User Guide

BMW Motorrad
Service data
F 650 CS
Item Desired value Units / Specifications
Oil capacities
Engine (incl. filter) 0.5 (0.88/0.53)
Litres (Imp. pints/US quarts)
Specification: see latest
Service Information
Engine (incl. filter) and oil tank 2.5 (4.4/2.64)
Litres (Imp. pints/US quarts)
Specification: see latest
Service Information
Coolant
50%
50%
Water
Anti-freeze
protection to –25 °C
Cooling system 1.3 (2.29/1.37) Litres (Imp. pints/US quarts)
Reservoir 0.1 (0.18/0.11) Litres (Imp. pints/US quarts)
Brake Fluid DOT 4
Valve clearance
measured cold (max. 35 °C/95 °F)
Inlet 0.03-0.11 (0.0012-0.004) mm (in)
Exhaust 0.25-0.33 (0.010-0.013) mm (in)
Spark plugs NGK DR8 EB
Electrode gap 0.6...0.7 (0.02...0.03) mm (in)
Engine idle speed 1,400 rpm
Clutch cable play
Cable at grip 1.0 - 2.0 (0.004 - 0.008) mm (in)
Tyre pressure
tyres cold
Solo front/rear 2.2/2.5 (31.91/36.26) bar (psi)
fully loaded front/rear 2.2/2.5 (31.91/36.26) bar (psi)
Tightening torques
Engine oil drain plug 40 Nm
Oil filter cover 10 Nm
Drain plug, on-frame oil tank 21 Nm
Oil lines to frame 42 Nm
Oil strainer to frame 80 Nm
Water pump drain screw 10 Nm
Vent screw 12 Nm
Expansion tank to radiator 9 Nm
Cylinder head cover 10 Nm
Spark plugs 20 Nm
Camshaft bearing cap 10 Nm
Chain guide 10 Nm (Loctite 243)
Fuel filter to stowage-compartment frame 9 Nm
Intake air pipe to intake air silencer 9 Nm
Suspension strut to angled lever 41 Nm
Eccentric clamp Initial tightening 10
21
Nm
Nm
Brake caliper to swinging arm 21 Nm
Struts to swinging arm 41 Nm
Swinging-fork pivot axle 100 Nm
Adjusting screw steering head bearing 25
Back off through
angle of rotation 60
Nm
°
Clamp screw for fork bridge steering head 23 Nm
Engine to frame at rear 50 Nm
Cylinder head to frame 41 Nm
Cylinder head to frame, locknut 100 Nm
Engine shell to engine 55 Nm
Engine shell to engine, bottom, with bottom truss 55 Nm
Engine shell to bracing tube 24 Nm
Rear frame to main frame 24 Nm (Loctite 2701)
Exhaust manifold to cylinder head 20 Nm
Silencer to exhaust manifold 55 Nm
UX-VS-2, 07.2001
BMW recommends Castrol