Installation / Operation Instruction Manual
Table Of Contents
- TABLE OF CONTENTS
- INSTALLATION
- Figure 1
- Probable Cause
- Control Status
- LED Status
- Millivolt power is not present. Light pilot.
- None (LED not on or flashing)
- Gas valve is powered and waiting for the set point knob to be turned to a water temperature setting. If the set point knob is at desired setting the thermostat is satisfied.
- If set point knob is in “PILOT” position, then pilot flame is detected. (no faults).
- One flash and three second pause.
- LED strobe (two quick flashes) and three second pause.
- Thermostat calling for heat (no faults).
- Water heater operating normally
- Set point know was recently turn to “OFF” position. Wait until LED goes out before attempting to relight.
- Set point knob has been recently turned to the “OFF” position.
- LED on continuously.
- Weak pilot flame detected. System will reset when pilot flame is sufficient.
- Two flashes and three second pause.
- Insufficient water heating. System will reset.
- Three flashes and three second pause
- Excessive tank temperature. System must be reset.
- Four flashes and three second pause
- Probable Cause
- Control Status
- LED Status
- Five flashes and three second pause.
- Temperature sensor fault.
- Water leak detected by accessory module (some models).
- Six flashes and three second pause.
- Gas valve electronic fault detected.
- Seven flashes and three second pause.
- Eight flashes and three second pause.
- False pilot flame present.
2
CONGRATULATIONS!
You have just purchased one of the finest water heaters on
the market today!
This installation, operation and instruction manual will
explain in detail the installation and maintenance of your
new Gas Water Heater. We strongly recommend that you
contact a plumbing professional for the installation of this
water heater.
We require that you carefully read this manual, as well as
the enclosed warranty, and refer to it when questions arise.
If you have any specific questions concerning your
warranty, please consult the plumbing professional from
whom your water heater was purchased. For your records,
we recommend that you write the model, serial number and
installation date of your water heater in the maintenance
section in the back of this manual.
This manual should be kept with the water heater.
TABLE OF CONTENTS
page
GENERAL INFORMATION ............................................................................ 3
INSTALLATION .............................................................................................. 4
Locating the Water Heater ..................................................................... 4
Minimum Clearances ............................................................................. 7
Venting .................................................................................................... 8
Combustion Air Supply ......................................................................... 9
Water Connections ................................................................................. 11
Gas Connections .................................................................................... 14
GENERAL OPERATION ................................................................................ 15
Lighting and Shutdown Instructions .................................................... 16
Thermostat Adjustment ......................................................................... 19
Burner Flame Check .............................................................................. 21
MAINTENANCE .............................................................................................. 22
TROUBLESHOOTING CHART ...................................................................... 24
PARTS LIST AND DRAWING ........................................................................ 29
INSTALLATION INSTRUCTIONS FOR POTABLE WATER AND SPACE
HEATING ........................................................................................................ 30
NOTES ............................................................................................................ 31