Owner’s Manual
Owner’s Details Model _________________________________________________________________ Vehicle Identification Number V.I.N.
The essential accessory for your new caravan! Away from the rush of every day life and the busy tourist centres, you’ll find 200 Club Sites in areas of outstanding natural beauty across the country. Some located in National Parks, on land owned by the National Trust or even in the grounds of stately homes. And around 2,500 small, informal sites or CLs that are ideal for a restful break. Wherever you stay, you’ll receive a friendly welcome.
Contents Owner’s Details ............................................................ 1 1.1 INTRODUCTION ........................................... 1-1 1.2 WARRANTY .................................................. 1-2 1.3 WARRANTY COVER .................................... 1-2 1.3.1 6 Year Body Shell Integrity Guarantee .......... 1-2 1.3.2 3 Year Manufacturers Warranty ..................... 1-2 1.3.3 Terms and Conditions .................................... 1-3 1.
Contents 4.9.3 4.9.4 4.9.5 4.9.6 4.10 Energy Selection ......................................... 4-18 Temperature setting cooling compartment .. 4-20 Exchange of the igniter’s battery ................. 4-20 Storing food ................................................. 4-20 DOMETIC REFRIGERATOR MODEL RM 8550L (Pageant & Senator) ............................... 4-21 4.10.1 Cleaning ...................................................... 4-21 4.10.2 Operating modes and use of the refrigerator ................
Contents 4.24.4 4.25 4.25.1 4.25.2 4.25.3 4.25.4 4.25.5 4.25.6 4.25.7 4.25.8 4.25.9 5.1 5.1.1 5.1.2 5.1.3 5.1.3 5.1.4 5.1.5 5.1.6 5.1.7 5.1.8 5.1.9 5.1.10 5.1.11 5.1.12 5.1.13 5.1.14 5.2 5.2.1 5.2.2 5.2.3 5.2.4 5.2.5 5.2.6 5.2.7 5.2.8 5.3 5.3.1 5.3.2 5.3.3 5.3.4 5.4 5.4.1 5.4.2 5.4.3 5.4.4 5.4.5 5.4.6 5.4.7 5.4.8 5.5 5.5.1 5.5.2 5.5.3 Fault Finding ................................................ 4-58 DAEWOO MICROWAVE OVEN .................
Congratulations on the purchase of a fine touring caravan! To ensure you enjoy your caravanning to the full, may we commend the following books from Haynes Publishing? They have been written by John Wickersham whose caravanning articles appear every month in several magazines, including the Members’ Magazine of The Caravan Club. The Caravan Handbook.
Introduction 1.1 1 INTRODUCTION Bailey of Bristol welcome you to the ranks of Bailey Owners. This Handbook has been designed to enable you to derive the maximum benefits and enjoyment from your caravan, its information will be of benefit to both experienced and new caravanners alike. Several sections are ‘common to all models’ in the range, the specific sections relative to a particular model are clearly indicated.
1 Introduction 1.2 WARRANTY Any claims under warranty must be made through the Retailer from whom the caravan was purchased. It is with the retailer that the purchaser’s Contract of Sale exists and consequently Bailey Caravans cannot enter into any discussions with the purchaser. Bailey retailers sell our products of their own choice and not as agents. They are, therefore, unable to bind Bailey Caravans Ltd or make any representation or undertaking whatsoever on behalf of Bailey Caravans Ltd.
Introduction 1 Fridge; door seal, condenser, gas control valve, gas igniter, flame failure device, 12 and 230v heater elements, gas thermostat, 230v thermostat, 230v temperature control switch. Water System; water heater (gas or electric), fresh water tank, water pump, water gauges, taps and shower head. Auxiliary Electrics; mains hook-up input connector, ELCB, battery charger and distributor unit, interior lighting units (excluding bulbs).
1 1.4 Introduction CARAVAN REGISTRATION AND IDENTIFICATION SCHEME (C.R.I.S) This caravan has been security marked and recorded under the Caravan Registration and Identification Scheme that is organised by the Caravan Industry. Shortly after purchasing this caravan you should receive your Touring Caravan Registration Document. It will be sent by post to your home address. Your Touring Caravan Registration Document will include a 17 character V.I.N.
Introduction 1.5 1 SAFETY This handbook contains the information that you will require for safe enjoyment of your tourer. All of the information contained herein is important. However to draw your attention to specific items we have prefixed them with the following symbols to indicate a warning, caution or note respectively: Warnings are items that if ignored can cause the user(s) physical harm. Cautions are items that if ignored can result in the caravan becoming damaged.
1 1-6 Introduction
Caravan & Tow Vehicle 2.1 2 INTRODUCTION Choosing the right car and caravan combination for safe and stable towing is both an art and a science. It may seem complicated to the newcomer, but a few minutes spent understanding the basic principles, common terms and definitions in use will be worthwhile in ensuring your enjoyment of our product. 2.2 CARAVAN AND TOWING VEHICLE TERMS Maximum technically permissible laden mass: As stated by the vehicle manufacturer.
2 2.2.1 Caravan & Tow Vehicle Measurement of nose weight Nose weight may be measured using a proprietary brand of nose weight indicator. Such equipment is obtainable from your Bailey Dealer. Another simple method is to use bathroom scales and a suitable piece of strong timber as a platform to rest the tow hitch on. The timber can be placed vertically between the caravan tow hitch and the bathroom scales.
