Service manual

Combi-Oven Maintenance
20
Cleaning
The construction of the BKI Combi makes it very easy to clean. The oven compartment is all-welded in
stainless steel and accordingly splash proof. You will find the easy-to-use hand shower with flexible hose
very suitable for inferior cleaning.
The door gasket at the oven door can easily be removed which ensures a quick and efficient cleaning
around it
The flat front panel also makes the exterior cleaning quick and efficient.
1. Interior cleaning
Manual Method
a. Always clean the oven when it is cold or cool the oven compartment down to below 140°F.
b. Add mild or strong oven detergent (according to requirement) with a soft brush to the sides of
the oven compartment, rack etc. Protect your face and hands as the oven detergent may be
caustic.
c. Leave the oven detergent for approx. 5-10 min.
d. With the MULTI STEAMING mode, the oven is set to steam for approximately 10 min. at
194°F.
e. Flush the oven compartment with the hand shower.
f. Check that the water can pass freely through the drain. The grating that comes with the oven is
to be placed over the drain hole inside the oven.
Integrated Cleaning Program (CVC and S Controllers only)
a. Choose the cleaning program (“198” for CVC controller and “C” for S controller). The display
says “CLEA”.
b. Press “START”.
c. Apply an oven detergent with a soft brush or a sprayer when the alarm sounds and the display
says ”SOAP”.
d. Close the oven door.
e. When the alarm sounds and the display says ”AQUA”, rinse the oven chamber with the hand
shower.
Never use high-pressure cleaner. Never spray water directly on heating
elements behind the filter housing.
2. Cleaning behind filter housing
For a more thorough cleaning of the oven compartment, the filter housing is removed so that it is
possible to clean at the fan and the heating elements. You loosen the 2 screws (A) and (B) on the
filter housing. The filter housing is demounted by lifting it up till it is clear of the bottom pin and then
tipping it.