Pro DASH 11 Pro DASH 16 Pro Pro Spec Models Owner Manual
Pro MODEL:DASH 11 (10.4 Ah) DASH 16 (15.6Ah) Dash Pro Orange BICYCLE SERIAL NUMBER:- D B B BATTERY SERIAL NUMBER:- Dash Pro Blue Register your BATRIBIKE Warranty online at batribike.com/warrantyregistration PURCHASE DATE:- FW / DATATAG ID:- DAY / 20 MONTH YEAR Register your DATATAG online at datatag.co.uk/cycle/validate.
Thank you for purchasing a BATRIBIKE Electric Bicycle With care and correct usage your bicycle will give many years of service. Important PLEASE CHARGE THE BATTERY BEFORE FIRST USING THE BICYCLE Even though the battery indicator will show charge this cannot be relied upon until the battery has had the initial full charge.
Pro 3 7 5 5 4 6 1 9 8 2 PARTS IDENTIFICATION We continually strive to ensure that we provide you with the best possible products, therefore SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 LCD (Display) Handlebar Fold Lever Thumb Throttle Front LED Light 19 20 Rear Brake Lever 21 Front Brake Lever 22 Motor Cutout Switch 23 Gear Selector Levers 24 Bell 25 Gear Indicator 26 Height Adjust Lever 27 Charging Socket 28 Battery Key Switch/Lock 29 Bat
15 16 17 9 18 19 20 22 21 23 24 25 26 27 28 29 30 31 32 UNDERSIDE OF FRAME BENEATH CRANK 33 10 34 11 35 33 36 Pro
Pro BATTERY CARE & CHARGING Your Batribike Electric Bicycle uses a Lithium battery for it's power and the following points will directly affect battery life and performance. Storage Batteries do not like to be stored in very hot or very cold conditions or to be subject to conditions of high moisture. They also do not like to be left in a fully discharged state. If Lithium batteries are left flat for an extended period they may no longer be functional.
Using the Charger Two types of battery charger are used by BATRIBIKE. (Only one will be supplied). Both have a charge light which will display RED when charging and change to GREEN when the battery is charged. The alternative type charger also has a second light which shows RED when mains power is applied. • Ensure the battery is switched off. • Plug the charging lead into the battery. The charging lead plugs into the charging socket located beneath the slide cover on the side of the battery casing.
Pro Usage Your BATRIBIKE Electric Bicycle can be used as a normal pedal cycle by simply not switching on the battery.
ELECTRIC BICYCLE FUNCTIONS Switching On To use under electric power, switch on at the key switch on the side of the battery, then press the POWER button on the handlebar LCD display. Control Buttons By means of the three buttons, POWER, UP and DOWN, on the handlebar mounted display unit, the various functions of the power controller and Cycle Computer can be utilised. See the following sections for details.
Pro Battery Meter The LCD shows the charge remaining in the battery in the lower right of the display. The indicators will gradually go out as the battery power is used up. Refer to the table below for details. BATTERY METER DISPLAYS THE CHARGE REMAINING IN THE BATTERY SYMBOL DISPLAYED CHARGE REMAINING FLASHING 70 - 100% 50 - 70% 30 - 50% 15 - 30% 0 - 15% BATTERY IS EXHAUSTED AND SHOULD BE RECHARGED AS SOON AS POSSIBLE Display Backlighting - Night Mode The LCD has a backlight for night time use.
Speed Display The centre large digits will normally display the current speed of the bicycle. For the UK market this is set to show miles per hour (MPH). The display is accurate to about 10% when the wheel size is correctly calibrated and the tyre inflated as per the manufacturers recommendations. The display can be changed to show kilometres per hour (KMH) by pressing and holding the UP button for 4 seconds. To return to MPH repeat this process.
Pro Pedal Assistance There are 5 levels of pedal assistance available from the motor. Using the UP and DOWN buttons you can select from LOW (1 bar), to HIGH (5 bars). The motor will then be activated upon pedalling. There is a rotation sensor located near the crank which senses when the pedals are being used. PEDAL ASSISTANCE FROM THE MOTOR LEVEL PERFORMANCE 28 miles 15.