Caravan & Tow Vehicle 2 The greater the towing vehicle’s tail overhang (the distance between the rear axle and the tow ball) the greater the effect the noseweight will have on the towing vehicle’s rear suspension. After trying out the caravan it may be found that stiffening of the rear suspension is necessary - but note that this may give the towing vehicle a firmer ride when not towing. There are a number of suspension aids available and advice should be sought on which to use and how to fit.
2 Caravan & Tow Vehicle Where no designated attachment point has been provided on the towbar: Fig b Fig c Fixed ball - Loop the cable around the neck of the towball. If you fit the cable like this, use a single loop only. See Figs. b and c. Detachable ball - You must seek guidance on procedure from the towbar manufacturer or supplier.
Caravan & Tow Vehicle 2 ▲ Always load the caravan in such a way that maximises towing safety. Incorrect caravan loading and/or overloading of the towing vehicles rear suspension will also result in poor towing stability. The weight should be distributed so that each side of the caravan carries, approximately, the same load. ▲ Please take care that you have allowed for the weight of all items you intend to load into the caravan. 2.2.
2 Caravan & Tow Vehicle 5. All lockers and cupboard doors are closed and secured 6. All bunks are secure 7. All rooflights, extractor fans and sunroofs are closed and secured 8. Tables are securely stored in their transit positions 9. Fridge is on 12v operation and door lock is set (if required) 10. All windows are fully closed and latched. Never tow with windows on night setting. Leave all curtains and blinds open to aid rear visibility 11.
Caravan & Tow Vehicle 2 The final positioning should be carried out by manoeuvring the caravan by hand. Carefully release the caravan handbrake. Manoeuvre the caravan by hand to position the caravan’s tow hitch directly over the car’s tow ball. ▲ Always manoeuvre the caravan by pushing /pulling on the grab handles only. Not the body panels. When the caravan is in the correct position fully apply the handbrake. Raise the handle on the caravan tow hitch until it clicks and remains at an angle.
2 Caravan & Tow Vehicle Pick up any levelling pads or levelling boards. Check round the caravan for anything left behind. Fully release the caravan’s handbrake. Carry out a second check that the hitch is secure and the secondary braking cable is connected. Adjust all of the car’s driving mirrors from driving seat to ensure good rear wards visibility. 2.3 TOWING 2.3.
Caravan & Tow Vehicle 2 Reduce speed in high winds, cross winds, downhill or in poor visibility. High sided vehicles such as lorries or coaches can cause air buffeting, so extra care must be taken when passing or being passed. Give as much space as is possible between your caravan and the high sided vehicle. 2.3.6 Mirrors The Law requires the driver of the towing vehicle to have an adequate view to the rear.
2 2.3.9 Caravan & Tow Vehicle Stabilisers A stabiliser should never be used to try to improve a caravan/towing vehicle combination that has poor stability as instability may appear at higher speed. However, a good stabiliser can make an acceptable caravan/towing vehicle combination more comfortable and easier to handle. ▲ Holes should not be drilled in either the coupling head or ‘A’ Frame members without prior consultation with the chassis manufacturers.
Caravan & Tow Vehicle 2 The cleaning of tyres should only be carried out using soap and water. Petrol, diesel, paraffin and other solvents are not suitable. If the caravan is not used for long periods of time (winter months) it is recommended that the wheels/ tyres are removed and stored at normal inflation pressure in a cool, dry place protected from direct sunlight, sources of heat, ozone concentrations and fuel/oil contamination. They can be covered with a natural material (e.g.
2 Caravan & Tow Vehicle The condition of wheels should be checked regularly particularly for distortion of flanges and the wheel dish. Wheels damaged or distorted, or having the wheel bolt seating cracked or deformed must not be repaired. If a wheel or tyre has to be changed it should be of the same type of construction and size as originally fitted. ▲ Only use a spare wheel and tyre recommended by Bailey Caravans, which should be of the same specification as those fitted to the caravan.
Caravan & Tow Vehicle 2 iii. Lower the corner steadies as a safety measure to stabilise the caravan. Chock the un-punctured wheel on the opposite side of the caravan to prevent any movement. iv. Slacken off the wheel bolts by no more than one quarter of a turn on the wheel that requires changing. Do not fully undo them. v. Place the jack plate under the axle tube as near as possible to the main longitudinal member.
2 Caravan & Tow Vehicle 2.3.18 Levelling the caravan Levelling must be carried out in both directions in order for the refrigerator and other equipment to function correctly. The positioning of the jockey wheel can be used to help level the caravan. Lower the corner steadies until they are in firm contact with the ground. ▲ Under no circumstances should the corner steadies be used as a jack as they are only a means of stabilising the caravan.
Caravan Service Systems 3.1 THE WATER SYSTEM 3.1.1 Water Supply 3 All models are supplied with a 12 volt submersible pump, controlled by a pressure switch. The water inlet is located in the off-side exterior wall, protected by a lift up lid. 3.1.2 The Submersible Pump (Discovery & Ranger) Operation Ultraflow Compact ● Raise the lid, clean both the water socket and the plug of the pump assembly. ● Plug the pump connector into the socket.
