Submittal
DRAFT
Date:
Project #:
Engineer:
Prepared By:
Bid Date:
Project Name:
Location:
Contractor:
Standard
Features
Hydronic Boiler
CFH Firetube Boiler
Indoor / Outdoor, Sizes 1000 - 3000
Submittal Data
Boiler Data
Factory
Mounted
Options
H
MagnaTherm FT Submittal Data
Standard • ASME "H" stamp • Electronic PID modulating • Sensor for indirect DHW tank
Features • 160 psi maximum working pressure control with large touchscreen • Outdoor reset with air sensor
• Certified for Category II and and color display • Horizontal or vertical direct vent
Category IV vent systems
• Multiple independent heat demands • Vent and air pipe lengths of up to
• Indoor/outdoor • VARI-PRIME boiler pump control 100 equivalent feet (each)
• Low NOx system exceeds the via user-selectable fixed boiler • High & low gas pressure switches
most stringent regulations for air temperature rise
• Vent temperature cutoff
quality
• Wired and programmed to control • Normally open alarm contact
• High condensing efficiency boiler isolation valves • Air filter
• Up to 20:1 turndown modulation • Controller cascades with up to • Built-in condensate trap
• Sophisticated gas/air valve eight MagnaTherm FT boilers • Temperature & pressure gauge
allows for constant control
• Accepts 4-20ma or 0-10VDC • Low water cutoff
of modulation external modulation or external
• Water flow switch
• Tru Trac
TM
real-time O
2
sensing set point control • 75 psi (517kPa) ASME rated
maintains efficiency throughout
• Modbus RTU & BACnet MSTP pressure relief valve
the modulation range on board
• Flange water fittings
• Stainless steel vertical firetube heat • Multiple pump control for boiler • Burner site glass
exchanger with welded construction pump, system pump, & indirect DHW
• Heat exchanger warranty:
• Sealed combustion chamber water pump, each with delay 10-Year limited non-prorated
• Pre-mix stainless steel burner • Indirect water heater priority 25-year limited thermal shock
• 1-Year limited parts warranty
Boiler Number of Units Voltage
Data 120V, single ph (1000-2000) 208V, three ph (2000-3000)
208V, single ph (1000-2000) 480V, three ph (2000-3000)
Fuel 220/240V, single ph (1000-2000) 600V, three ph (2000-3000)
Natural
Factory
ASME CSD-1 Additional auto & manual 75 psi pressure relief valve (std)
Mounted
BACnet IP gateway reset high limit switches 30 psi pressure relief valve
Options
LonWorks gateway Alarm bell with silence switch 50 psi pressure relief valve
60 psi pressure relief valve
125 psi pressure relief valve
150 psi pressure relief valve
Accessories Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting Motorized isolation valve(s) Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer Screen for vertical CPVC vent or vertical ducted air
Condensate neutralizer with pump Screen for horizontal Screen for horizontal
Vent terminal for outdoor unit polypropylene vent polypropylene ducted air
Screen for outdoor unit air Screen for vertical Screen for vertical
Vent terminal for horizontal polypropylene vent polypropylene ducted air
stainless steel vent
MagnaTherm FT Submittal Data
Standard • ASME "H" stamp • Electronic PID modulating • Sensor for indirect DHW tank
Features • 160 psi maximum working pressure control with large touchscreen • Outdoor reset with air sensor
• Certified for Category II and and color display • Horizontal or vertical direct vent
Category IV vent systems
• Multiple independent heat demands • Vent and air pipe lengths of up to
• Indoor/outdoor • VARI-PRIME boiler pump control 100 equivalent feet (each)
• Low NOx system exceeds the via user-selectable fixed boiler • High & low gas pressure switches
most stringent regulations for air temperature rise
• Vent temperature cutoff
quality
• Wired and programmed to control • Normally open alarm contact
• High condensing efficiency boiler isolation valves • Air filter
• Up to 20:1 turndown modulation • Controller cascades with up to • Built-in condensate trap
• Sophisticated gas/air valve eight MagnaTherm FT boilers • Temperature & pressure gauge
allows for constant control
• Accepts 4-20ma or 0-10VDC • Low water cutoff
of modulation external modulation or external
• Water flow switch
• Tru Trac
TM
real-time O
2
sensing set point control • 75 psi (517kPa) ASME rated
maintains efficiency throughout
• Modbus RTU & BACnet MSTP pressure relief valve
the modulation range on board
• Flange water fittings
• Stainless steel vertical firetube heat • Multiple pump control for boiler • Burner site glass