Weather and terrain will affect the performance. In hilly areas, or when the bike is heavily loaded, there will be a significant increase in the power used from the battery and hence the range will decrease accordingly. A lightly loaded bike will achieve higher performance levels. (These results were obtained by test riders in optimal conditions - 75kg rider, level ground, no wind).
Pro No Assistance - Normal Pedal Bicycle If the assistance level is set to ZERO (one bar flashing), then the motor will not be turned on. Your BATRIBIKE will now act and feel like a normal bicycle. This is useful when you are feeling fit at the start of a journey or using your bike for exercise purposes. Power is still only a button press away.
BS EN15194 Compliance The BATRIBIKE Pro range is compliant with BS EN15194. For the British market, the addition of a throttle control has rendered this not compliant in some countries. ● You are recommended to seek advice from the relevant authorities in the country you are visiting before travelling.
Pro CYCLE COMPUTER The Pro models have useful Cycle Computer functions built in. There is a built in sensor and pickup located in the rear hub which activates the speed and distance readings. Normal Display When first turned on the display shows the Trip Distance (TRIP) in the bottom left. The Speed is always shown in the upper left section of the display. The assistance level (ASSIST) is set to the lowest level, (1 bar), and the readout is set to display speed in MPH and Trip/Odometer distances in MILES.
Resetting the Trip To reset the TRIP distance at the start of a journey, simply press and hold the UP and DOWN buttons simultaneously, and hold for 6 seconds. TOGETHER The Odometer distance displays the total distance travelled by the bicycle since leaving the factory and cannot be reset.
Pro STANDARD BICYCLE FUNCTIONS Gears The DASH Pro is provided with 6 speed Shimano Index gears. To change gear you use the right handlebar mounted selectors. Gear number 1 is low for hills and rough terrain and gear 7 is high for normal road use. An indicator window shows the selected gear. To increase the gear simply press the + button with your right thumb. To decrease the gear push the black lever away from you with your thumb. You must be pedalling forwards as you change gears.
Braking To stop, release the throttle and pull the brake levers. The brake icon will be shown on the handlebar mounted display. Bell A bell is incorporated into the left hand (rear) brake lever. It is designed to be operated with the left index finger. BELL lever Side Stand To put the bicycle on its stand:1) While holding the bicycle upright, push the stand downwards to its full extent. 2) Lean the bicycle over onto the stand. Do not sit on the bicycle whilst the stand is down.
Pro Quick Release fittings for Seat Height Adjustment With the locking lever in the loose position, tighten the nut until finger tight. The final tightening is done by moving the lever to the locked position. To undo move the lever to the loose position to enable height adjustment. Loose Locked Folding the Bicycle 1. FOLD PEDALS Fold pedals by squeezing in as per photo, and turning through 90 degrees. Turn the pedals to a suitable position so they are not trapped when folding the frame. 2.
3. FOLD HANDLEBARS Loosen the clamp and fold in the direction shown. Take care not to trap the wires and cables. Locked Rotate black locking collar Fold down locking lever Allow handlebars to fold down Reverse procedure to return bicycle to riding position. Magnetic Clip A magnetic clip system is provided on the front fork and lower rear frame to hold the bicycle in position when folded.
Pro Datatag is now fitted as standard to your BATRIBIKE Electric Bicycle We believe that there are many advantages to having the system fitted. Our customers often worry about the possibility of theft and Datatag has a proven track record as a deterrent. There are other benefits too, including cheaper insurance as major insurers offer reduced premiums for Datatagged bikes.
A quick scan of the QR code displays the Make & Model of the bike but does not display any personal information. Police can obtain further information via their linked PNC systems. Datadots® A superior microdot identification system developed for ease of use. The Datadots® can be applied to any surface, and we have chosen strategic places on major components, thus making it virtually impossible for the criminals to locate and remove them all.