3 Caravan Service Systems 3.1.3 Whale Smartflo On Board Pump (Pageant & Senator) SENATOR CONFIGURATION PUMP Operation Valves: Both the manual valves included in this system must be positioned appropriately (fig 1-3) when switching between the three functions of the water system; using an external water supply, filling the onboard tank and using the onboard tank. 3.1.4 Priming the System using the External Water Container (Pageant & Senator) 1. Position the valves as shown in fig.
Caravan Service Systems 9. The system is now ready for use. Hose can be inserted into plug groove (fig. 6) to keep filter off the ground while refilling water container. Keep socket lid shut at all times when plug is removed. WALL SOCKET 10. When the caravan is left unattended or water supply has been allowed to empty to prevent the pump running continuously, turn off at isolating switch. 11.
3 3.1.5 Caravan Service Systems Troubleshooting (Pageant & Senator) FAULT CAUSE SOLUTION Pump doesn’t run No power to pump Check power supply Attach leads/clean corrections Check tap microswitch if present. Fuse has blown Replace fuse do not exceed recommended fuse size. Blockage in pipework Check pipework for kinks. No water getting to pump Check water tank is not empty. Check filter is not blocked.
Caravan Service Systems 3.1.6 3 Routine Maintenance ● Ensure the hose adapter ‘O’ ring and the socket in the housing are kept free from dirt. ● Use only silicone or water based lubricant to inlet nipple ‘O’ rings on socket for lubrication. ● Drain system thoroughly during the winter months, (see separate winterisation instructions). ● Service inlet socket annually, (use Whale’s AK8834 service kit containing all serviceable parts).
3 Caravan Service Systems 3.1.11 Aquasource Direct Mains Water Connection (This is not included as standard equipment, but is available from your nearest Bailey retailer). ● The Aquasource fits simply and securely to your Whale socket system. ● Comes with 7.5m of foodgrade layflat hose, which is compact for storage. (A further 7.5m extension hose is available as an optional extra to extend the hose).
Caravan Service Systems 3 3.1.15 Waste (Grey) Water System The waste water (often referred to as ‘grey’ water) from the caravan’s sinks and shower tray are routed to two outlets just behind the offside wheel. When setting up your caravan short pieces of waste pipe hose should be fitted to the wastewater outlets to direct the water into a suitable container. These are both available from your caravan retailer.
3 3.2.2 Caravan Service Systems Types of gas ● Butane Butane is supplied in the UK in Green or Blue bottles. Continental bottles usually have a male left hand thread similar to but not identical with UK Butane. Butane is suitable for use at temperatures down to 2°C but will not work below that temperature. ● Propane Propane is supplied in red, or partly red bottles that have a female left hand threaded connector. Scandinavian countries use the same connector.
Caravan Service Systems 3 Your caravan is fitted with a regulator as standard equipment. This is located in the caravan gas box mounted on the front bulkhead of the caravan between the gas bottles. The gas regulator has a working pressure of 30mbar and is suitable for both propane and butane liquefied petroleum gas. There are dedicated hoses available for different types of gas/bottle. They are also available for camping gas and other mainland Europe LPG Suppliers.
3 Caravan Service Systems Extinguish naked lights including cigarettes and pipes. Do not operate electrical switches. Open all doors and windows to disperse any gas escape. Butane/Propane gas is heavier than air, any escaping gas will therefore collect at a low level. The strong unpleasant smell of gas will enable the general area of the leak to be detected. Check that the gas is not escaping from an unlit appliance.
Caravan Service Systems 3.3 3 THE ELECTRICAL SYSTEM – 230 VOLT As in the home, care must be exercised when handling mains electricity. Your attention is drawn to the following notice as laid down by the Institute of Electrical Engineers. Instructions for electricity supply - low voltage (230 v) 3.3.1 On arrival at caravan site ▲ Before connecting the caravan installation to the main supply: ▲ Check that the mains supply is suitable for your installation and appliances, i.e. whether it is a.c. or d.c.
3 3.3.2 Caravan Service Systems On leaving caravan site ● first switch off the site supply. ● switch off the caravan RCD unit. ● then disconnect the pitch lead. In case of difficulty consult an approved electrical installation contractor (who may be the local electricity board). It is dangerous to attempt modifications and additions yourself. ▲ Lampholder-plugs (bayonet-cap adapters) should not in any circumstances be used. ● replace the cover of the socket outlet at the site supply point.
Caravan Service Systems 3 A means of checking the polarity of the mains supply when overseas is useful. There are available several proprietary makes of equipment for the purpose (e.g. Martindale tester unit). If it can be achieved, it is preferable to connect live to live, and neutral to neutral to maintain full electrical protection. Check all caravan equipment is set-up to accept the site supply before actually switching on. 3.3.5 Mains unit The mains unit replaces the conventional fusebox.
3 Caravan Service Systems 230V Mains equipment typical consumption figures: Fridge .............................................. 0.5 amps Colour TV ....................... 2.5 amps Charger ........................................... 1.0 amps Microwave ....................... 10 amps Water heater ................................. 3.75 amps Air conditioning .................. 4 amps Blown/convection air heating .......... 8.7 amps 3.
Caravan Service Systems 3.4.1 3 12-volt Control Panel The system is fitted with an automatic relay to select the power source. When the car is connected via lead the car power will be used. When the car is not connected the battery and or the power supply will be used to power the caravan. The control panel is fitted with a master 12-volt switch; this enables you to isolate the 12-volt supply in the caravan.
