INSTALLATION AND OPERATION MANUAL ELECTRIC OVEN RANGE E50 E56 For use in GB & IE 229398-3
Contents Blue Seal Electric Static / Convection Oven Ranges - 900 mm E50 E56 Electric Static Oven Range. Electric Convection Oven Range. Introduction..............................................................................................2 Specifications............................................................................................3 Model Numbers Covered in this Specification General Electrical Supply Requirements Electrical Connection Dimensions Installation.............................
Introduction We are confident that you will be delighted with your BLUE SEAL ELECTRIC OVEN RANGE and it will become a most valued appliance in your commercial kitchen. To ensure you receive the utmost benefit from your new Blue Seal ELECTRIC OVEN RANGE, there are two important things you can do. Firstly: Please read the instruction book carefully and follow the directions given. The time taken will be well spent.
Specifications Model Numbers Covered in this Specification E50-D E50-C E50-B E50-A Electric Electric Electric Electric Static Static Static Static Oven Oven Oven Oven E50-D E50-C E50-B E50-A Electric Electric Electric Electric Convection Convection Convection Convection Range Range Range Range Oven Oven Oven Oven with with with with Range Range Range Range 6 Radiant Elements. 4 Radiant Elements / 300 mm Griddle. 2 Radiant Elements / 600 mm Griddle. 900 mm Griddle.
Dimensions Dimensions E50 Hob Options E50-D E50-C E50-B E50-A 4
Dimensions Dimensions E56 Hob Options E56-D E56-C E56-B E56-A 5
Installation Installation Requirements NOTE: • It is most important that this Electric Static / Convection Oven Range is installed correctly and that operation is correct before use. Installation shall comply with local electrical and health and safety requirements. • This appliance shall be installed with sufficient ventilation to prevent the occurrence of unacceptable concentrations of health harmful substances in the room, the appliance is installed in.
Installation Assembly C AUTION : • This appliance is for professional use and is to be used by qualified persons only. • Only qualified service persons are allowed to carry out installation and servicing of this appliance. All Models All models come pre-assembled. NOTE: This appliance is fitted with adjustable feet to enable the unit to be positioned securely and level. This should be carried out on completion of the electrical connection. Refer to “Electrical Connection” section.
Installation Commissioning 1. Before leaving the new installation; a. Check the following functions in accordance with the operating instructions specified in the “Operation” section of this manual. • Check the current draw and loading for the equipment. Refer to the 'Specifications' section for correct electrical requirements. • Check that all the connections are correct and that all cover panels have been re-fitted. • Check that the appliance functions in accordance with the operating instructions.
Operation Operation Guide C AUTION : • This appliance is for professional use and is to be used by qualified persons only. • Only qualified service persons are allowed to carry out installation and servicing of this appliance. 1. 2. Blue Seal Electric Static / Convection Oven Ranges have been designed to provide simplicity of operation. They can be fitted with 300mm, 600mm or 900mm griddle option depending on range size.
Operation Heat Control Radiant Elements Convection Oven (E56 Series) ๐ OFF Position LOW Position 1 Position 2 Position 3 Position Position 4 HIGH Position Power Indicator Lamps (Clear) Heating Indicator Lamps (Amber) Griddle Only Heating Indicator Lamp (Amber) Griddle Plate (If Fitted) & Oven Temperature Control ๐ OFF Position 50°C to 300°C Temperature Graduations Power Indicator Lamp (green) Fig 3 Hob Element / Griddle Options Open Radiant Elements Solid Radiant Elements Griddle Plate Fig 4 1
Operation Radiant Elements (Solid or Open) The controls for the radiant elements may be set at any position between high and low to provide the desire level of heating. An individual green neon for each element, will glow when the element is switched 'ON' to show that there is power to the element. Start cooking at the highest setting and change to a lower setting when the desired temperature is reached.
Cleaning and Maintenance C AUTION : Always turn off the electrical power supply at the mains supply before cleaning. This appliance is not water proof. Do not use water jet spray to clean interior or exterior of this appliance. General Clean the range regularly. A clean appliance looks better, will last longer and will perform better. Carbonised grease on the surface or on the griddle plate (If fitted) will hinder the transfer of heat from the cooking surface to the food.
Cleaning and Maintenance Daily Cleaning 1. 2. 3. 4. The grease drawer should be checked and emptied frequently to prevent overflow and spillage. Remove the grease drawer while still warm so that the grease is in a liquid state. Empty any grease from the drawer and wash thoroughly in the same manner as any cooking utensil. Thoroughly clean the splash back, the interior and exterior surfaces of the range with hot water, a detergent solution and a soft scrubbing brush.
Cleaning and Maintenance Periodic Maintenance To achieve the best results cleaning must be regular and thorough and all controls and mechanical parts checked and adjusted periodically by a competent serviceman. If any small faults occur, have them attended to promptly. Don't wait until they cause a complete breakdown. It is recommended that the appliance is serviced every 6 months.
Fault Finding This section provides an easy reference guide to the more common problems that may occur during the operation of your appliance. The fault finding guide in this section is intended to help you correct, or at least accurately diagnose problems with your equipment. Although this section covers the most common problems reported, you may encounter a problem not covered in this section.
BOTTOM ELEMENT 900 (1200 SINGLE) 750 TOP ELEMENT 900 (1200 SINGLE) 750 #228059 4.5kW #228719 3.75kW #228082 2.0kW #228718 1.
BOTTOM ELEMENT 900 (1200 SINGLE) 750 TOP ELEMENT 900 (1200 SINGLE) 750 #228059 4.5kW #228719 3.75kW #228082 2.0kW #228718 1.
Circuit Schematics Cook Top - 6 Elements (E50-D & E56-D Models) Cook Top - 4 Elements - 300 mm Griddle (E50-C & E56C Models) E 29 30 23 21 20 26 24 22 27 25 L1 L2 L3 N N 34 13 17 29 E 16 12 29 28 30 28 E 29 E 29 E 31 15 11 28 28 10 14 LEFT 9 CENTRE 13 REAR PHASE 8 12 REAR NEUTRAL 7 11 FRONT NEUTRAL FRONT PHASE 6 2 2 8 23 LEFT 25A 22 L3 FRONT PHASE 6 RED MARK 15 FRONT NEUTRAL 2 2 NOT USED BLUE MARK NOT USED BLACK MARK 14 25 CENTRE 25A 24 L2 P
Circuit Schematics Cook Top - 2 Elements - 600 mm Griddle (E50-B & E56-B Models) Cook Top - 900 mm Griddle (E50-A & E56-A Models) 19
Replacement Parts List Replacement Parts List IMPORTANT: Only genuine authorized replacement parts should be used for the servicing and repair of this appliance. The instructions supplied with the parts should be followed when replacing components. For further information and servicing instructions, contact your nearest authorized service branch (contact details are as shown on the reverse of the front cover of this manual).
Replacement Parts List General 227892 227893 227896 227850 227963 228922 229674 227850 Oven Side Rack LH. Oven Side Rack RH. Oven Rack. Adjustable Legs. Neon Orange. Neon White. Rear Roller Kit. Adjustable Legs - 150mm. Accessories 228566 228567 228799 Griddle Scraper Tool. Smooth Plate Scraper Blades (Pack of 5 Blades). 900 mm Plinth Kit. Utensils Direct 0845 873 6600 www.utensilsdirect.co.
