INSTALLATION AND OPERATION MANUAL GAS CHARGRILL G592 G594 G596 G598 For use in GB, IE & DK 228593-20
MANUFACTURED BY Moffat Limited Christchurch New Zealand INTERNATIONAL CONTACTS AUSTRALIA Moffat Pty Limited Web: E.Mail: Main Office: Service: Spares: Customer Service: www.moffat.com.au vsales@moffat.com.au (tel) +61 (03) 9518 3888 (fax) +61 (03) 9518 3833 (tel): 1800 622 216 (tel): 1800 337 963 (tel): 1800 335 315 (fax): 1800 350 281 CANADA Serve Canada Web: E.Mail: Sales: Service: www.servecanada.com info@servecanada.
Contents List G592-B G594-[2] G596-[2] G598-[2] NOTE: Gas Chargrill, 300mm wide - Bench Model. Gas Chargrill, 600mm wide. Gas Chargrill, 900mm wide. Gas Chargrill, 1200mm wide. [2]: LS B - On Leg Stand. - Bench Models. Introduction .............................................................................................. 2 Specification ..............................................................................................
Introduction We are confident that you will be delighted with your BLUE SEAL CHARGRILL, and it will become a most valued appliance in your commercial kitchen. To ensure you receive the utmost benefit from your new Blue Seal CHARGRILL, there are two important things you can do. Firstly: Please read the instruction book carefully and follow the directions given. The time taken will be well spent.
Specifications Model Numbers Covered in this Specification G592-B G594-[2] G596-[2] G598-[2] NOTE: Gas Chargrill, 300mm wide - Bench Model. Gas Chargrill, 600mm wide. Gas Chargrill, 900mm wide. Gas Chargrill, 1200mm wide. [2]: LS B - On Leg Stand. - Bench Models. General A commercial heavy duty, fully modular, gas fired chargrill created for modular kitchens and can be supplied in 4 different sizes with branding grates or optional griddle plates. Fitted with 300mm section stainless steel burners.
Specifications Gas Connection Bench Models (G592 Model Only) Gas supply connection point is located at rear of appliance, approximately 100mm from left hand side, 23mm from rear, 39mm from floor and is reached from rear of appliance. (Refer to ‘Dimensions’ section). Connection is ½" BSP male (For G592 model).
Dimensions G592-B NOTE: G592 are only available in Bench Model (- B) Option. G594-B G596-B G598-B R R 5 = Rating Plate Location for this option.
Dimensions G594-LS G596-LS G598-LS R R 6 = Rating Plate Location for this option.
Installation Installation Requirements NOTE: It is most important that this appliance is installed correctly and that operation is correct before use. Installation shall comply with local, gas, health and safety requirements. This appliance shall be installed with sufficient ventilation to prevent occurrence of unacceptable concentrations of health harmful substances in the room, appliance is installed in.
Installation Clearances NOTE: Only non-combustible materials can be used in close proximity to this appliance. Combustible Surface Non Combustible Surface Left / Right Hand Side 200mm 0mm Rear 150mm 0mm Assembly Bench Models (G592 Model Only) 1. Check all feet are securely fitted. Bench Models (G594 / G596 / G598 Models Only) 1. 2. Check all feet are securely fitted. Adjust feet to make Chargrill steady and level.
Installation Fitting Leg Stand to Chargrill Warning TO PREVENT EQUIPMENT DAMAGE AND RISK OF INJURY, REMOVE ALL CHARGRILL CASTINGS, BURNERS AND OTHER REMOVABLE ITEMS PRIOR TO FITTING THE LEG STAND. 1. Remove grates, griddle plates and radians from chargrill. 2. Lower Chargrill onto it’s rear face. 3. Attach four hob legs to leg mounting positions on underside of chargrill. Secure each leg hand tight. 4.
Installation NOTE: It is important that adequately sized piping runs directly to connection joint on appliance with as few tees and elbows as possible to give maximum supply volume. 3. Fit gas regulator supplied, into gas supply line as close to appliance as possible. For G592, regulator connection is ½" BSP female. Connection on unit is ½" BSP male. For G594/G596/G598 regulator connections are ¾" BSP female. Connection on unit is ¾" BSP male.
Operation Operation Guide Caution This appliance is for professional use and is only to be used by qualified persons. Only authorised service persons are to carry out installation, servicing or gas conversion operations. Components having adjustments protected (e.g. paint sealed) manufacturer should not be adjusted by the user / operator. by the 1. Blue Seal Chargrills have been designed to provide simplicity of operation and 100% safety protection. 2.
Operation Lighting Pilot Burner Warning WHEN THE SOLID GRIDDLE PLATE IS USED, IT'S SURFACE TEMPERATURE CAN REACH OVER APPLIANCE IS OPERATED AT FULL SETTING. 350°C WHEN THE NOTE: All chargrill models incorporate push button piezo ignition system for each individual pilot burner. 1. Depress gas control knob and rotate anti-clockwise to ‘PILOT’ position. 2. With gas control knob depressed, press piezo igniter button located on front control panel, until pilot burner ignites.