3 Caravan Service Systems ▲ Switch off all appliances before disconnecting battery. ▲ Negative connections should always be disconnected first and reconnected last. ▲ Car type battery chargers are not suitable for charging a leisure battery and may damage it. When storing the caravan for long periods of time, we recommend that the 12 volt leisure battery is disconnected and removed, except in the case of Senator models - please see 4.23.3 Tracker alarm winter storage.
Caravan Equipment 4.1 4 THE TRUMA ULTRASTORE WATER HEATER Operating Instructions 4.1.1 Filling the Truma Ultrastore with water ● Check that the safety/drain valve in the cold water intake is closed. The yellow lever should be in the horizontal position, position (e). ● Open the hot tap in bathroom or kitchen with pre-selecting mixing taps or single lever fittings set to hot. ● Switch on power for water pump (main switch or pump switch).
4 4.1.2 Caravan Equipment Gas operating instructions ▲ Never operate the water heater without water in it! ● Remove exterior cowl cover. ● Open gas cylinder and open quick-acting valve in the gas supply line. ● Select required water temperature at rotary knob (a) infinitely variable from approx. 30o to 70o by rotating the inner ring (b). ● Switch on water heater by rotating the outer ring on the control panel to the position.
Caravan Equipment 4 4.1.4 Electrical operating instructions (230v) Ensure that the water heater is full then switch the isolation switch on. (Usually mounted on the bunk face adjacent to the gas control switch.) ▲ The water temperature cannot be selected, temperature is automatically limited to 70oC. For a faster heating up the appliance can be simultaneously operated with gas and electrical power. 4.1.5 Draining the water heater f ● Turn off the power supply to the water heater.
4 4.1.7 Caravan Equipment Important Operating Notes: ● If the cowl is positioned close to an opening hatch (window), keep this closed during operation . See warning plate. Always mount the cowl cover if the heater is not being used. Nonobservation of this point can lead to the function of the appliance being impaired through water, dirt or insects. ● Always remove the cowl cover prior to operating the water heater on gas. ● Only use original Truma-Ultrastore parts.
Caravan Equipment 4.1.9 4 Technical Data Water contents: .................................... 10 litres Gas and electrical operation ... approx. 25 mins Water pressure: ................... up to max. 2.8 bar Power consumption .................................... 12V Type of gas: .... Liquid Gas (propane or butane) Ignition: ................................................... 0.17 A Operating Pressure: .............................. 30mbar (or 28mbar butane, 37mbar propane) Heating Up: ............
4 Caravan Equipment 4.2 THE TRUMA S 3002 EL SPACE HEATER 4.2.1 Gas Operation Switching on ● Turn on gas cylinder. b ● For space heaters fitted with manual piezo ignition (Discovery and Ranger) turn control knob to thermostat setting 1-10 and press it down as far as the stop. At the same time keep operating the piezo ignitor rapidly until the flame ignites.
Caravan Equipment 4 ● Any alteration to the appliance (including exhaust duct and cowl) or the use of spare parts and accessories which are important to the function of the heater and which are not original Truma parts, as well as the non-observance of the installation and operating instructions, will lead to the cancelling of the guarantee and exclusion of liability claims.
4 Caravan Equipment ● Do not operate appliance when refuelling the vehicle and when in the garage. ● Always connect the pressure regulator to the gas cylinder with great care. Inspect the regulator connection hoses regularly for signs of weakness. Caravanning gas cylinders must always be upright. 4.2.5 Technical data Type of Gas : ...... Liquid gas (propane/butane) Rated thermal output : ......................... 3400 W 4.2.6 Gas Consumption : ........................ 30-280 g/h Product Ident. No : .
Caravan Equipment 4 ▲ Any alteration to the appliance (including exhaust duct and cowl) or the use of spare parts and accessories which are important to the function of the heater and which are not original Truma parts, as well as the non-observance of the installation and operating instructions, will lead to the cancelling of the guarantee and exclusion of liability claims. 4.2.7 Technical Data Power supply: ............................ 230v or 50Hz Weight: ..........................................
4 Caravan Equipment greater heat requirement. This means that the air output can be used to the full on this side. By adjusting the air flap (Fig. 1:d) the quantity of air can be increased individually. This means that the air output on the other side is reduced. ▲ If the air output drops or the operating noise increases, the fan impeller wheel may be severely soiled. Cleaning (with switched off appliance!).
Caravan Equipment 4.4 4 THE COUNTRY LEISURE COOKING APPLIANCES Operating Instructions Ensure the gas cylinder is turned on. In the event of a gas smell turn off at the cylinder and contact supplier. The use of a gas cooking appliance results in the production of heat and moisture in the room in which it is installed. Ensure that the kitchen is well ventilated, keep natural ventilation holes open or install a mechanical ventilation device (mechanical extractor hood).
4 Caravan Equipment 4.6 THE MIDI OVEN & GRILL (Ranger, Pageant & Senator) 4.6.1 Grill ▲ Accessible parts may be hot when the grill is used! Young children should be kept away. ▲ The heater deflector below the fascia should be pulled out prior to grill operation. ▲ Whilst the grill is operating never adjust the deflector without using hand protection. ▲ Only use the grill with the door open and always remove the handle from the pan when in use. 1. Ensure gas cylinder/supply is connected and turned on.
