INSTALLATION AND OPERATING INSTRUCTIONS for all WTFCS Worktop Freezer Models 809-177A Rev. A. 02/20/2023 3779 CHAMPION BLVD, WINSTON-SALEM, NC 27105 Phone: (888) 845-9800 | Fax: (800) 253-5168 | Web: beverage-air.
User Manual for WTFCS Freezers Beverage-Air WELCOME Thank you for purchasing a Beverage-Air cabinet. This series has passed our strict quality control inspection and meets the high standards set by Beverage-Air! You have made a quality investment that with proper maintenance will give you many years of reliable service! Please read the following installation and maintenance instructions before installing or using your unit.
User Manual for WTFCS Freezers Beverage-Air SAFETY This appliance has been designed with your safety in mind. It has many features to keep you from being harmed. However, safe operation and maintenance are your responsibilities.
User Manual for WTFCS Freezers Beverage-Air SAFETY Note: The top panel of this unit can be damaged by standing on it. Damage like that is NOT covered by warranty. WARNING Risk of Personal Injury From Falling Stay OFF top of unit NO STEP 4 NO STEP NO STEP Beverage-Air Rev.
User Manual for WTFCS Freezers Beverage-Air IMPORTANT INFORMATION This unit is intended to be used in a commercial application. That includes schools and cafeterias. If installed in a residence some commercial service companies may not be able to service it on site. The manufacturer has designed and produced this machine with the finest in materials. The manufacturer assumes no liability for units that have been altered in any way. Alterations or part substitutions will void the warranty.
User Manual for WTFCS Freezers Beverage-Air PRODUCT INFORMATION Model Cabinet Dimensions w x d x h (Inches) WTFCS36HC 36 x 34 3/4 x 24 3/8 WTFCS36HC-48* 48 X 34 3/4 X 24 3/8 WTFCS48HC 48 x 34 3/4 x 24 3/8 WTFCS52HC 52 x 34 3/4 x 24 3/8 WTFCS60HC 60 x 34 3/4 x 24 3/8 WTFCS60HC-64* 64 x 34 3/4 x 24 3/8 WTFCS72HC 72 x 34 3/4 x 24 3/8 WTFCS72HC-76* 76 x 34 3/4 x 24 3/8 WTFCS84HC 84 x 34 3/4 x 24 3/8 WTFCS84HC-89* 89 x 34 3/4 x 24 3/8 WTFCS84HC-96* 96 x 34 3/4 x 24 3/8 WTFCS96HC 96 x 3
User Manual for WTFCS Freezers Beverage-Air CLEARANCE AND PLACEMENT Placement Consider the following when selecting a location for your freezer: Clearance: • 0 in. at the top • 1.0 in. at the rear, • 0.0 in. at the left side • 0.0 in. at the right side • 3 13/16 in. below Floor Load: The floor on which the freezer is located must be even and level, free from vibrations, and strong enough to support the combined weights of the unit and maximum product load.
User Manual for WTFCS Freezers Beverage-Air UNPACKING AND SET UP Carefully inspect the shipping carton for damage. This is the only time that shipping damage may be claimed. If damage is suspected, open the carton immediately and, if there is damage, retain the carton and contact the shipper to make a claim. Do NOT contact the manufacturer. Uncrating Tools Needed: ¾” box wrench, adjustable wrench, level, flat head screw driver, and box cutter.
User Manual for WTFCS Freezers Beverage-Air ELECTRICAL This is a cord-connected unit, and must be connected to its own dedicated power supply. Check the dataplate on the machine to confirm the voltage and per the dataplate use the correct fuses or HACR circuit breakers. Note: Do not connect to GFI / GFCI outlets. Connection to that type of outlet can result in product loss due to unsafe cabinet temperature when GFI device trips from moisture.
User Manual for WTFCS Freezers Beverage-Air USING THE UNIT Operation is simple, just keep it connected to the correct power supply and the freezer will maintain the internal temperature it has been set to. Keep the drawers closed as much as possible to avoid unnecessary run time. The internal fan will be on whenever the appliance is connected to power. The controller displays the current internal temperature. Adjusting the set temperature lower will NOT cause the system to lower the temperature faster.
User Manual for WTFCS Freezers Beverage-Air SEQUENCE OF OPERATIONS FREEZER The freezer operates based on the air temperature measured by the probe located at the return air. ON COMPONENT OPERATION OFF CONTROLLER ACTION Compressor turns on when the air temperature at the probe is above the sum of the set point + 2.
Condition Condenser Fan Evaporator Fan Defrost Heater Face/Door Heater Drain Heater Beverage-Air Compressor User Manual for WTFCS Freezers Cabinet Temp > Set point + 2.5 ON ON ON OFF ON ON Cabinet Temperature <= Set point - 2.