Cleaning and Maintenance General Caution Always turn off the gas supply before cleaning. This appliance is not water proof. Do not use water jet spray to clean interior or exterior of this appliance. Clean chargrill regularly. A clean chargrill looks better, will last longer and will perform better. Carbonised grease on surface or on chargrill will hinder transfer of heat from cooking surface to food. This will result in loss of cooking efficiency.
Cleaning and Maintenance Weekly Cleaning NOTE: If chargrill usage is very high, we recommend that weekly cleaning procedure is carried more frequently. Ensure that protective gloves are worn during cleaning process. DO NOT use harsh abrasive detergents, strong solvents or caustic detergents as they will damage chargrill and burners. DO NOT use water on chargrill while grates are still hot as warping may occur. Allow these items castings to cool and remove for cleaning. Grates (Cast Iron) a.
Cleaning and Maintenance Griddle Plate (Steel - Drop-On) (Optional Extra) Caution Always ensure that even pressure is applied over whole surface of scraper tool when using on flat surface of griddle, to prevent scoring of griddle surface. NEVER bang sharp edge of scraper tool on flat surface of griddle as this will damage griddle and invalidate the warranty.
Fault Finding This section provides an easy reference guide to the more common problems that may occur during operation of your equipment. The fault finding guide in this section is intended to help you correct, or at least accurately diagnose problems with your equipment. Although this section covers the most common problems reported, you may encounter a problem not covered in this section.
Gas Conversion and Specifications Conversion Procedure Caution Ensure Appliance is isolated from gas supply before commencing servicing. NOTE: These conversions should only be carried out by qualified persons. All connections must be checked for leaks before re-commissioning the appliance. Adjustment of components that have adjustments / settings sealed (e.g.
Gas Conversion and Specifications Gas Regulator NOTE, Pin rotated for Natural Gas NOTE: Gas regulator supplied is convertible between Natural Gas and LP Gas, but it’s outlet pressure is fixed ex-factory and is NOT to be adjusted. NOTE, Pin rotated for LPG Gas Type Labels On completion of gas conversion, replace gas type labels located at:- Rear of unit, above gas connection. - Beside rating plate. Commissioning Before leaving installation; 1.
Replacement Parts List Replacement Parts List IMPORTANT: Only genuine authorized replacement parts should be used for servicing and repair of this appliance. Instructions supplied with parts should be followed when replacing components. For further information and servicing instructions, contact your nearest authorized service branch (contact details are as shown on reverse of front cover of this manual). When ordering replacement parts, please quote part number and description as listed below.
Replacement Parts List Chargrill 300mm - Main Assembly 20
Replacement Parts List Chargrill 300mm - Gas System Assembly Parts List ITEM 7 13 20 21 22 23 24 25 26 27 28 29 30 31 DESCRIPTION PART NO BURNER PIEZO - SIT SUPPLY PIPE BURNER SHIELD THERMOCOUPLE 320mm M9 x 1 GAS VALVE 21S SPARK ELECTRODE PILOT ASSY 3 WAY PILOT INJECTOR - 0.35mm - NAT GAS PILOT INJECTOR - 0.25mm - LPG / PROPANE / BUTANE PILOT INJECTOR - 0.60mm - TOWNS HT LEAD 250mm RING TERMINAL PILOT TUBE KNOB B-SEAL 8mm GAS PF 6" FLEXITUBE INJECTOR MOUNTING BUSH MAIN INJECTOR - 2.
Replacement Parts List Chargrill 300mm - Gas System Assembly 22
Replacement Parts List Chargrill 600mm / 900mm / 1200mm - Main Assembly Parts List ITEM 1 1a 1a 1b 1b 2 3 4 5 6 7 8 9 10 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 PART No.
Replacement Parts List Chargrill 600mm / 900mm / 1200mm - Main Assembly Bench Mount Option 24
Replacement Parts List Chargrill 600mm / 900mm / 1200mm - Gas System Assembly ITEM PART NO DESCRIPTION G594 G596 7 BURNER 227286 28 SUPPLY PIPE WA BBQ 227182 29 UNION BRASS CONICAL 1/2" BSPT 016044 30 MANIFOLD 31 PILOT BURNER KIT - BBQ 32 PILOT INJECTOR - 0.45mm - NAT. PILOT INJECTOR - 0.30mm - LPG / PROPANE / BUTANE. PILOT INJECTOR - 0.75mm - TOWNS.
Replacement Parts List Chargrill 600mm / 900mm / 1200mm - Gas System Assembly 26
Replacement Parts List Gas Regulators Gas Type Model G592 Nat. Gas LPG Butane Gas Regulators Part No. Description 228533 ½” BSP F/F Convertible. 228531 ¾” BSP F/F Convertible. 230185 ¾” BSP F/F Adjustable. G594 G596 G598 Town Gas ALL Gas Conversion Kits Gas Type to Convert to Model Australia / New Zealand Only UK Only Nat. Gas LPG Nat.