Caravan Equipment 4.6.2 4 Oven 1. Ensure the gas cylinder is connected and turned on. In the event of a gas smell turn off at gas cylinder and contact supplier. 2. Remove all accessories and packing that may be in the oven and clean the interior before using it for the first time. Use warm soapy water and rinse carefully. 3. To light : Open door, push in the control knob and turn to gas mark 9. Hold a lighted match or taper to the burner and push the control knob in and hold.
4 4.6.4 Caravan Equipment Temperature Control The temperature control in the oven is controlled by a thermostatic gas tap and is variable over the range 130°C to 240°C. Approximate temperatures for the settings on the control knob are shown in the table below. The temperatures indicated refer to the centre of the oven and at any particular setting the oven will be hotter at the top and cooler towards the base.
Caravan Equipment 4 Most cookery books give details of the shelf positions and gas mark settings for each recipe. If in doubt about a recipe you intend to use, study the recipe carefully then find a similar dish in our guide and use our shelf position and gas mark setting recommendation. Shelf positions are from the top down. When roasting with aluminium foil care must be taken that the foil does not impair circulation or block the oven flue outlet.
4 4.7 Caravan Equipment THE FIRE SENTRY SMOKE ALARM The Smoke Alarm is operational once the battery is connected. When products of combustion are sensed, the unit sounds a loud pulsating alarm until the air is cleared. 4.7.1 False Alarms ‘Hush’ Control Units with the ‘hush’ feature have the capability of temporarily disabling the alarm circuit for approximately 7 minutes. This feature is to be used only when a known alarm condition, such as smoke from cooking activates the smoke alarm.
Caravan Equipment 4.8 4 REFRIGERATORS Winter Operation - Thetford and Dometic Refrigerators ▲ Please check that the ventilation grilles or the flue outlets are not blocked by snow, leaves etc. Your caravan is supplied with winter covers as standard equipment. These covers should be fitted when the outside temperature is below 10°C. ▲ The covers should also be used when the caravan is in storage or is being washed by a high pressure spray. or during very wet weather.
4 Caravan Equipment 4.9.3 Energy Selection 12V Electrical Operation (DC) ▲ The refrigerator should only be used while the motor is running, otherwise the on-board battery would be discharged within a few hours! 1. Set energy selector switch (A) to 12V. 2. The refrigerator operates without thermostatic control (continuous operation). Mains power This option should only be selected where the supply voltage of the connection for power supply corresponds to the value specified on the data plate.
Caravan Equipment 4 3. Set energy selector switch (A) to Gas. 4. Press and hold rotary switch (B). 5. Activate ignition by pressing the button (C) and keep it depressed. 6. Check the inspection glass to see whether there is a flame (the inspection glass is inside the refrigerator at the bottom left). 7. Release igniter button (C). Keep rotary switch (B) depressed for another 10-15 seconds, then release. 8. Check the inspection glass to see whether a flame is burning. 9.
4 Caravan Equipment 4.9.4 Temperature setting cooling compartment As already shown, with rotary knob (B) the temperature in the cooling compartment can be regulated as necessary. ▲ The cooling unit’s performance is influenced by ambient temperatures. At ambient temperatures of +15 deg C up to +25 deg C, set the knob B to the middle position. The cooling unit works with optimal performance. ▲ Dometic refrigerators work according to the absorption principle.
Caravan Equipment 4.10 4 DOMETIC REFRIGERATOR MODEL RM 8550L (Pageant & Senator) 4.10.1 Cleaning Before starting up the refrigerator, it is recommended to clean it inside and repeat this at regular intervals. Use a soft cloth and lukewarm water with a mild detergent. Then wipe out the appliance with clean water and dry thoroughly. ▲ To avoid deterioration of materials: ● Do not use soap or hard, abrasive or soda-based cleaning agents. ● Do not allow the door seal to come into contact with oil or grease.
4 Caravan Equipment Explanation: The refrigerator is equipped to operate on mains power, 12V DC or liquid gas. Select the desired power supply by turning the energy selector switch A. The energy selector switch A has four settings: OFF, AC mains voltage, DC (battery), gas (liquid gas). 4.10.
Caravan Equipment 4 Prior to starting the refrigerator in gas mode: ● Open the gas cylinder valve. ● Open the shut-off valve for gas supply to the refrigerator. Appliances with battery igniter: 1. Turn the rotary selector switch A to position . 2. Turn the temperature selector B clockwise and push. Keep the controller button depressed. 3. Then, press knob C of battery igniter down and keep it depressed. The ignition process is activated automatically. 4.
4 Caravan Equipment Fixing and releasing the door lock hook when parking the vehicle If the vehicle is parked for a longer period of time, the locking hook may be clamped by means of a lockbar. The door may now be opened by just pulling it without need of pressing the locking button. Restore the original position by pushing the hook down. ▲ As a basic rule, shut and lock the refrigerator door before commencing your journey. 4.10.
Caravan Equipment 4 4.10.9 Exchange of the igniter’s battery Unlock the battery by depressing and turning the button (C) approximately 90 degrees clockwise. Remove cap and exchange battery (1.5V AAA / R3 / Micro). Observe correct polarity. 4.10.10 Shutting off the refrigerator ● For battery igniter models, set energy selector switch A to position ‘OFF’. The appliance is switched off. ● Press the ‘MODE’ button to switch off MES and AES models. Keep button A pressed for two seconds.
