Instruction Manual

10"
"
"
b) After"feeling"the"pressure"on"the"strip"of"paper"on"the"operator"side,"gently"pull"
on"the"strip"of"paper"on"the"nonHoperator"side"and"feel"the"amount"of"pressure"
the"fold"rolls"are"applyin g."
"
o If"pulling"on"this"strip "o f "p ap e r "fells "lik e"t h er e"is "n o t"e n o u g h "p r es su r e "an d "d oes"
not"cause"the"fold"rolls"to"start"rotating,"turn"the"gapset"knob"counterHclock"
wise"to"add"more"fold"roll"pressure."
"
o If"pulling"on"this"strip "o f "p ap e r "fells "lik e"t h er e"is "to o "much"pr e ss u re "and"cause "
the"strip"of"paper"to "tear"rota ting,"turn "the "gap set"kn ob "clock "wise"to"reduce"the"
amount"of"fold"roll"pressure."
"
c) Now"that"you"have"initially"cailbrated"the"fold"roll"pressures"on"the"op era tor"an d "
nonHoperator"sides,"you"must"go"back"and"check"the"pressures"on"each"strip"of"
paper"again"to"ensure"the"pressures"remained"the"same."You"may"hav e"to"
readjust"the"pre ssure "on "eac h"side "to"en su re"the "pro per"a m ou n t"of"fold "roll"
pressure"is"maintained."
"
>5.,26(/"9,:."%,02(0#(%4$(#093(.099(7.$--5.$(-$%%,26-@(,%(,-(/.,%,/"9(%0($2-5.$(%4" %(
%4$("105 2%(0 #(3." 6(0 2(:0 %4 (%4$(0 7$ ."%0 .("2 3(202K07$."%0.(-,3$-(,-(%4$(-"1$M(
(
d) Repeat"steps"3"&"4"by"adjust"the"proper"gapset"knobs"for:"
#2"fold"roll"to"main"fold"roll(strips"of"paper"in"between"the"#2"and"main"fold"rolls"
&"adjusting"the"#2"gapset"knobs),"then"
#3"fold"roll"to"#2"fold"roll(strips"of"paper"in"between"the"#3"and"#2"fold"rolls"&"
adjusting"the"#3"gapset"knobs),"then"
"
#4"fold"roll"to"#3"fold"roll(strips"of"paper"in"between"the"#4"and"#3"fold"rolls"&"
adjusting"the"#4"gapset"knobs),"then"
"
#5"fold"roll"to"#4"fold"roll(strips"of"paper"in"between"the"#5"and"#4"fold "rolls"&"
adjusting"the"#5"gapset"knobs."
"
5. Now"that"all"of"the"fold"roll"pressures"have"been"calibrated"properly,"while"holding"each"gapset"
knob"so"that"it"does"not"move(if"the"gapset"knob"turns,"the"fold"roll"pressures"will"change),"turn"
each"gapset"indicator"dial"so"that"each"dial"is"set"at"1."