Product Manual

6 7
IMPORTANT SAFETY WARNINGS
WARNING
Serious injury may occur from touching the gasoline engine, muer, or heat exchanger.
These areas can remain hot for some time after the pressure washer is shutdown.
• Never allow any part of your body to contact the gasoline engine, muer, or heat exchanger.
WARNING
Serious injury may occur to the operator from moving parts on the pressure washer.
• Before making any adjustments, be certain the engine is turned o and the ignition cable(s) is
removed from the spark plug(s). Turning the machinery over by hand during adjustment or cleaning
might start the engine and machinery with it.
• Do not operate the unit without all protective covers in place.
WARNING
Serious injury may occur from a pressure washer malfunction or exploding accessories if
incorrect system components, attachments, or accessories are used.
Serious injury or death may occur if attempting to start the pressure washer when the
pumping system is frozen.
• Never make adjustments to the factory set pressures.
• Never exceed manufacturers maximum allowable pressure rating of attachments.
• Do not allow any hoses to make contact with heat exchanger to prevent the possibility of bursting.
Avoid dragging the hoses over abrasive surfaces such as cement.
• Use only manufacturer recommended repair parts for your pressure washer.
• In freezing temperatures, the unit must always be warm enough to ensure there is no ice formation
in the pump. Do not start the pressure washer if it has been transported in an open or under heated
vehicle without first allowing the pump to thaw.
WARNING
Serious injury or death may occur from detergents contacting the skin.
Serious injury can occur from loose debris being propelled at a high speed from the spray
gun.
Injury may occur if the operator loses their balance caused by the thrust of water traveling
through the spray nozzle.
• Never use any solvents or highly corrosive detergents or acid type cleaners with this pressure washer.
• Protective equipment such as rubber gloves and respirators are advisable, especially when using
cleaning detergents.
• Keep all detergents out of the reach of children!
• Always wear protective goggles when operating the unit to shield the eyes from flying debris and
detergents.
• Do not direct spray toward fragile materials such as glass.
• Stay alert: watch what you are doing. Do not operate the unit when fatigued or under the influence of
alcohol or drugs.
• Never squeeze the trigger unless securely braced.
• Do not overreach or stand on unstable support.
• Wet surfaces can be slippery. Wear protective foot gear and keep good footing/balance at all times.
• Never pull the trigger of the gun while on a ladder, roof, or other unstable surface.
• Always hold on firmly to the gun/lance assembly when starting and operating the unit. Failure to do so
can cause the lance to fall and whip dangerously.
• Do not leave pressurized unit unattended. Shut o the pressure washer and release trapped pressure
before leaving.
• Do not operate the unit if you see any fuel, oil, or water leaking from the machine. DO NOT resume
operation until the unit has been inspected and repaired by a qualified technician.
• Do not transport the unit by pulling on hoses or cords.
FEATURES
OIL / DIESEL FIRED
Adjustable thermostat
up to 200°F with LED rocker
switch and hour/tach meter
Heavy-duty roll-cage powder
coated 1.5” OD steel tube
frame, with centre balanced
lift hook (
above industry standards)
American made
heavy duty 7000 PSI
rupture disk
7-gallon, removable,
rust-proof polyethylene
fuel tank with fuel
gauge in cap
Brake assembly
Marine sealed battery
box with 55 AH AGM deep
cycle battery
Adjustable pressure
relief valve
triplex direct-drive
general pump carries
a 5-year warranty
Honda GX390 electric
start w/ 18amp charge
12” oil drain hose for
ease of maintenance
3/4”HD Threaded
mount axle
360° Hose reel
swivel bracket
CC’sPSIGPM MODEL
SHIP WT
(lbs)
SHIPPING
DIMENSIONS
UNIT
DIMENSIONS
BURNER FUEL
CONS.
DRIVEPUMP MODEL BTU/HRENGINE
• Gun/wand assembly with insulated grip
and quick connects
• 50’ high pressure hose w/quick connects
• 20% chemical injector assembly w/quick
connects
• 4 color-coded QC spray nozzles
• 1 color-coded QC chemical nozzle
DIRECT DRIVE
HONDA
GX390
GENERAL PUMP
EZ4040
3894 HW4013HG 4000 DIRECT 2.21 GPH 47”L x 31”W x 50”H 52”L x 36”W x 55”H 530330,000
HOT WATER
PRESSURE WASHER
Stainless-steel coil
skin provides extra
durability and
resists corrosion
HEATING COIL
½” Heavy-duty schedule 80
American made Carbon
Steel Cold-rolled pipe,
no weak points from
heating to make bends
5500PSI Rated,
“Full Sized” 96’ length for
maximum heat rise and
proper heat production
12v DC Oil-fired
Beckett burner
with low voltage
inhibitor, prevents
burner from starting
up if battery voltage
is dropped
Mounting bracket
for truck mounting
13” heavy-duty
flat free tires
GETTING TO KNOW YOUR WASHER
Electric Start engine
w/ 18 amp charge
Triplex Direct-Drive
pump carries a
5-Year Warranty
Low pressure chemical injector assembly
to draw cleaner/detergent