4 Caravan Equipment 4.10.12 Troubleshooting Before notifying the authorised Service Centre, please check whether: ▲ The instructions in the section “Operating the refrigerator” have been followed. ▲ The refrigerator is level. ▲ It is possible to operate the refrigerator with any available power source. Failure: The refrigerator does not cool sufficiently. Possible cause Action you can take a) Inadequate ventilation to the unit. a) Check that the ventilation grilles are not covered.
Caravan Equipment 4 14.101.13 Maintenance ● Works on gas components and electrical installation may only be carried out by authorised personnel. We recommend to contact your Dometic Service Centre. ● EN 1949 stipulates that the appliance’s gas equipment and its associated fume system must be inspected after installation and a certificate issued. Afterwards a qualified technician must inspect according to EN 1949 every two years and a certificate issued.
4 4.11 Caravan Equipment THETFORD REFRIGERATOR MODEL N97 (Ranger) 4.11.1 Switching on the refrigerator ● Clean the inside of the refrigerator before you switch it on. ● Let the refrigerator cool for at least eight hours before you place food in it for the first time. ● The freezer compartment should be cold one hour after switching on the refrigerator. A = Energy source selector switch B = Thermostat C = Flame meter D = Piezo Ignition 4.11.
Caravan Equipment 4 Open the valve of the gas bottle and the gas taps. Set the gas control button to the maximum position. Set the energy source selector switch (A) to ignite the gas flame. 4.11.4 Power with gas 1 Open the valve of the gas bottle and the gas taps. 2 Set the thermostat button (B) to the maximum position. 3 Set the energy source selector switch (A) to 4 Press the gas control button, rotary switch (B), and keep it depressed. 5 Depress the piezo ignition button so that it clicks.
4 Caravan Equipment 4.11.7 Door locking mechanism The refrigerator door has an automatic locking mechanism. The door locks automatically when you press it shut firmly. The lock releases unnoticed when you open the refrigerator with your hand. This automatic locking mechanism also keeps the refrigerator door shut during driving. For some models an additional security device is fitted below the refrigerator.
Caravan Equipment 4.12 4 THE THETFORD CASSETTE C-200 CW / CWE (Discovery & Ranger) The unit consists of two sections, a permanently installed toilet system and a slide out waste holding tank. The toilet section of the C-200 CW includes a rotatable bowl, removable seat and cover, a console with flush handle, a built in flush water tank and a waste level warning indicator. Underneath the bowl, the valve blade handle is located.
4 Caravan Equipment 2 3 4 5 6 7 8 9 10 11 12 13 14 15 1 4-32
Caravan Equipment 4 vii. Open the water fill door and add 50ml. of Aqua Rinse. This results in a better flush and improves the hygiene of the toilet. Then fill the tank with fresh water using a jerry can or hose. Tank Capacity is 7 litres (fig.7). 4.12.2 Operation viii. Turn the bowl into most comfortable position (fig.8). The toilet can be used with the blade open or closed. If closed go to step ix. If open go to step xi. ix.
4 Caravan Equipment and cover and the outside of the toilet. When the toilet is not going to be used for a long time, leave the cap off the pour-out spout and leave the blade open so the cassette can dry. ▲ Never use household cleaners (bleach, solvents or other powerful cleaning agents). These may cause permanent damage to the seals and other toilet components. 4.12.5 Winterising / Storage The Thetford Cassette is easily winterised for storage.
Caravan Equipment 4.13 4 THE THETFORD CASSETTE C-250 (Pageant & Senator) 4.13.1 Introduction The Thetford Cassette Toilet is a high quality product. The toilet forms an integral part of your caravan or camper bathroom, thanks to its functional design which combines modern styling and ease of use. The C-250 Cassette Toilet is manufactured from high quality synthetic materials which makes it a durable, user and maintenance friendly toilet.
4 Caravan Equipment Standard C250 Control panel (with optional features) 4-36 Optional features C250
Caravan Equipment 4 4.13.2 Preparing for use (standard) 1. Open the access door on the outside of your caravan or camper. 2. Remove the Waste Holding Tank by pulling the safety catch (which holds the tank in place) upwards. 3. Pull the Waste Holding Tank outward to the stop. Tip it slightly and take the tank fully out. 4. Place the tank upright and turn the rotating emptying spout upwards. The emptying spout ensures that the tank can be easily and hygienically emptied. 5.
4 Caravan Equipment pressing the flush button for several seconds (if necessary re-activate the control panel). Close the blade after use. ▲ If your toilet has its own flush-water tank, please make sure that you do not travel with a flush-water tank that is too full. Do not travel with water in the toilet bowl. Failure to adhere to this notice may result in water damage to your caravan or motor home. 4.13.5 Using the toilet with Optional Features 13.
Caravan Equipment 4 20. Waste Pump-Out System: When activating the control panel this feature automatically lights up. When the Waste Holding Tank Level Indicator illuminates, press the Waste Pump-Out button to pump out the waste from the holding tank into the vehicle’s waste tank. The button will flash while the waste is being pumped and will stop automatically (after approximately 5 minutes) when all waste has been transferred.
4 Caravan Equipment The rubber seals in the toilet (the lip seal, the mechanism seal, the automatic pressure release vent seal and the cap seal) should be regularly cleaned with water and treated with Thetford High Grade Seal Lubricant. This will ensure that the seals remain flexible and in good condition. If the toilet is not to be used for any length of time, it is important to treat the seals with Thetford High Grade Seal Lubricant after cleaning.
