Owner`s manual

29843-5-1012 Page 39
Please Note
It is normal for appliances fabricated of steel to give off
some expansion and/or contraction noise during the start
up or cool down cycle. Similar noises are found with your
furnace heat exchanger or car engine.
Itisnotunusualforyourgasreplacetogiveoffsomeodorthe
rsttimeitisburned.Thisisduetothecuringofthepaintandany
undetectedoilfromthemanufacturingprocess.
Please ensure that your room is well ventilated - open all
windows.
It is recommended that you burn your replace for at least six
(6) hours the rst time you use it.
IMPORTANT: Turn off gas before servicing appliance. It is
recommendedthataqualiedservicepersonperformthesecheck-
upsatthebeginningofeachheatingseason.
• Clean Burner and Control Compartment
 Keepthecontrolcompartment,logs,andburnerareassurrounding
thelogscleanbyvacuumingorbrushingatleasttwiceayear.
Cleaning Procedure
1. Turnoffpilotlightatcontrolmodule.
2. Removeglassfront.(SeeGlassRemoval)
3. Vacuumburnercompartment.
4. Reinstallglassfront.
5. Ignitepilot.(SeeLightingInstructions)
6. Operatethepilotburner.Ifitappearsabnormalcallaservice
person.
• Check Vent System
 Theapplianceandventingsystemshouldbeinspectedbefore
initialuseandatleastannuallybyaqualiedserviceperson.
Inspecttheexternalventcaponaregularbasistomakesure
thatnodebrisisinterferingwiththeairow.
Glass Cleaning
Itwillbenecessarytocleantheglassperiodically.Duringstart-up
condensation,whichisnormal,formsontheinsideoftheglassand
causeslint,dustandotherairborneparticlestoclingtotheglass
surface.Alsoinitialpaintcuringmaydepositaslightlmontheglass.
Itisthereforerecommendedthattheglassbecleanedtwoorthree
timeswithanon-abrasiveammonia free household cleaner and
warmwater(werecommendgasreplaceglasscleaner,contacta
localdealerforthisproduct).Afterthattheglassshouldbecleaned
twoorthreetimesduringeachheatingseasondependingonthe
circumstancespresent.
General Glass Information
Warning: Do not operate appliance with the glass front
removed, cracked or broken. Replacement of the glass
should be done by a licensed or qualied service person.
Onlyglassapprovedforusebythemanufacturerinreplacemay
beusedforreplacement.Theglassreplacementshouldbedone
byalicensedorqualiedserviceperson.
WARNING:
1. Theuseofsubstituteglasswillvoidallproductwarranties.
2. Caremustbetakentoavoidbreakageoftheglass.
3. Undernocircumstancesshouldthisappliancebeoperatedwithout
theglassfrontorwithabrokenglassfront.Replacementofthe
glass(withgasket)assuppliedbythemanufacturershouldbe
donebyaqualiedserviceperson.
4. Donotabusetheglassbystrikingorhittingtheglass.
WARNING: Do not use abrasive cleaners on glass. Do not
attempt to clean glass when glass is hot.
Glass Removal and Replacement
1.Removethefront.
2. Unlatchthe4springclipsgoingaroundtheglassframeassembly.
Usetheincludedtooltomakeiteasier.
 3. Grasptheglassframeonthetopandthebottom.Pulltheglass
straightouttodisengagetheglassfromthereplace.
 4. Toreplace,reversetheabovesteps.SeeFigure 59.
GLASS
CLIPS
►
►
►
►
GLASS
CLIPS
Figure 59
MAINTENANCE AND SERVICE
Reassembly and Resealing Gas Accumulation Relief System
Glass Frame Assembly and Combustion Chamber
Whenevertheglassframeassemblyispivotedopenbyadelayed
ignitioninthemainburner,theglassframeassemblygasketsand
combustionchambermustbeexaminedbyaqualiedserviceperson
fordamage.Alldamagedgasketsontheglassframeassemblyand
combustionchambermustbereplacedbyaqualiedserviceperson.
Ifdamageoccurstothecombustionchamber,itmustbereplaced
byaqualiedserviceperson.ContactEmpireComfortSystems,
Inc.forreplacementparts.