INSTALLATION AND OPERATING INSTRUCTIONS for all MMF Freezer Models 809-151A 07/25/2022 3779 CHAMPION BLVD, WINSTON-SALEM, NC 27105 Phone: (888) 845-9800 | Fax: (800) 253-5168 | Web: beverage-air.
User Manual for MMF Freezers Beverage-Air WELCOME Thank you for purchasing a Beverage-Air cabinet. This series has passed our strict quality control inspection and meets the high standards set by Beverage-Air! You have made a quality investment that with proper maintenance will give you many years of reliable service! Please read the following installation and maintenance instructions before installing or using your unit.
User Manual for MMF Freezers Beverage-Air SAFETY This appliance has been designed with your safety in mind. It has many features to keep you from being harmed. However, safe operation and maintenance are your responsibilities.
User Manual for MMF Freezers Beverage-Air SAFETY CAUTION CAUTION: If it is necessary to move the Freezer after removal from the skid, remove all doors and carefully push the unit at a point of no more than 36” from the bottom to avoid damage. Height will vary by model Push ONLY below the 36 inch / .91 meter height 4 Beverage-Air Rev.
User Manual for MMF Freezers Beverage-Air IMPORTANT INFORMATION This unit is intended to be used in a commercial application. That includes bars and restaurants. If installed in a residence some commercial service companies may not be able to service it on site. The manufacturer has designed and produced this machine with the finest in materials. The manufacturer assumes no liability for units that have been altered in any way. Alterations or part substitutions will void the warranty.
User Manual for MMF Freezers Beverage-Air PRODUCT INFORMATION Model Cabinet Dimensions w x d x h (Inches) MMF12HC-1 24 1/8 x 25 3/4 x 62 MMF19HC-1 27 1/4 x 27 1/2 x 78 1/8 MMF23HC-1 27 x 33 5/8 x 78 MMF27HC-1 30 x 33 5/8 x 78 MMF35HC-1 39 1/2 x 33 1/2 x 78 1/8 MMF44HC-1 47 x 33 1/2 x 78 MMF49HC-1 52 x 33 1/2 x 78 MMF72HC-5 75 x 33 1/2 x 78 Half or Full Door Glass or Solid Door Full Load Amps Power Cord Plug (NEMA) R-290 / 50 / 1.
User Manual for MMF Freezers Beverage-Air CLEARANCE AND PLACEMENT 6" TOP MINIMUM CLEARANCE 0" LEFT/RIGHT SIDE MINIMUM CLEARANCE 3" REAR MINIMUM CLEARANCE 0" BOTTOM MINIMUM CLEARANCE Placement Consider the following when selecting a location for your freezer: Clearance: • 6 in. at the top • 3.0 in. at the rear, • 0.0 in. at the left side • 0.0 in. at the right side • 0.
User Manual for MMF Freezers Beverage-Air UNPACKING AND SET UP Carefully inspect the shipping carton for damage. This is the only time that shipping damage may be claimed. If damage is suspected, open the carton immediately and, if there is damage, retain the carton and contact the shipper to make a claim. Do NOT contact the manufacturer. Uncrating Note: additional clear plastic protective wrap is applied directly to any product with a glass door.
User Manual for MMF Freezers Beverage-Air LEVELING Cabinets must be leveled when installed. Level should be measured on the headrail. Failure to level your cabinet may result in door not sealing, closing correctly, or condensed water draining not draining properly. For cabinets with legs, rotate the foot of the leg with an adjustable wrench to achieve desired height for leveling.
User Manual for MMF Freezers Beverage-Air SHELF INSTALLATION 1. Determine the proper location for the shelf clips. The reference numbers on the pilaster can serve as a guide to ensure all clips are properly located. 2. Insert the top tab of the shelf clip into the desired hole of the pilaster. The retaining tab MUST be facing up as shown. 3. Rotate the clip downwards and insert the bottom tab into the matching hole in the pilaster. The clip may need to be squeezed slightly during installation. 4.
User Manual for MMF Freezers Beverage-Air ELECTRICAL This is a cord-connected unit, and must be connected to its own dedicated power supply. Check the dataplate on the machine to confirm the voltage and per the dataplate use the correct fuses or HACR circuit breakers. Note: Do not connect to GFI / GFCI outlets. Connection to that type of outlet can result in product loss due to unsafe cabinet temperature when GFI device trips from moisture.
User Manual for MMF Freezers Beverage-Air USING THE UNIT Operation is simple, just keep it connected to the correct power supply and the refrigerator will maintain the internal temperature it has been set to. Keep the doors and / or drawers closed as much as possible to avoid unnecessary run time. The controller displays the current internal temperature. Adjusting the set temperature lower will NOT cause the system to lower the temperature faster.
User Manual for MMF Freezers Beverage-Air SEQUENCE OF OPERATIONS FREEZER The freezer operates based on the air temperature measured by the probe located at the return air. ON OFF COMPONENT OPERATION CONTROLLER ACTION OPERATION Compressor turns on when the air temperature at the probe is above the sum of the set point + 2.
