Operating instructions

O
NOTE: To prevent battery from
discharging, store it on a wooden
shelf away from moisture. A stored bat-
tery must be recharged at least every 40
days.
Chassis
Clean the vehicle thoroughly, removing
all dirt and grease accumulation.
~ CAUTION: Plastic alloy cornpo-
.. nents such as fuel tank, wind-
shield, controls, etc., can be cleaned
using mild detergents or isopropyl al-
cohol. Do not use strong soaps, de-
greasing solvents, abrasive cleaners,
paint thinners, etc.
Inspect the hood and repair any dam-
age. Clean the frame. For the unpainted
aluminum portion use only
"Aluminum
cleaner" and follow instructions on the
container.
Touch up all metal spots where paint
has been scratched off. Spray all bare
metal parts
with metal protector. Wax
the hood and the painted portion of the
frame for better protection.
O
NOTE: Apply wax on glossy fin-
ish only. Protect the vehicle with a
cover to prevent dust accumulation dur-
ing storage.
~ CAUTION: If for some reason the
.. snowmobile has to be stored out-
side it is necessary
to cover it with an
opaque
tarpaulin. This caution will
prevent the sun rays and the grime
from affecting the plastic components
and
the vehicle finish.
General Inspection
Check the electrical wiring and compo-
nents, retighten loose connections.
Check for stripped wires or damaged
insulation.
Thoroughly inspect the vehicle and
tighten loose bolts, nuts and linkage.
O
NOTE: Leave the drive belt off the
pulleys for the entire storage
period.
Suspension Stopper Strap
Replace annually and/or as condition
dictates. Torque
nut to 10 N-m (7 Ibf-
ftl.
____________ 35