User Guide
Table Of Contents
- Product Data
- Features/Benefits
- Model Number Nomenclature
- AHRI Capacities
- Unit Dimensions
- Unit Dimensions
- 36-60
- Accessory Dimensions
- 1. Roof curb must be set up for unit being installed.
- 2. Seal strip must be applied, as required, to unit being installed.
- 3. Roof curb is made of 16-gauge steel.
- 4. Attach ductwork to curb (flanges of duct rest on curb).
- 5. Insulated panels: 1-in. (25.4 mm) thick fiberglass 1 lb. density.
- Performance Data
- Application Data
- Electrical Data
- Connection Wiring Schematic 208/230-1-60
- Controls
- Operating Sequence
- 2. The normally open contacts of energized contactor (C) close and complete the circuit through compressor motor (COMP) to condenser (outdoor) fan motor (OFM). Both motors start instantly.
- 3. The set of normally open contacts on the interface fan board (IFB) are closed which energizes a circuit to the indoor fan motor (IFM).
- Guide Specifications
- Packaged Gas Heating/Electric Cooling Units Constant Volume Application
- HVAC Guide Specifications
- General
- Products
- Guide Specifications (Continued)
- 2. Compressor Start Kit (single phase units only):
- 3. Thermostat:
- 4. Crankcase Heater:
- 5. Economizer:
- 6. Filter Rack Kit:
- 7. Flat Roof Curb:
- 8. Flue Discharge Deflector
- 9. Low Ambient Package:
- 10. Manual Outdoor Air Damper:
- 11. Square-To-Round Duct Transitions (24-48 models):
- 12. Time Guard II
- 13. Low Pressure Switch Kit
577C--K Ultra Low NOx: Product Data
Manufacturer reserves the right to change, at any time, specifications and designs without notice and without obligations.
18
Gas Adjustment
Natural Gas Orifice Sizes and Manifold Pressure - Single and Three Phase Models
Nameplate Input (Btu/hr)
Altitude of Installation (FT. Above Sea Level)
U.S.A.
*
*. Altitude of 2001ft and above is not allowed.
0 to 2000
(0-610 m)
45,000
Orifice No. (Qty) 0.125-in.
Manifold Press. (in. W.C.) 3.2~3.8
60,000
Orifice No. (Qty) 28 (1)
Manifold Press. (in. W.C.) 3.2~3.8
89,000
Orifice No. (Qty) 18 (1)
Manifold Press. (in. W.C.) 3.2~3.8