You can rely on User Guide and Important Warranty Information Condensing Combination Boiler Please keep these instructions in a safe place. If you move house, please hand them over to the next occupier.
Contents Natural Gas Potterton Titanium 24 G.C.No 47-393-39 Potterton Titanium 28 G.C.No 47-393-40 Potterton Titanium 33 G.C.No 47-393-41 Potterton Titanium 40 G.C.No 47-393-42 Section Page 1.0 Quick Reference Guide 3 2.0 Troubleshooting 4 3.0 Repressurising System 6 4.0 Clearances 7 5.0 Care of the Boiler 8 6.0 Legislation 9 7.0 Setting the Timer 10 8.0 Emergency 11 9.
1.0 Quick Reference Guide 3 2 1 12 11 PM 10 bar 4 11 Reset System Pressure Gauge Reset 12 Domestic Hot Water Temperature Control 1 Reset Central Heating Temperature Control 2 Display 3 ON/OFF/Reset Selector Switch 5 0 9 4 0 AM 8 7 7 3 8 1 9 Reset 5 2 10 4 Integral Timer Reset OFF Position Central Heating & Hot Water Domestic Hot Water Reset The boiler will not operate. Both Heating & Hot Water will operate. Hot Water will operate.
Boiler not working 2.0 Troubleshooting START Make sure the gas supply is turned ON and check if other gas appliances are operating (e.g. fire, cooker). YES Is the ( ) or ( ) light on and the ( ) on ? YES Is the ON/OFF/Reset Select Switch in the ( ) position and the display lit ? Central Heating Indicator Domestic Hot Water Indicator NO If no gas, consult your supplier. NO Reset YES Display NO Check electricity to the boiler is switched on.
2.0 Troubleshooting Is the Integral Timer ON and calling for heat ? 2 1 3 12 YES Is the Room Thermostat (if fitted) set high enough ? YES 11 10 20 5 AM 8 7 7 8 PM 15 25 9 5 10 4 9 10 5 0 4 3 2 1 12 11 NO NO Turn Room Thermostat to maximum setting (typical example shown). Ensure timer is set for Central Heating ON (see Section 7.0 of these instructions - ‘Setting the Timer’) 15 20 25 5 10 CONTACT YOUR INSTALLER OR SERVICE ENGINEER.
3.0 Repressurising the System 3.1 1. The water pressure in the central heating system is indicated by the pressure gauge. 2 1 Fig. 1 3 2. With the system cold and the boiler not operating the pressure should be at least 0.5 bar. During operation the pressure should not exceed 2.5 bar, and will normally be between 1.0 and 2.0 (Fig. 1). 4 0 bar 2 Normal Pressure 1 Fig. 2 3 4 0 bar Requires Repressurising 2 1 Fig. 3 Central Heating System Pressure 3 3.
4.0 Clearances 450mm 5mm Min 5mm Min 200mm Min (300mm Min if using 80/125mm flueing system) 4.1 For your Safety 1. This appliance must have been installed in accordance with the manufacturer’s instructions and the regulations in force. 2. Any modification that may interfere with the normal operation of the appliance without express written permission from the manufacturer or his agent could invalidate the appliance warranty.
5.0 Care of the Boiler 5.1 Cleaning the Outer case The painted panels should be wiped with a damp cloth and then dried completely. DO NOT USE ABRASIVE CLEANING AGENTS. 5.2 Protection & Precaution 1. The boiler incorporates an integral frost protection feature that will operate in both modes. If the boiler temperature falls below 5° C, then the boiler will operate until the water temperature has been raised. 2.
6.0 Legislation 6.1 Installation, Commissioning, Service & Repair 1. This appliance must be install in accordance with the manufacturer’s instructions and the regulations in force. Read the instructions fully before installing or using the appliance. 2. In GB, this must be carried out by a competent person as stated in the Gas Safety (Installation & Use) Regulations. 3.
7.0 Setting the Timer 10 7.1 8 The Electro-Mechanical Timer allows the central heating system to be set every 15 minutes. Constant Using the three position switch the timer will allow either constant operation, timed operation or central heating off. 7 Timed Move the switch button by sliding to the desired position. AM Off Three position switch (Fig. 6) 5 0 Constant (Top position): The heating will be on constantly irrespective of the position of the tappets.
8.
Please complete the boxes below Serial Number 9.0 Warranty & Service Standard Warranty Term & Conditions 5 Years Free Warranty - register today To receive your 5 years free warranty please complete the registration card supplied with the boiler, or register it online at www.heateam.co.uk. heateam is the service division of Potterton boilers.