User Manual for WTFCS Freezers Beverage-Air Keyboard Functions UP DOWN DEFROST (ESC) Quick press and release Quick press and release Quick press and release • Increases Set Point • Decreases Set Point • Activates manual defrost Long press and release Long press and release Long press and release • Increases display brightness • Decreases display brightness • Controller enter stand-by mode SET (ENTER) Quick press and release • Toggles lights on/off Long press and release • Toggles display °
User Manual for WTFCS Freezers Beverage-Air Control Panel Connections Changing the Set point 14 Beverage-Air Rev.
User Manual for WTFCS Freezers Beverage-Air Keyboard Functions Electronic Controller Alarms The alarm condition is always signaled by the alarm icon will continue flashing. . Press any button to silence the alarm, the relative icon NOTE: If alarm exclusion times are in progress (ALA folder of the parameter table), the alarm is not signaled.
User Manual for WTFCS Freezers Beverage-Air CLEANING AND MAINTENANCE Cleaning Schedule: Cabinet Condenser coil Gaskets Routine maintenance Daily wipe down Quarterly cleaning Daily inspection, check that hinges are tight to the cabinet. Annually Weekly interior Daily Exterior Cleaning It is much easier to clean on a regular basis than to have to remove stains once they have built up. 1. Wash with a clean sponge and a mild detergent that does not contain chlorine. 2. Rinse with clean water. 3.
User Manual for WTFCS Freezers Beverage-Air DRAWER CLEANING AND MAINTENANCE Drawer models are shipped with the drawers already installed in the cabinets. Drawers are designed with slides which have locking mechanisms to prevent drawers from coming off cabinets during normal opening and closing operations. See illustration below: Drawers and slides can be removed from a cabinet for cleaning purposes. To remove a drawer from a cabinet follow these instructions: 1. Open the drawer to full extension 2.
User Manual for WTFCS Freezers Beverage-Air CONDENSER CLEANING Keeping the condenser coil clean is critical to efficient operation. 8. Reconnect electric power and check operation. The condenser coil is located right behind the front grille of the cabinet. It should be inspected once a month and cleaned as required. Vacuum clean all surfaces of the condenser. Make sure no fins are bent or damaged in the process. If there are bent fins, carefully straighten them so that air can flow through the coils.
User Manual for WTFCS Freezers Beverage-Air METHODS FOR CLEANING STAINLESS STEEL Cleaning Needed Cleaning Agent Method of Application Affect on Finish Smears and fingerprints Areal 20, Lac-O-Nu, Lumin Wash O’Cedar Cream Polish, Stainless Shine. Rub with cloth as directed on the package. Satisfactory for use on all finishes. Provides barrier film to minimize prints. Allchem Concentrated Cleaner. Apply with damp sponge or cloth. Rub with damp cloth.
User Manual for WTFCS Freezers Beverage-Air HELP Trouble Diagnosis for the User Malfunction Possible Cause Likely Solution No cooling - unit is silent Unit not plugged in. Fuse or circuit breaker tripped. Power cord plug loose in outlet. Connect to proper voltage circuit Replace fuse or reset breaker.
User Manual for WTFCS Freezers Beverage-Air FOR THE SERVICE TECH - R290 Refrigeration service should only be attempted by a trained trade professional certified to work on R290 systems. Here are some critical service items. Other Information: This list does not qualify anyone to service the unit. It is a reminder and checklist for the service tech. Keep these in mind for R290 service: Evacuation: It is critical that a refrigeration system be leak free and internally dry.
User Manual for WTFCS Freezers 8 Beverage-Air 5 6 7 FOR THE SERVICE TECH - WIRING DIAGRAM 4 WHITE BLACK CNTRL 2 3 *SEE CONTROLLER DETAIL 3 COMPRESSOR DETAIL D CONDENSER FAN 1 2 *SEE CONTROLLER DETAIL START RELAY 4 R C COMP OL 10 R.C. S S.C.
User Manual for WTFCS Freezers Beverage-Air LIMITED WARRANTY WARRANTY (Warranty valid in USA and Canada) BEVERAGE-AIR THREE (3) YEAR PARTS AND LABOR WARRANTY: Also, this extended compressor-part only warranty does NOT apply to any electrical controls, condenser, evaporator, fan motors, overload switch, starting relay, capacitors, temperature control, filter/drier, accumulator, refrigeration tubing, wiring harness, labor charges, or supplies which are covered by the warranty above.
User Manual for WTFCS Freezers Beverage-Air LIMITED WARRANTY (CONTINUED) With the exception of Blast Chillers product is designed for maintaining temperature and not bringing food to a desired temperature therefore cannot be held responsible for this function under warranty. Units must be in a conditioned environment or warranty will be void. Condensing coils must be cleaned at regular intervals. Failure to do so can cause compressor malfunction and will void warranty.
User Manual for WTFCS Freezers Beverage-Air Warranty Registration Register your product online at beverage-air.com/parts-service or fill out and mail the form below.
