Operator`s manual

ATB 46e – revised December 2001 3
Maintenance schedules
90 day or 150 hour maintenance
(trained service technician)
Components Service Required Recommended Lubricant or
Further Instructions
Daily maintenance Perform maintenance as per schedule
Preventive inspection mainte
-
nance checklist
Perform inspection, complete form Retain copy of checklist
Placards and decals inspection Inspect using drawing and parts listing
in section 1 (repair parts)
Replace any missing or unread
-
able decals/placards
Batteries Check specific gravity 1.260/1.275 at 80° F.
Charging system Check operation
Door hinges and latches Lubricate SAE 10W oil or spray lubricant
Rotation bearing Lubricate Conoco Super Sta #2
Above 32° Mobilgrease CM-P
Below 32° Mobilgrease CM-L
Rotation bearing teeth & pinion Lubricate Mobil Mobiltac 375NC
Tie rods Lubricate Conoco Super Sta #2
Above 32° Mobilgrease CM-P
Below 32° Mobilgrease CM-L
Gear hubs Check fluid level, fill if low Mobil Mobilube HD 80W-90
Platform lift capacity Check if platform can lift maximum load
Platform rotator Check smooth operation Repair or replace if not working
properly
Platform controller Check smooth operation and speeds
Platform lift/lower speeds Check smooth operation and speeds
Hydraulic return filter Check condition Replace if dirty
Slide pads Check condition Do not lubricate
Yearly or 500 hour maintenance
(trained service technician
Components Service Required Recommended Lubricant or
Further Instructions
90 day or 150 hour maintenance Perform maintenance per schedule
Hydraulic oil reservoir Clean and replace fluid Above 10° Mobil DTE-13M
Below 10° Mobil DTE-11M
Hydraulic return filter Replace After 1st. 50 hours, thereafter
at recommended interval
Hydraulic reservoir suction filter Clean and reinstall
Hydraulic pressures Check pressures
Gear hubs Replace fluid Mobil Mobilube HD 80W-90
Platform controller Check operation
Ground controls Check operation
Front wheel bearings Clean and repack Conoco Super Sta #2
Above 32° Mobilgrease CM-P
Below 32° Mobilgrease CM-L