Pro MAINTAINANCE SCHEDULE Maintaining your bicycle ensures you’ll get the most out of every ride and out of the entire life of your BATRIBIKE electric bike. How much of your bike’s maintenance you can do yourself will depend on your knowledge, skill, experience and whether you have the necessary tools for the job. Beyond this manual, it is good to consult your BATRIBIKE dealer for advice if you are at all unsure about any of the procedures described.
After 3,000 miles (5,000 km) (or YEARLY) ● Hub motor and general inspection We recommend you arrange to have a thorough inspection of your bicycle by a BATRIBIKE dealer. This includes opening up the hub motor to inspect and lubricate the gears. Tyre Pressures The tyres should be pumped up to within the range stated on the sidewall. This should be regularly checked as running with the correct pressures will ensure maximum range from the battery.
Pro SPECIAL BATTERY FEATURES Battery Meter The battery has a useful meter located on the top surface. This is handy when the battery is not fitted to the bicycle as it gives an indication of resting charge level. To operate the meter, press and hold the power button and the LEDs will light to show an approximation of the remaining charge in the battery. The Battery Switch, (key located on the side of the battery), must be switched to the ON position to operate the meter.
Battery Fuse If the battery will not operate or charge correctly, firstly switch off the battery and check the battery fuse (rated 30A) located on the side of the battery beneath the screw cover. Use a small crosshead (+) screwdriver to remove the cover. Battery Fuse 30A Glass Type (Automotive) Please consider the environment before disposing of any part of your Batribike Electric Bicycle. The Battery Pack contains Lithium and Special Consideration should be given to its safe disposal.
Pro WARRANTY CONDITIONS The following warranty conditions are in addition to your legal rights. Requirements for Warranty As the makers, we guarantee against possible material or construction defects. Provided the following conditions are satisfied : ● ● ● ● ● ● Please retain your receipt as this is your proof of purchase and entitlement to Warranty. The guarantee starts on the date of purchase. Warranty is non transferable and applies only to the original owner.
Battery Warranty Terms & Conditions 1. 2. 3. 4. Warranty is void if Warranty Label is removed or tampered with. ** Owner must ensure that battery is not left in a fully discharged state. ** Battery must only be charged with the charger supplied. ** Battery must be put on charge and charged fully at least once per calendar month, even if the bike is not used. ** 5. Warranty is not transferrable. 6. In the unlikely event of a battery failure, the battery must be returned to Batribike for testing.
Lithium (Samsung) Gears Saddle Height up to 24 miles (Throttle) at 15 mph 28 miles (level 5) at 15 mph 40 miles (level 3) at 12 to 15 mph 60 miles (level 2) at 9 to 12 mph 6 speed Shimano Index System (SiS) Powerful Vee Brakes Front and Rear 20" with puncture resist tyres Suspension Range (motor only) Range (pedal assist) Sturdy side stand Aluminium Alloy rack Stand Rear Rack Cycle only or Multi-Mode Power Pedal assist (5 power levels) Switchable throttle ** Power System (All distances quoted o
Lithium (Samsung) Gears Saddle Height up to 30 miles (Throttle) at 15 mph 35 miles (level 5) at 15 mph 50 miles (level 3) at 12 to 15 mph 80 miles (level 2) at 9 to 12 mph 6 speed Shimano Index System (SiS) Powerful Vee Brakes Front and Rear 20" with puncture resist tyres Suspension Range (motor only) Range (pedal assist) Sturdy side stand Aluminium Alloy rack Stand Rear Rack Cycle only or Multi-Mode Power Pedal assist (5 power levels) Switchable throttle ** Power System (All distances quoted on fl
www.batribike.com BATRIBIKE Electric Bicycles are exclusive to:Fallowgate Limited Kellaway House Marton Road Sturton-by-Stow Lincoln LN1 2AH Phone: 01427 787774 E-mail: support@batribike.
