631 OWNERS MANUAL For 10 Sunnen Drive St. Louis, MO 63143 telephone: 314-678-6336 fax: 314-781-2714 www.wellsbloomfield.com BREWING SYSTEMS MODELS POUR OVER BREWER 4543-D2 POUR OVER AIRPOT BREWER 4774-A Includes: Installation Use & Care Servicing Instructions Model 4774-A Airpot Brewer with optional 7760-ALM Airpot Model 4543-D2 Brewer with optional 8900-Series Glass Decanters p/n 2M-Z16993 Rev.
WARRANTY STATEMENT All electrical equipment manufactured by BLOOMFIELD is warranted against defects in materials and workmanship for a period of one year from the date of original installation (1 year labor, two years parts) and is for the benefit of the original purchaser, except that: A. airpots carry a 30 day parts warranty only. B. dispensers; i.e., tea and coffee carry a 90 days parts warranty only, excludes decanters. C. decanters are not covered by this warranty D.
TABLE OF CONTENTS WARRANTY STATEMENT SPECIFICATIONS PRECAUTIONS & GENERAL INFORMATION AGENCY APPROVAL INFORMATION INSTALLATION INSTRUCTIONS OPERATION BREWING COFFEE CLEANING INSTRUCTIONS TROUBLESHOOTING SUGGESTIONS SERVICING INSTRUCTIONS Deliming Instructions xi 1 2 2 3 5 7 8 9 10 10 Thank You for purchasing this Wells Bloomfield appliance.
PRECAUTIONS AND GENERAL INFORMATION WARNING: ELECTRIC SHOCK HAZARD WARNING All servicing requiring access to non-insulated components must be performed by qualified service personnel. Do not open any access panels which require the use of tools. Failure to heed this warning can result in electrical shock. WARNING: INJURY HAZARD WARNING All installation procedures must be performed by qualified personnel with full knowledge of all applicable electrical and plumbing codes.
INSTALLATION INSTRUCTIONS READ THIS CAREFULLY BEFORE STARTING THE INSTALLATION IMPORTANT: To enable the installer to make a quality installation and to minimize installation time, the following suggestions and tests should be done before the actual unit installation is started: CAUTION: EQUIPMENT DAMAGE DO NOT plug in or energize this appliance until all Installation Instructions are read and followed.
START UP IMPORTANT: Never pour more than 9 cups (2.2 liter) of water into the water reservoir. A. INITIAL START-UP BEFORE BREWING COFFEE For initial start-up, or if the brewer has not been used for an extended period of time: Please check that your EMPTY brew chamber is assembled correctly, with the spring wedged firmly at the bottom of the basket. DO NOT ADD COFFEE. 1. Place the machine on a firm level surface with plenty of space above it to place a decanter.
BREWING COFFEE A. PREPARATION Place one (1) genuine Bloomfield paper filter in the brew chamber. Add a pre-measured amount of fresh coffee grounds. Gently shake the brew chamber to level the bed of grounds. Slide the brew chamber into place under the brew head. CAUTION: BURN HAZARD Exposed surfaces of the brewer, brew chamber and decanter may be HOT to the touch, and can cause serious burns. IL1605 Fig. 7 Brew Chamber B. POUR-OVER OPERATION Be sure the unit’s power switch is on.
CLEANING INSTRUCTIONS PROCEDURE: Clean Coffee Brewer CAUTION: SHOCK HAZARD Do not submerge or immerse brewer in water. IMPORTANT: DO NOT use steel wool, sharp objects, or caustic, abrasive or chlorinated cleansers to clean the brewer. PRECAUTIONS: Disconnect brewer from electric power. Allow brewer to cool. FREQUENCY: Daily TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Bristle Brush. 1. Disconnect brewer from electric power. Allow brewer to cool before cleaning. IMPORTANT: 2.
DELIMING INSTRUCTIONS PROCEDURE: Delime the Water Tank CAUTION: PRECAUTIONS: Disconnect Power and allow brewer to cool. CHEMICAL BURN HAZARD FREQUENCY: As Required TOOLS: Deliming Solution Protective Gloves, Goggles & Apron In areas around the water boiler, hard water will cause a mineral to build-up as the unit is used.
TROUBLESHOOTING SUGGESTIONS SYMPTOM POSSIBLE CAUSE Brewer unplugged or circuit breaker tripped SUGGESTED REMEDY Check power supply cord Check / reset circuit breaker Allow to cool Coffee level low (pour-over) Brew chamber overflows Sprays water from brew head Poor coffee quality Hi-Limit thermostat tripped Reset hi-limit Perform Deliming Procedures Damaged internal component or wiring Examine wiring & connectors, thermostat and heating element, Repair/replace as needed Pourover - no water or too l
SPARE PARTS Spare Parts List Descripation. Models Fig No. Parts No.
EXPLODED VIEW; 4543-D2 Model: 4543-D2 Drain Pipe 2M-Z16993-631 ECO Style Brewers 51 11
EXPLODED VIEW; 4774-A Model: 4774-A 53 2M-Z16993-631 ECO Style Brewers 52 12
2M-Z16993-631 ECO Style Brewers NOTES 13
2M-Z16993-631 ECO Style Brewers NOTES 14
10 Sunnen Drive, St. Louis, MO 63143 telephone: 314-678-6336 fax: 314-781-2714 www.wellsbloomfield.
