE INSTRUCTIONS

90 CFM: BV-BF-01

110 CFM: BV-BF-02

Please read these instructions carefully before installing, operating or servicing the fan.

Failure to comply with the instructions contained herein could result in personal injury

or property damage. We recommend that you keep this guide for future reference.

Summary of content (8 pages)

PAGE 1
INSTRUCTIONS BATHROOMFAN 90 CFM: BV-BF-01 110 CFM: BV-BF-02 READ AND SAVE THESE INSTRUCTIONS Please read these instructions carefully before installing, operating or servicing the fan. Failure to comply with the instructions contained herein could result in personal injury or property damage. We recommend that you keep this guide for future reference. Table of contents General information and parts ..................................................................
PAGE 2
General information You have to read the entire instruction guide prior to installing this fan.
PAGE 3
Description This product is designed with a built-in thermal cut-off for safety and long life of the motor. Sizes 12 3/16” (31 cm) 9 ” (23 cm) 12 5/8” (32.07 cm) 3/4” 8 ” (20.3 cm) (1.9 cm) 4” (10.16 cm) 9” (23 cm) 12 5/8” (32.
PAGE 4
Specifications AIR DIRECTION V HZ DUCT DIAMETER NOISE (SONE) POWER 90 CFM 120 60 4” (10.16 cm) 0.8 24 W 110 CFM 120 60 4” (10.16 cm) 1.2 30 W SPEED (RPM) AIR DELIVER AT 0.1” WG (CFM) WEIGHT 1000 90 CFM 9.2 lb (4.18 kg) 1160 110 CFM 9.2 lb (4.18 kg) Dimensions CEILING OPENING L CEILING OPENING W CEILING OPENING D HOUSING DIMENSION L HOUSING DIMENSION W HOUSING DIMENSION D 9.4 ” (24 cm) 9.4 ” (24 cm) 8.23 ” (20.9 cm) 9” (23 cm) 9” (23 cm) 7.6 ” (19.
PAGE 5
General safety information and warnings 1. Electric service supply must be 120 V 60 Hz 2. Follow all local safety and electrical codes as well as Canadian Electrical Code and CSST. 3. This unit must be properly grounded. 4. Always disconnect the power supply prior to servicing the fan, motor or junction box. 5. Do not bend or kink the power wires. 6. Do not install where the room air temperature will exceed 104ºF (40ºC). 7.
PAGE 6
Installation I (joist mounting) 1. For ideal ventilation use, hold the body of the fan with the exhaust side facing the desired duct direction. 5. If the brackets are too short to reach the joist, use the extensions provided (Fig. E). Fig. A Fig. E 2. Place the body of the fan in between joists in designated area. Fig. B 3. If convenient to secure unit to the joist (otherwise go to step 4), place the unit against joist and push the fan to the proper depth and use long screws (Fig. C). Fig. C 4.
PAGE 7
. Electrical installation: Wires from the power supply to the unit should not be smaller than size 14 AWG. The ground wire must be connected to the green wire in junction box, the neutral wire to the white wire and the hot wire to the black wire. Installation II (in existing ceiling) 1.
PAGE 8
Maintenance Cleaning the fan Routine maintenance should be done at least once a year and should be as follows: 1. Remove cover grille; 2. Wash with lukewarm water and a mild detergent and clean the grille in a sink and dry with a cloth; 3. Remove dust and dirt from the fan housing with a vacuum cleaner; 4. Dry the body with a cloth or paper towel; 5. Replace the grille. CAUTION Never use solvents, thinner or harsh chemical for cleaning the fan. Do not allow water to enter the motor.