Technical data

ManualsBrandsBMW ManualsAutomobileM5

111

112

113

114

115

116

117

118

119

120

Table Of Contents

E60 M5
System overview
Foreword
- The most important features in brief
- Technical data and competitors
- Objectives
Purpose of this Participant's Manual
- Introduction
Introduction
- Technical data
- System overview
S85B50
- Engine block with bedplate
- Crankshaft drive
- Cylinder head
- Timing gear
- VANOS
- Belt drive
- Cooling circuit
- Oil circuit lubrication
- Intake air manifold
- Idle control system
- Secondary air system
- System components
Basic engine and add-on parts
- Upper section of crankcase
- Bedplate
- Crankcase
- Cylinder head
- Crankshaft/main bearings
- Connecting rods
- Pistons
- Camshaft
- Valve springs
- Valve cotters
- Box-type tappets
- Valves
- VANOS High pressure pump
- VANOS Actuators
- VANOS gear mechanism
- VANOS Pressure accumulator
- Oil pumps
- Electric oil pumps
- Oil spray nozzles
- Oil filter housing
- Exhaust manifold
- Intake air manifold
- Intake silencers
- Radiator
- Thermostat
- Objectives
Purpose of this Participant's Manual
- Introduction
Introduction
- System overview
- Functions
Functional Principle of the Digital Motor Electronics
- Engine torque control
- Requirement-oriented fuel delivery with variable pressure
- Activation of the fuel pumps
- Ionic current measurement
- Selectivity of maximum engine power output
- System components
Digital Motor Electronics (DME)
- DME control unit Siemens MS_S65
- Hot-film air mass meter (HFM)
- Fuel pressure sensor
- Electric fuel pump (EKP)
- EKP module
- Ionic current control unit
- Crankshaft sensor
- Camshaft sensor
- Oil condition sensor (QLT)
- Oil pressure switch
- Oil extraction pump
- Idle speed actuator (LLS)
- Throttle valve actuator motor
- Throttle valve sensor (DKG)
- Secondary air pump
- Mini HFM for secondary air system
- Primary oxygen sensor (control sensor)
- Secondary oxygen sensor (monitor sensor)
- Exhaust gas temperature sensor
- Pressure accumulator shut-off valve (VANOS)
- Service information
  - Electric throttle valve actuators (EDR)
  - Individual throttle valve
  - DME programming
  - VANOS Pressure accumulator
  - Ionic current technology
- Objectives
Purpose of this Participant's Manual
- Introduction
New 7-speed SMG
- System overview
The new SMG3
- Functions
Special functions
- Tow-start
- Hill ascent assistant
- Launch control
- Teaching in the axle difference
- Clutch overload protection (KÜS)
- System components
Transmission ratio of the SMG3
Gearshift pattern
Signals and parameters
- Gear recognition
- Reversing light
- Gearbox oil temperature
- Input speed
- Clutch slave cylinder
- Selector lever
- Gearshift paddles
- Drivelogic
- Brake light switch
- Steering angle
- Longitudinal acceleration/gradient
- Wake-up
- Bonnet contact switch
- Door contact
- Trailer operation
- Engine speed
Hydraulic system
- Service information
Initialization
- Clutch teach-in function
- Adaptations
- Pressure accumulator preload
- Objectives
Purpose of this Participant's Manual
- Introduction
MK60E5 from Continental Teves
- Features of the MK60E5
- System overview
Further development of the MK60psi
- Functions
DSC Additional Functions
- Operating modes of the MK60E5
- M Dynamic Mode (MDM)
- Brake readiness
- Dry braking
- Hill ascent assistant
- Condition Based Service (CBS)
- System components
Differences compared to the MK60psi
- Sensors
- Control unit
- Hydraulic unit
- Pressure generation
- Engine intervention
- Interfaces
- Objectives
Purpose of this Participant's Manual
- Introduction
Additional Functions
- System overview
Differences compared to the E60
- System components
Displays and indicators in the E60 M5
- Instrument cluster
- Head-up display (HUD)
- Oil level indicator

Abbreviations

ACC Active cruise control

BC On-board computer

BSD Bit-serial data interface

CAS Car access system

DME Digital motor electronics

DSC Dynamic stability control

DTC Dynamic traction control

EKP Electric fuel pump

FBS Fading brake support

FLR Driving performance control

HDP High pressure pump

HFM Hot-film air mass sensor

HVA Hydraulic valve lash adjustment

IBS Intelligent battery sensor

KÜS Clutch overload protection

KW Crankshaft

Short wave

LLS Idle actuator

LWS Steering angle sensor

MDM M Dynamic mode

MFL Multifunction steering wheel

PLCD Permanent magnetic linear contactless displacement

PT-CAN Power Train Controller Area Network

RLS Rain/driving light sensor

RPA Tyre puncture warning

SZL Steering column switch cluster

THZ Tandem-brake master cylinder

ZMS Dual-mass flywheel