Operating instructions

PRE-SEASON
PREPARATION _
To simplify the pre-season preparation
we have drawn up a small chart. The
chart indicates servicing points to be
performed by you and your servicing
dealer. If these services are performed
as suggested, your vehicle will give you
many hours of fun and low cost use.
IMPORTANT: Observe all Warnings
and Cautions mentioned
throughout
this manual which are pertinent to the
item being checked. When component
conditions seem less than satisfactory,
replace
with genuine Bombardier parts
or suitable equivalents.
PRE-SEASON
TO BE PERFORMED BY DEALER
•
PREPARATION CHART
TO BE PERFORMED BY OWNER
0
Change spark plugs*
0
Check chaincase oil level
0
Check rotary valve oil level
0
Replace fuel filter (located inside fuel tank)
0
Check track tension and alignment
0
Lubricate suspension
0
Inspect drive belt and install
0
Check steering alignment and ski runner condition
0
Inspect condition of starting rope
0
Check tightness of all bolts, nuts and linkage
0
Refill gas tank
0
Check throttle cable for damage and free operation
•
Check electrical wiring (broken wire, damaged insulation)
0
Inspect seals for possible cuts or leaks
•
Check coolant condition and level
0
Replace injection oil filter
•
Refill injection oil tank
•
Inspect brake condition and operation
•
Set engine timing
•
Check pulleys, verify components and clean. Lubricate.
•
Adjust carburetor
•
Adjust oil injection pump
•
O
*NOTE: Before installing new spark plugs, it is suggested to burn the excess
storage oil by starting the engine, using the old spark plugs.
~ CAUTION: Only perform this procedure in a well ventilated area.
36 _