TRASH COMPACTOR SERVICE MANUAL MODELS MODELS 1050L-C & 1051L-C 1055-K & 1059-C Broan-NuTone LLC, 926 West State Street, Hartford, WI 53027 (1-800-637-1453) $5.
CONTENTS BAG INSTALLATION Safety Precautions ................................................................... 2 Model and Serial No. Identification ....................................... 2 Transporting Compactor ......................................................... 2 Manually Raising and Lowering Ram .................................... 2 Troubleshooting Guide .................................................... 3 & 4 Component Replacement .............................................
TROUBLESHOOTING GUIDE Condition I. Will not run. Dead no sound. (Turn key to start, if unit hums, go to section III. II. Runs continuously, will not shut off. III. Will not run - hums when key held in start position. Possible Cause Correction Not plugged in securely. Insert plug securely into outlet. Circuit breaker or fuse open. Check for condition causing circuit breaker or fuse to open. Correct condition, then reset circuit breaker or replace fuse. Drawer not closed. Push drawer to close.
TROUBLESHOOTING GUIDE Condition Possible Cause Correction IV. Starts and reverses immediately. Will not go down into drawer. Rhythmic buzzing. Defective upper limit switch. Didn’t hold key long enough. Replace. V. Thermal cutout on motor trips. (Compactor may appear to start by itself several minutes after last use.) Smells hot. Defective upper limit switch. Replace. Defective centrifugal switch on motor. Replace. VI. Drawer does not open smoothly after compactor is leveled. Worn rollers.
CABINET REPLACEMENT - POWER PACK REMOVAL DRAWER ASSEMBLY 1. Pull out drawer until it stops. 2. Lift drawer slightly, then pull out drawer to second stop. 3. Lift drawer up and out of compactor. A box or similar stand approximately 11” high x 15” long x 7” wide is recommended for power pack removal. The box must be able to support 60 lbs. or more since you will be placing the full weight of the power pack on it. 1. Unplug compactor from socket. 2. Remove drawer assembly from cabinet. 3.
SWITCH LOCATIONS the door. Another switch located against the interlock switch is to provide the “No-Jam” circuitry function. This switch is normally open and bypasses the interlock to provide “No-Jam” capability. It can be replaced in the same manner as the interlock switch. KEY SWITCH INTERLOCK SWITCH TO REPLACE INTERLOCK SWITCH 1. Remove air scentry panel assembly. 2. Disconnect leads one by one and attach to new switch. UPPER LIMIT SWITCH TRUNNION NUT 1.
TRUNNION BEARING GEARBOX 1. Remove sprocket and drive pin. 2. Pull out trunnion bearing. Grease trunnion bearing inside and out with wheel bearing grease prior to reinstalling. 1. Lower ram manually until there is approximately 11" to 12" between the ram and the bottom assembly. 2. Remove the four 3/8" nuts securing motor to gearbox, slide motor out and rest it on the front trunnion assembly. 3.
BLACK GRAY RED GREEN MOTOR Before motor is removed, it should be tested to be sure it is inoperative. Check the continuity of the motor. ORANGE CHECK CONTINUITY Black to Orange Red to Orange Gray to Orange Green to Motor Frame 1. 2. 3. 4. If open, replace motor If open, replace motor If open, replace motor If open, inspect wire to be sure it is properly attached to motor frame Lower ram manually until there is approximately 7" between the bottom assembly and the ram.
MODELS 1050L-C, 1051L-C, 1055-K, 1059-C Service Parts Page 1 of 4 45 45 ITEM NO. 1 2 4 5 6 7 9 10 12 13 14 15 17 18 19 21 22 23 24 25 26 27 28 30 38 40 41 42 43 45 PART NO.
70 MODELS 1050L-C, 1051L-C, 1055-K, 1059-C Service Parts Page 2 of 4 FRONT 66 65 87 68 89 69 87 ITEM NO. PART NO.
126 125 MODELS 1050L-C, 1051L-C, 1055-K, 1059-C Service Parts Page 3 of 4 ITEM NO. 66 67 82 83 99 100 102 105 106 107 108 109 113 114 115 116 119 120 121 122 123 124 125 126 127 128 129 156 157 ----- PART NO.
MODELS 1050L-C, 1051L-C, 1055-K, 1059-C Service Parts Page 4 of 4 144 146 154 153 158 ITEM NO. 2 19 24 130 143 144 145 146 151 OPTIONAL 152 153 154 PART NO. 93150459 93470012 93260447 93042445 93042448 91016538 93420449 91016539 93260454 99140102 93480003 93420447 93360100 93360141 93370334 92007833 93110514 92008715 93650007 99230342 93650008 93100511 93650057 91009957 93620008 99230340 99111098 158 99260502 131 132 133 134 135 136 137 138 139 140 142 DESCRIPTION Screw, 8-18 x 1/2 PH. TR. HD.
