Operating instructions

3
design and construction for the intended use and
provides adequate protection from electrical shock and
harmful physical contact to personnel.
5. A leak-tight fuel delivery conduit and control system
must be maintained at all times.
6. Products of combustion must be transported from the
boiler/burner system to the outdoors in an approved,
leak tight, insulated venting system. The boiler room
must be positively ventilated to prevent a concentration
of products of combustion and a reduction in the
amount of oxygen in the air.
7. Burner/boiler materials of construction, products of
combustion and fuels contain alumina, silica, heavy
metals, carbon monoxide, nitrogen oxides, aldehydes,
carbon dioxide, particulates and/or other toxic or
harmful substances which can cause death or serious
illness and which are known to the state of California to
cause cancer, birth defects and other reproductive
harm. Always use proper safety clothing, respirators
and equipment when servicing or working near the
equipment.
1. The equipment shall be installed in accordance with
regulations in force in the area where the installation is
to be made. These regulations shall be carefully followed
in all cases. Authorities having jurisdiction shall be
consulted before installations are made. All
boiler installations in the USA should comply with
the current edition of the following standards:
A. American national standard NFPA 31, "Installation
of Oil Burning Equipment”.
B. American national standard NFPA211, “Chimneys,
Fireplaces, Vents, and Solid Fuel Burning
Appliances”.
C. American Society of Mechanical Engineers ASME
CSD-1, “Controls and Safety Devices for
Automatically Fired Boilers”.
2. All wiring on boilers shall be made in accordance
with the National Electrical Code and/or local regulations.
3. Installation, start-up, operation and/or maintenance
(service) of this burner/boiler system must be
undertaken only by trained and skilled personnel.
4. Failure to follow all instructions in the proper
order can cause personal injury or death. Read all
instructions, including all those in other boiler/burner
system manuals, which were provided with the equipment
before installing, operating or servicing.
Burner/boiler system, as used throughout this manual,
shall mean all mechanical and/or electrical equipment
including the boiler, burner, pumps, compressors, feed
water systems and all associated piping, electrical and
control systems used and maintained in the boiler room.
The following dened terms are used throughout this
manual to bring attention to the presence of hazards
or various risk levels or to note important information
concerning the operating life of the product.
Indicates presence of a hazard which will cause severe
personal injury, death or substantial property damage if
ignored.
Indicates presence of a hazard which can cause severe
personal injury, death or substantial property damage if
ignored.
Indicates presence of a hazard which will or can cause
minor personal injury or property damage if ignored.
Indicates special instructions on installation, operation or
maintenance which are important but not necessarily related to
personal injury hazards.
1. If you smell gas or fuel oil vapors, do not try to operate
the burner/boiler system. Do not touch any electrical
switch or use any phone in the building. Immediately call
the gas or oil supplier from a remotely located phone.
2. Burner/boiler systems produce steam or hot water in a
 pressurizedvesselbymixingextremelyammable 
gaseous, liquid or solid fuels with air to produce
combustion and very hot products of combustion.
 Explosions,res,severepersonalinjury,deathand/or 
property damage will result from improper, careless or
inadequate installation, operation or maintenance of
fuel-burning and boiler equipment.
3. Insulateallsteamandhotwaterpiping,ttingsand 
connections and all other hot components and
equipment from personnel contact..
4. Assureallpipes,ttings,electricalcontrolsandall 
other associated burner/boiler equipment is of proper
IMPORTANT INFORMATION
WARNING
CAUTION
NOTICE
DANGER
WARNING