Caravan Equipment 4.14 AL-KO SECURE ● Align the wheel so that the receiver can be seen in the centre of the rim opening. DO NOT use the rim opening in which the tyre valve is fitted (Fig 1). ● Unscrew the plastic cap from the receiver and store in the tool kit box. (When AL-KO Secure is not in use, always screw the plastic cap in place). (Fig 2). ● Insert the locking bolt into the rim specific insert (Fig 3). ● Insert the locking bolt socket key (Fig 4).
4 4.15 Caravan Equipment AL-KO ATC TRAILER CONTROL SYSTEM AL-KO ATC is an electronic, emergency braking system for caravans and trailers. It automatically recognises critical swinging motions and applies the caravan brakes accordingly to regain control of the car and caravan. ▲ AL-KO ATC is a passive safety product and activates the braking system on the caravan in unsafe driving conditions.
Caravan Equipment 4.16 4 OMNIVENT ROOFLIGHT MOUNTED EXTRACTION FAN (Pageant & Senator only) 4.16.1 Use Ventilator (only for OMNIVENT 12V) The ventilator is started by the switch marked < o > (extraction or intake) The airflow is adjusted by the black switch: position 1 = 7m3/min. (245 cft/min.) (10W - 0.8 A) position 2 = 12m3/min. (420 cft/min.) (25W - 2.2 A) position 3 = 20m3/min. (700 cft/min.
4 4.17 Caravan Equipment THE ALKO CARAVAN CHASSIS 4.17.1 Chassis members The recommended tow vehicle coupling height is 415 +/- 35mm from the ground to the centre of the ball. Manufactured from high quality steel, the chassis has extra deep sections to provide strength at points of maximum stress. Large elongated holes are punched in the longitudinal and towbar, (‘A’ frame) members, to reduce weight to a minimum.
Caravan Equipment 4 4.17.5 Operation : Type AK 160 & AK 300 Coupling Head Lift locking trigger and lift handle upward and forward. Place the unlocked coupling onto the towing ball and with the slightest downward pressure it will lock onto the ball automatically. Ensure locking trigger returns to its free position before commencing to tow. 4.17.6 Secondary braking (Breakaway cable) Please refer to details in Section 2.2.5, page 2-3. 4.17.
4 Caravan Equipment 4.17.11 Stabiliser Unit: 2) To operate the Stabiliser (once coupled to the towball), simple press the stabiliser lever down as far as it will go (Fig. 4/Item 2). 4.17.12 Uncoupling 1) Pull the stabiliser lever handle up as far as it will go, open the coupling handle and lift the AKS 3004 from the towball. With larger nose loads, coupling and uncoupling can be made easier by using the jockey wheel to assist lifting.
Caravan Equipment 4 down by hand force only DO NOT use your foot or an extension bar, this will damage the components (Fig. 6). 3) When opening or closing the stabiliser lever, please ensure your hand does not touch the coupling handle - you may accidentally trap your fingers! (Fig. 6). 4.17.15 Noises whilst driving As a rule, the friction pads of the AKS 3004 do not make a noise during driving.
4 Caravan Equipment 4.17.20 Jockey wheel Lubricate wheel and screw thread periodically with grease. 4.17.21 Brake linkage All moving parts should be lubricated periodically to ensure their satisfactory operation. 4.17.22 Corner steadies The screw and pivot pins should be lubricated periodically to ensure their satisfactory operation. 4.17.23 Braking system adjustment (At 500 miles, then every 3,000 miles or 1 year) i. Ensure the towing shaft with coupling heads is pulled fully forward (fig. 8). ii.
Caravan Equipment xi. 4 Check the brake rod support bracket, (fixed to the floor) is supporting the brake rod evenly. The brake rod must always run straight, never bent or curved under any fittings. On tandem axles, using the double balance bar, a brake rod support tube (Part No. 228827) must always be fitted on the end of the brake rod, passing through the centre aperture on the abutment. xii. Remove the slack in the brake rod by adjusting Fig.
4 Caravan Equipment ▲ In order to operate the Al-Ko braking system correctly adequate traction of caravan wheels is required when reversing. Therefore surface conditions that would result in a lack of traction should be avoided. Example: Peas, shingle/loose gravel. ▲ Care should be taken when traversing ramps or other obstacles in order to prevent damage to the caravan under gear. When approaching such obstacles reduce towing speed appropriately. 4.17.24 Chassis Lubrication Points 1.
Caravan Equipment 4.19 4 HEKI 2 ROOFLIGHT Operating Instructions ▲ Before commencing any journey always ensure that the Heki 2 rooflight is fully closed and both handles are securely fastened. 4.19.1 To open in the tilted position a) Press the knob in the toggle catches on either side of the glass and turn through approx. 90 deg. b) Grasp the metal bar in the middle, snap it out of its holder, swivel down and press the glass dome upwards. (Glass dome is held by the two gas springs after approx. 150mm).
4 Caravan Equipment 4.19.5 Opening the blinds a) Move blind (end rod with rocker) right to the outside. b) Hold the recessed grip with one hand; with the other hand, press the rocker and move the blind back (do not let it recoil). ▲ Do not stand on the acrylic glass dome. ▲ Close Heki 2 completely before moving off. ▲ Do not leave your vehicle when Heki 2 is open. ▲ Please consult your local dealer if you have any problems or defects. ▲ Remove any snow/ice or dirt before opening the roof.
