Instructions / Assembly

18
TROUBLE SHOOTING GUIDE
SYMPTOM
Burner will not light
and burner tube is clean
Not enough gas flow from
propane tank
Open propane tank valve all
the way
CAUSE POSSIBLE SOLUTION
Low gas level in propane tank,
or tank is empty
Check gas level in propane tank,
re-fill or exchange tank
Damaged regulator hose
assembly
Contact 1-800-864-6194;
Model M5JET
Hissing or gurgling sounds
coming through gas train
from tank to burner
Damaged hose Perform soapy water test to check
for cracks in hose.
See page 11; Model M5JET
Gas leak Perform soapy water test to check
all connections - See page 11
Flame has gone out
Low gas level in propane tank,
or tank is empty
Check gas level in propane tank
Too much wind Check wind direction and set
cooker away from windy areas
Blockage in burner tube Clean and check burner tube for
spiders, insect nests and debris
Cooker lights but the flame
remains very small
Cooker will not light
Orifice Hole in Jet Tube is not
facing straight up
Using a wrench, turn brass cap
until orifice hole is facing up
Do not use this appliance if gas
leaks cannot be stopped and
corrected.
Orifice hole is blocked Using a wire, insert into orifice
hole to remove blockage debris
Repeat lighting instructions and be
certain to S-L-O-W
-L-Y open cylinder
valve one full turn, then S-L-O-W-L-Y
open regulator valve to light burner.
It may be necessary to disconnect, then
reconnect the regulator to the cylinder
in order to reset the gas flow system.
After doing this, make certain
regulator valve is turned
CLOCKWISE to OFF position.
NOTE: Replacement Parts can be purchased at www.thebayou.com or call 1-800-864-6194.
Model M5JET Regulator Hose Assembly
Rapid gas flow from propane
tank activates EXCESS FLOW
safety device because
Regulator Valve is not in OFF
position
ATTENTION: Always turn Propane Tank Valve and Regulator
Control Knob/Valve
to OFF position after every use! Propane Tanks,
and this Cooker, come equipped with a safety device that restricts the flow
of gas should the hose be cut or severed. While the safety device protects
the operator, it can sometimes impair lighting the cooker. To reduce trouble
lighting the cooker, always turn the regulator control knob/valve to the OFF
position after every use.
Turn Valve CLOCKWISE
to OFF position