Submittal

DRAFT
Accessories
for Field
Mounting
Clearances
Sizing Data
Electrical
Data
Full Load Amperage
Minimum Circuit Ampacity
Max Over-current Protection
Sizing Data
MBH kw MBH kw MBH kw MBH kw %%
1000 67 19.6 999.9 293 63 18.5 950 278 95.8 96.1 15:1
1500 75 22.0 1500 440 71 20.8 1425 418 95.9 96.3 20:1
2000 100 29.3 1999.9 586 95 27.8 1900 557 95.4 95.5 20:1
3000 150 44.0 3000 879 143 41.9 2850 835 95.9 95.9 20:1
lbs kg lbs kg lbs kg gal l
1000 1300 590 1934 878 1450 658 76 288
1500 1450 658 2292 1041 1600 726 101 382
2000 1750 795 2717 1234 1950 885 116 439
3000 2050 931 3292 1495 2250 1022 149 564
Water Content
Shipping
Weight
Operating
Weight
Product
Weight
Model
Model
Thermal
Efficiency
Maximum
Output Rate
Minimum
Output Rate
Maximum
Input Rate
Minimum
Input Rate
Modulation
Turndown
Ratio
Combustion
Efficiency
Clearances
inches cm inches cm
Front 18 46 24 61
Back 18 46 24 61
Left 3 8 12 30
Right 3 8 12 30
Top 3* 8 24* 61
Note: A 4" high equipment pad is required.
This pad must NOT extend more than 3" beyond the boiler base structure at the rear of the boiler.
*24" top clearance is suggested to service the unit.
Clearance to
Combustibles
Suggested
Service
Clearance
MagnaTherm FT Submittal Data
Standard • ASME "H" stamp • Electronic PID modulating • Sensor for indirect DHW tank
Features • 160 psi maximum working pressure control with large touchscreen • Outdoor reset with air sensor
• Certified for Category II and and color display • Horizontal or vertical direct vent
Category IV vent systems
• Multiple independent heat demands • Vent and air pipe lengths of up to
• Indoor/outdoor • VARI-PRIME boiler pump control 100 equivalent feet (each)
• Low NOx system exceeds the via user-selectable fixed boiler • High & low gas pressure switches
most stringent regulations for air temperature rise
• Vent temperature cutoff
quality
• Wired and programmed to control • Normally open alarm contact
• High condensing efficiency boiler isolation valves • Air filter
• Up to 20:1 turndown modulation • Controller cascades with up to • Built-in condensate trap
• Sophisticated gas/air valve eight MagnaTherm FT boilers • Temperature & pressure gauge
allows for constant control
• Accepts 4-20ma or 0-10VDC • Low water cutoff
of modulation external modulation or external
• Water flow switch
• Tru Trac
TM
real-time O
2
sensing set point control • 75 psi (517kPa) ASME rated
maintains efficiency throughout
• Modbus RTU & BACnet MSTP pressure relief valve
the modulation range on board
• Flange water fittings
• Stainless steel vertical firetube heat • Multiple pump control for boiler • Burner site glass
exchanger with welded construction pump, system pump, & indirect DHW
• Heat exchanger warranty:
• Sealed combustion chamber water pump, each with delay 10-Year limited non-prorated
• Pre-mix stainless steel burner • Indirect water heater priority 25-year limited thermal shock
• 1-Year limited parts warranty
Boiler Number of Units Voltage
Data 120V, single ph (1000-2000) 208V, three ph (2000-3000)
208V, single ph (1000-2000) 480V, three ph (2000-3000)
Fuel 220/240V, single ph (1000-2000) 600V, three ph (2000-3000)
Natural
Factory ASME CSD-1 Additional auto & manual 75 psi pressure relief valve (std)
Mounted BACnet IP gateway reset high limit switches 30 psi pressure relief valve
Options LonWorks gateway Alarm bell with silence switch 50 psi pressure relief valve
60 psi pressure relief valve
125 psi pressure relief valve
150 psi pressure relief valve
Accessories
Gateway for BACnet IP Screen for vertical stainless Screen/adapter for vertical or
for Field
Gateway for LonWorks steel vent horizontal PCV ducted air
Mounting
Motorized isolation valve(s) Screen for horizontal CPVC vent Screen for horizontal galvanized
Condensate neutralizer Screen for vertical CPVC vent or vertical ducted air
Condensate neutralizer with pump Screen for horizontal Screen for horizontal
Vent terminal for outdoor unit polypropylene vent polypropylene ducted air
Screen for outdoor unit air Screen for vertical Screen for vertical
Vent terminal for horizontal polypropylene vent polypropylene ducted air
stainless steel vent
Electrical
Data
Voltage FLA MCA MOP FLA MCA MOP FLA MCA MOP FLA MCA MOP
120V, 1 phase 5.0 6.2 15.0 6.2 7.8 15.0 7.8 9.7 20.0
N/A N/A N/A
208V, 1 phase
2.9 3.6 15.0 3.6 4.5 15.0 4.5 5.6 15.0 N/A N/A N/A
220/240V, 1 phase
2.7 3.4 15.0 3.4 4.2 15.0 4.3 5.3 15.0 N/A N/A N/A
208V, 3 phase
N/A N/A N/A N/A N/A N/A 3.3 4.1 15.0 4.5 5.6 15.0
480V, 3 phase
N/A N/A N/A N/A N/A N/A 1.5 1.9 15.0 2.1 2.6 15.0
600V, 3 phase
N/A N/A N/A N/A N/A N/A 1.1 1.4 15.0 1.4 1.8 15.0
FLA - Full Load Amperage
MCA - Minimum Circuit Ampacity
MOP - Maximum Over-current Protection
1000 1500 2000 3000
Current Current Current Current