Product Manual

4 5
IMPORTANT SAFETY WARNINGS
This is the safety alert symbol. It is used to alert you
to potential personal injury hazards. Obey all safety
messages that follow this symbol to avoid possible
injury or death.
explosion fire
toxic fumes
hot surface
flying objects injection
moving parts
electric shock
DANGER
This is indicates a hazard which, if not avoided, will result in serious
injury or death.
WARNING
This indicates a hazard which, if not avoided, will result in a severe injury or
property damage.
CAUTION
This indicates a hazard which, if not avoided, might result in a minor or
moderate injury.
NOTICE
This indicates a situation that could result in equipment damage or damage
to other property. Ensure all safety messages are observed and adhered to.
Hazard Symbols and Meanings
DANGER
• Always operate the pressure washer in a well-ventilated area free of flammable vapors, combustible
dust, gases, or other combustible materials.
• Do not store the pressure washer near an open flame or any equipment such as a stove, furnace, water
heater, etc., which utilizes a pilot light or sparking device.
• Do not use this pressure washer to spray flammable material.
• Do not smoke while filling burner fuel tank.
• Never fill the fuel tanks while the pressure washer is running or hot. Allow unit to cool for two minutes.
• Always refuel slowly to avoid the possibility of spilled fuel which may cause a risk of fire.
• Always leave room for fuel to expand in the gas tank. Do not overfill.
• Engine Fuel Tank: If using a Gasoline Engine, refuel with gasoline only. Do not use diesel or kerosene.
• Burner Fuel Tank (Black): When refueling the Burner Fuel Tank, use No. 1 or No. 2 fuel oil/diesel or
kerosene. Do not use gasoline.
• Do not operate the unit if gasoline or diesel fuel is spilled. Wipe the pressure washer clean and move it
away from the spill. Avoid creating any ignition until the gasoline or diesel fuel has evaporated.
• When the battery is being activated, hydrogen and oxygen gases in the battery are extremely
explosive. Keep open sparks and flames away from the battery at all times, especially when charging.
• Be certain to disconnect the battery ground terminal before servicing. When disconnecting the cable
from the battery, start with the negative terminal. When connecting them, start with the positive cable.
• When charging the battery, remove the battery vent plugs.
• Use only a voltmeter or hydrometer to check a battery charge.
• DO NOT jump start the battery unless both batteries are of equal voltage and amperage.
IMPORTANT SAFETY WARNINGS
WARNING
Serious injury or death may occur from a fire caused by a muer spark.
Serious injury or death may occur if system safety’s are not properly maintained.
• A spark arrester must be added to the muer of this engine when using on land covered with any
flammable agricultural crop (hay and grain), and if they are used in or near brush or forested areas. The
arrester must be maintained in eective working order by the operator of the equipment. In the state
of California, the above is required by law. (Section 4442 and 4443 of the California Public Resources
Code.) Other states/provinces may have similar laws. Federal laws apply on Federal lands.
• This pressure washer has a Safety Relief Valve . This should never be altered, modified, removed or
made inoperative. If the device fails, replace immediately with genuine manufacturer replacement part.
WARNING
Serious injury or death may occur from inhaling engine/burner exhaust or dangerous
vapors. The engine exhaust from this product contains chemicals known to the State of
California to cause cancer, birth defects, or other reproductive harm.
• Never operate this pressure washer in an enclosed area. Always ensure there is adequate ventilation
(fresh outside air) for breathing and combustion. This will prevent the buildup of dangerous carbon
monoxide gases. Beware of poorly ventilated areas, or areas with exhaust fans which can cause poor
air exchange. This unit should only be used outdoors to ensure ventilation is never an issue.
• Follow all safety instructions provided with the materials you are spraying. Use of a respirator may be
required when working with some materials. Do not use this pressure washer to dispense hazardous
detergents.
WARNING
Serious injury or death could occur from high pressure spray penetrating the skin.
• Keep clear of nozzle and spray! Never put your hand, fingers or body directly over the spray nozzle.
• Do not direct discharge stream at self, other persons, or pets.
• This product is to be used only by trained operators.
• Always keep operating area clear of other people.
• Do not allow children to operate this unit or be in the vicinity while you operate it.
• Seek emergency medical care if spray seems to have penetrated the skin. Do not treat as a simple cut!
• High pressure hoses and fuel lines should be inspected daily for signs of wear. If evidence of failure
exists, promptly replace all suspect hoses and fuel lines to prevent the possibility of injury from the
high pressure spray. If a hose or fitting is leaking, do not place your hand on the leak.
• Never operate the gun with the trigger held in the open position. To prevent accidental discharge, the
trigger gun should be securely locked when not in use.
• Before removing the spray nozzle or servicing the unit, always shut the unit o and pull the trigger of
the gun to release trapped pressure (even after you shut o the unit, there is high pressure water left in
the pump, hose and gun until you release it by pulling the trigger the gun).
WARNING
Serious injury or death may occur from contact with electricity.
• Do not direct spray on or into electrical installations of any kind! This includes electrical outlets, light
bulbs, fuse boxes, transformers, and the unit itself.
• Do not allow metal components of the pressure washer to come in contact with live electrical
components.