KL KL KL K77 KL KL KLÿ,3ÿK77 K77 K77 K77 K77 K77 KL KLÿ,3ÿK77 K77 K77 K77 KL K77Beverage-Air KL KLÿ,3ÿK77 0123ÿ567869ÿ 3ÿ ÿ322 231QRÿSTUVWXYTÿ[WXUVWRRSV +,-./0/,- ÿ +,123455,3 +,-.
0123ÿ567869ÿ 3ÿ ÿ 2 236 2 3 Beverage-Air User Manual for MMF Freezers ()*+,ÿ./ÿ01023ÿ4561789:;ÿ<9348ÿ024ÿ9;ÿ=2:>2488ÿ?@A@ÿ/:1C42ÿ:/ÿ;014CH ÿ Rev.
User Manual for MMF Freezers Beverage-Air CLEANING AND MAINTENANCE Cleaning Schedule: Cabinet Condenser coil Gaskets Routine maintenance Daily wipe down Quarterly cleaning Daily inspection, check that hinges are tight to the cabinet. Annually Weekly interior Daily Exterior Cleaning It is much easier to clean on a regular basis than to have to remove stains once they have built up. 1. Wash with a clean sponge and a mild detergent that does not contain chlorine. 4.
User Manual for MMF Freezers Beverage-Air CONDENSER CLEANING Keeping the condenser coil clean is critical to efficient operation. 1. Unplug unit from power supply. Remove Screw CAUTION Rotating fan blade can cause personal injury. Unplug unit from power supply before beginning to clean condenser 2. Remove the single Phillips head screw at the top or bottom of the panel depending on the model. 3. Lift upwards on the front panel to remove 4.
User Manual for MMF Freezers Beverage-Air METHODS FOR CLEANING STAINLESS STEEL Cleaning Needed Cleaning Agent Method of Application Affect on Finish Smears and fingerprints Areal 20, Lac-O-Nu, Lumin Wash O’Cedar Cream Polish, Stainless Shine. Rub with cloth as directed on the package. Satisfactory for use on all finishes. Provides barrier film to minimize prints. Allchem Concentrated Cleaner. Apply with damp sponge or cloth. Rub with damp cloth.
User Manual for MMF Freezers Beverage-Air HELP Trouble Diagnosis for the User Malfunction Possible Cause Likely Solution No cooling - unit is silent Unit not plugged in. Fuse or circuit breaker tripped. Power cord plug loose in outlet. Connect to proper voltage circuit Replace fuse or reset breaker.
User Manual for MMF Freezers Beverage-Air FOR THE SERVICE TECH - R290 Refrigeration service should only be attempted by a trained trade professional certified to work on R290 systems. Here are some critical service items. Other Information: This list does not qualify anyone to service the unit. It is a reminder and checklist for the service tech. Keep these in mind for R290 service: Evacuation: It is critical that a refrigeration system be leak free and internally dry.
User Manual for MMF Freezers Beverage-Air FOR THE SERVICE TECH - WIRING DIAGRAM FOR ONE SYSTEM MODELS W H IT E B L AC K 2 CNTRL 3 *SEE CONTROLLER DETAIL COMPRESSOR DETAIL CONDENSER FAN START RELAY R 1 2 OL BLACK WHITE *SEE CONTROLLER DETAIL 10 4 S.C. C COMP S R.C. 1 2 FACE HEATER GLASS DOOR HEATER (NOT ALL MODELS) 6 DEFROST HEATER W H IT E B L AC K 2 *SEE CONTROLLER DETAIL HEATER SAFETY SWITCH 2 D.I. 2 D.I.
User Manual for MMF Freezers Beverage-Air FOR THE SERVICE TECH - WIRING DIAGRAM FOR TWO SYSTEM MODELS 2 C NT R L 3 YELLOW YELLOW 0 SCR 1 WHITE 2 *S E E C O N T R O L L E R D E T A I L WHITE BLACK *S E E C O N T R O L L E R D E T A I L 1 *S E E S E P E R A T E R E L A Y D E T A I L C O MP R E S S O R D E T A I L C O NDE NS E R F AN *S E E S C R D E T A I L S T AR T R E L AY 4 R 8 10 6 S .C . BLACK YELLOW WHITE 4 2 OL C C O MP *S E E S C R D E T A I L R .C .
User Manual for MMF Freezers Beverage-Air LIMITED WARRANTY WARRANTY (Warranty valid in USA and Canada) BEVERAGE-AIR THREE (3) YEAR PARTS AND LABOR WARRANTY: Also, this extended compressor-part only warranty does NOT apply to any electrical controls, condenser, evaporator, fan motors, overload switch, starting relay, capacitors, temperature control, filter/drier, accumulator, refrigeration tubing, wiring harness, labor charges, or supplies which are covered by the warranty above.
User Manual for MMF Freezers Beverage-Air LIMITED WARRANTY (CONTINUED) With the exception of Blast Chillers product is designed for maintaining temperature and not bringing food to a desired temperature therefore cannot be held responsible for this function under warranty. Units must be in a conditioned environment or warranty will be void. Condensing coils must be cleaned at regular intervals. Failure to do so can cause compressor malfunction and will void warranty.
User Manual for MMF Freezers Beverage-Air Warranty Registration Register your product online at beverage-air.com/parts-service or fill out and mail the form below.
