Owner`s manual

29843-5-1012Page 34
DVLL GLASS MEDIA INSTALLATION
Installation of the glass media is critical to safe and clean op-
eration of the replace.
WARNING
Failure to position the parts in accordance with the dia-
grams and instructions below or failure to use only parts
specically approved for use with this heater may result in
property damage or personal injury.
DECORATIVE GLASS ACCESSORY PLACEMENT
This Linear Contemporary replace is approved for use with
smoothglassmediameasuringassmallas1/4inchandupto1/2
inch in diameter. Empire Comfort Systems offers a selection of
glassmediaforthisreplace.Additionalcolorsmaybeavailable
fromyourEmpiredealer.Useproperlysizedsmoothglassmedia
approvedforgasreplaces.Followthediagramsinthismanualfor
placementofmediaandclearancetoburnerports.
CAUTION
Use of gloves and eye protection is required while applying
the decorative glass.
▲
▼
▲
BURNER
GLASS MEDIA RETAINER
MEDIA TRAY
▲
GLASS MUST NOT BE PLACED ON TOP OF OR
NEXT TO BURNER. GLASS TO BE PLACED ONLY
TO THE OUTSIDE OF THE FLANGED OPENING.
Figure 56
1. Removethefrontandtheglassframeassembly.
2. Placethelongthinglasspiece(glassmediaretainer)intothe
grooveinfrontofthemediatrayinthefireboxopening.This
willkeeptheglassbeadsfromfallingout.
3. Placedime-sizedpiecesofemberacrosstheburnersurface.
Asinglelayer,issufficient;donotover-apply.
4. Carefullyopenthe7.5lbs.bagofglassbeads.Distributethe
glassbeadsevenlyacrossthemediatray,takingcarenotto
lettheglassbeadsfalldownbytheburnerorthepilot.Ifthey
do,makesuretheydon'tblocktheburnerorpilot.Thereare
1/2"wallsaroundtheburner,pilotandbackairslotstokeep
thebeadsout.
5. Replacetheglassframeassemblyanddecorativefront.