® DIAMOND QUARTZ GRANITE User Manual REGENERATIVE RANGE
MODEL:- QUARTZ GRANITE DIAMOND SERIAL NUMBER:- B B PURCHASE DATE:- / DAY / MONTH YEAR DEALER STAMP IMPORTANT PLEASE READ THIS MANUAL FULLY PRIOR TO ASSEMBLY AND USE For your safety and to ensure a long and trouble free life of your Batribike bicycle, check the operation of brakes, lights, bell and gears, and check tyre pressures are correct. Also check all fasteners, including quick release mechanisms, before every ride.
Thank you for purchasing a BATRIBIKE Electric Bicycle from Fallowgate Limited. With care and correct usage your bicycle will give many years of service. Important PLEASE CHARGE THE BATTERY BEFORE FIRST USING THE BICYCLE Even though the battery indicator will show charge this cannot be relied upon until the battery has had the initial full charge. PACKAGE CONTENTS 1 ELECTRIC BICYCLE 1 BATTERY 1 BATTERY CHARGER with UK Mains Lead 1 MANUAL Contents Battery Charging ..........................................
Charging the Battery The battery can be charged on or off the bike. To remove the battery, unplug the battery from the bike, (Blue Plug), then unlock with the one of the two keys provided, hold down the plastic clamping tab and slide out the battery from the rear of the carrier. Insertion is the reverse of the above procedure. WARNING Ensure that charging socket cover is CLOSED before removing or inserting battery. Failure to do so will result in breakage of the cover.
Plug the charger into the mains socket and switch on at the wall outlet. The lights on the charger will illuminate after a few seconds. Power Charger Power Charger The RED light indicates that mains power is applied. The other light will show ORANGE whilst charging is taking place. This may take up to six hours for a flat battery. When the battery is charged the ORANGE light will change to GREEN. Once charged, switch off at the wall outlet and unplug.
Usage Your BATRIBIKE Electric Bicycle can be used as a normal pedal cycle by simply not switching on the battery. ON/OFF MODE To use under electric power plug in the battery with the blue plug located on the end of the battery beneath the rear of the seat. Then press and hold the ON/OFF, MODE switch on the handlebar display. The Power Indicator on the display will light to show the remaining power in the battery. If the unit shows 2 LEDs or less it is recommended that you charge the battery.
If the MODE switch is not pressed within a couple of seconds the LED display will revert to showing the battery power remaining. (Steady LEDs). RANGE: Battery level 3 shown (Estimated mileage will vary with terrain but at full power (Level 4), a 75kg rider should be able to travel up to 40 miles over level ground with a fully charged battery). There is also a twist throttle provided on the right handlebar grip.
Gears The DIAMOND, GRANITE & QUARTZ are provided with 7 speed Shimano gears. To change gear you use the right handlebar mounted selector. Gear number 1 is low for hills and rough terrain and gear 7 is high for normal road use. To increase the gear simply press the + button with your right thumb. To decrease the gear push the black lever away from you with your thumb. You must be pedalling as you change gears. Lights Lights are provided on your BATRIBIKE bicycle.
The rear light requires 2 AA batteries. You will require a small Philips screwdriver to take off the red lens for battery replacement. It is switched on by the small switch on the underside of the unit. Braking To stop, release the throttle and pull the brake levers. Regenerative Braking A feature of the Regenerative Range is the addition of REGENERATIVE BRAKING. This allows the rider to use the motor “like a dynamo” to effect efficient braking without using the normal brakes.
Centre Stand (where fitted) To put the bicycle on its stand:1) 2) While holding the bicycle upright, place your foot behind the stand. Pull the bicycle backwards until the stand is in place. Make sure bicycle is on solid ground. Side Stand (where fitted) To put the bicycle on its stand:1) 2) While holding the bicycle upright, push the stand to its full extent. Lean the bicycle over onto the stand. Make sure bicycle is on solid ground.
Folding the Bicycle (Quartz only) Fold pedals by squeezing in as per photo, and turning through 90 degrees. Turn the pedals to the position shown in photograph so they are not trapped when folding the frame. Release centre frame lock as follows:- Flip catch Turn to side Lift up lever to release pin from frame Fold frame front to back. Unscrew handlebar folding lock fully and fold down handlebars. Reverse procedure to return bicycle to riding position.
Service & Spares Remember to check all nuts and screws before and after the first ride. This will need to be repeated after a week or so of riding and periodically to maintain safe use of your BATRIBIKE bicycle. Cables may also stretch a little during the first few uses. Brakes and gears may need to be adjusted after the first few days to ensure correct operation. Refer to your local cycle shop if you are not familiar with this operation. Your BATRIBIKE bicycle uses standard cycle parts wherever possible.
Removing the Rear Wheel If you need to remove the rear wheel, for example, to replace the rear tyre, then the motor can be unplugged to aid disassembly. The plug is located in the small plastic casing as shown, (Right). Remember to ensure that the cable is suitably secured to the bicycle frame upon re-assembly. Charging Fuse If the battery will not operate or charge correctly, firstly check the battery fuse (rated 30A) located on the side of the battery beneath the screw cover.
Please consider the environment before disposing of any part of your Batribike Electric Bicycle. The Battery Pack contains Lithium and Special Consideration should be given to its safe disposal. Your Local Authority should have the necessary facilities in place. Never dispose of batteries in a fire or subject them to puncture or crushing.
Warranty Please retain your receipt as this is your proof of purchase and entitlement to Warranty. The Frame of your new BATRIBIKE Granite, Diamond & Quartz is guaranteed for 3 years from date of purchase. The Motor and Electronics are guaranteed for 2 years from date of purchase. Other main cycle parts have a warranty of 1 year. The battery is covered for 1 year. Please take note of the Battery Care information contained in this manual to ensure your battery life is maximised.