exchanger with welded construction pump, system pump, & indirect DHW
• Heat exchanger warranty:
• Sealed combustion chamber water pump, each with delay 10-Year limited non-prorated
• Pre-mix stainless steel burner • Indirect water heater priority 25-year limited thermal shock
• 1-Year limited parts warranty
Boiler Number of Units Voltage
Data
120V, single ph (1000-2000) 208V, three ph (2000-3000)
208V, single ph (1000-2000) 480V, three ph (2000-3000)
Fuel 220/240V, single ph (1000-2000) 600V, three ph (2000-3000)
Natural
Factory ASME CSD-1 Additional auto & manual 75 psi pressure relief valve (std)
Mounted BACnet IP gateway reset high limit switches 30 psi pressure relief valve
Options LonWorks gateway Alarm bell with silence switch 50 psi pressure relief valve
60 psi pressure relief valve
125 psi pressure relief valve
150 psi pressure relief valve
Accessories Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting Motorized isolation valve(s) Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer Screen for vertical CPVC vent or vertical ducted air
Condensate neutralizer with pump Screen for horizontal Screen for horizontal
Vent terminal for outdoor unit polypropylene vent polypropylene ducted air
Screen for outdoor unit air Screen for vertical Screen for vertical
Vent terminal for horizontal polypropylene vent polypropylene ducted air
stainless steel vent
MagnaTherm FT Submittal Data
Standard
•
ASME "H" stamp
•
Electronic PID modulating
•
Sensor for indirect DHW tank
Features
•
160 psi maximum working pressure control with large touchscreen
•
Outdoor reset with air sensor
•
Certified for Category II and and color display
•
Horizontal or vertical direct vent
Category IV vent systems
•
Multiple independent heat demands
•
Vent and air pipe lengths of up to
•
Indoor/outdoor
•
VARI-PRIME boiler pump control 100 equivalent feet (each)
•
via user-selectable fixed boiler
•
High & low gas pressure switches
most stringent regulations for air temperature rise
•
Vent temperature cutoff
quality
•
Wired and programmed to control
•
Normally open alarm contact
•
High condensing efficiency boiler isolation valves
•
Air filter
•
Up to 20:1 turndown modulation
•
Controller cascades with up to
•
Built-in condensate trap
•
Sophisticated gas/air valve eight MagnaTherm FT boilers
•
Temperature & pressure gauge
allows for constant control
•
Accepts 4-20ma or 0-10VDC
•
Low water cutoff
of modulation external modulation or external
•
Water flow switch
•
Tru Trac
TM
real-time O
2
sensing set point control
•
75 psi (517kPa) ASME rated
maintains efficiency throughout
•
Modbus RTU & BACnet MSTP pressure relief valve
the modulation range on board
•
Flange water fittings
•
Stainless steel vertical firetube heat
•
Multiple pump control for boiler
•
Burner site glass
exchanger with welded construction pump, system pump, & indirect DHW
•
Heat exchanger warranty:
•
Sealed combustion chamber water pump, each with delay 10-Year limited non-prorated
•
Pre-mix stainless steel burner
•
Indirect water heater priority 25-year limited thermal shock
•
1-Year limited parts warranty
Boiler
Number of Units Voltage
Data
120V, single ph (1000-2000) 208V, three ph (2000-3000)
208V, single ph (1000-2000) 480V, three ph (2000-3000)
Fuel 220/240V, single ph (1000-2000) 600V, three ph (2000-3000)
Natural
Factory
ASME CSD-1 Additional auto & manual 75 psi pressure relief valve (std)
Mounted
BACnet IP gateway reset high limit switches 30 psi pressure relief valve
Options
LonWorks gateway Alarm bell with silence switch 50 psi pressure relief valve
60 psi pressure relief valve
125 psi pressure relief valve
150 psi pressure relief valve
Accessories
Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field
Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting
Motorized isolation valve(s) Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer Screen for vertical CPVC vent or vertical ducted air
Condensate neutralizer with pump Screen for horizontal Screen for horizontal
Vent terminal for outdoor unit polypropylene vent polypropylene ducted air
Screen for outdoor unit air Screen for vertical Screen for vertical
Vent terminal for horizontal polypropylene vent polypropylene ducted air
stainless steel vent
Brute Magnatech
®
FT
• Controller cascades with up to eight
MagnaTech FT units.
• Real-Time O
2
sensing maintains
eciency throughout the
modulation range
• Variable speed boiler pump
control with xed Delta T control
for variable ow through boiler
Submittal Data
BCFH