Caravan Equipment 4.21 4 DISCOVERY, RANGER & PAGEANT COMBINATION WINDOW BLINDS Operation and Care The cassette contains a sun screen and a fly screen blind. The fly screen is operated by gently pulling down the handle nearest the window. It is designed to be either fully up or fully down. Push the handle towards the window until the crossbar hooks into the catch. To release blind push the handle downwards and gently towards you. This will unhook the catch and the blind can be raised.
4 4.22 Caravan Equipment TRACKER MONITOR Operating Instructions Tracker Monitor for caravans is armed and disarmed by an alarm. Triggering the alarm siren does NOT generate an alert from the Tracker Monitor unit. 4.22.1 To arm To arm the Tracker Monitor system, press the button on the remote control once. The siren will bleep twice. After 45 seconds the alarm system will arm. After a further five minute delay the Tracker Monitor system will arm.
Caravan Equipment 4 4.23 STATUS 315 OMNI-DIRECTIONAL TELEVISION & FM RADIO ANTENNA (Ranger only) 04-2064/5 Model 04-2064/10 Model Frequency Range Amplifier Gain Gain Adjustment Flatness Noise Figure Output Impedence Output Power Supply Power Consumption 5 metres coaxial cable 10 metres coaxial cable UHF 470-860 MHz VHF 40-230 MHz FM 88 - 108 MHz 18 db* 15 db ± 2 db 3 db 75 ohms 98 dbuv 12-24V DC 35 ma 4.23.1 Travelling ▲ Do not travel when using the suction pad facility. 4.23.2 Operating the System 1.
4 Caravan Equipment 4.23.5 Fault Finding The following are some of the key areas we suggest you check which generally solve the most common problems encountered with the operation of the Status antenna. Coaxial Plugs It is critical that all coaxial plugs in the system are fitted correctly. Please check each individual plug ensuring it is wired correctly. Secondly please ensure only quality plugs have been used.
4 Caravan Equipment 4.24 STATUS 530 DIRECTIONAL TELEVISION & FM RADIO ANTENNA (Pageant & Senator) Frequency Range Antenna Forward Gain Amplifier Gain Gain Adjustment Flatness Noise Figure Output Impedence Output Power Supply Power Consumption TV lead UHF 470-860 MHz VHF 40-230 MHz FM 88 - 108 MHz 7db 18 db* 15 db ± 1.52 db 3 db 75 ohms 98 dbuv 12-24V DC 35 ma 2 metres 4.24.1 Travelling Do not travel: With the Antenna raised. With the Antenna set for vertical signals. With the Telescopics extended.
4 Caravan Equipment 4.24.4 Fault Finding The following are some of the key areas we suggest you check which generally solve the most common problems encountered with the operation of the Status antenna. Coaxial Plugs It is critical that all coaxial plugs in the system are fitted correctly. Please check each individual plug ensuring it is wired correctly. Secondly please ensure only quality plugs have been used.
Caravan Equipment 4.25 4 DAEWOO MICROWAVE OVEN 4.25.1 Precautions to avoid possible exposure to excessive microwave energy ▲ Do not attempt to operate this oven with the door open since open-door operation can result in harmful exposure to microwave energy. It is important not to defeat or tamper with the safety interlocks. ▲ Do not place any object between the oven front face and the door or allow soil or cleaner residue to accumulate on sealing surfaces. ▲ Do not operate the oven if it is damaged.
4 6. Caravan Equipment Microwave energy will be turned off automatically when the timer reaches “OFF”. Then food can be taken out of the oven. • To prevent the oven from operating with the door open, your microwave oven is fitted with safety door interlock switches. • If you wish to inspect the food while it is cooking simply open the door. The oven will automatically stop cooking. To continue cooking, you simply close the door.
Caravan Equipment 4 4.25.4 Cooking Techniques Stirring Stir foods such as casseroles and vegetables while cooking to distribute heat evenly. Food at the outside of the dish absorbs more energy and heats more quickly, so stir from the outside to the center. The oven will turn off when you open the door to stir your food. Arrangement Arrange unevenly shaped foods, such as chicken pieces or chops, with the thicker, meatier parts toward the outside of the turntable where they receive more microwave energy.
4 Caravan Equipment 5. Plastic - most heat resistant plastic dinnerware may be used for heating food. However polyethylene, melamine, phenol are unsuitable for use in the oven. They become hot in the microwave. 6. Wax paper - use as a cover to avoid spatters. 4.25.6 Care and Cleaning Although your oven is provided with safety features, it is important to observe the following: 1. It is important not to deface or tamper with safety interlocks. 2.
Caravan Equipment 4 Q: Why do I have moisture in my microwave oven after cooking? A: The moisture on the side of your microwave oven is normal. It is caused by steam from cooking food hitting the cool oven surface. Q: Does microwave energy pass through the viewing screen in the door? A: No. The metal screen bounces back the energy to the oven cavity. The holes are made to allow light to pass through. They do not let microwave energy pass through. ▲ Do not attempt to service the oven yourself! 4.
4 4-64 Caravan Equipment
General 5.1 GENERAL MAINTENANCE 5.1.1 Exterior 5 The exterior of your caravan is very durable and easy to clean owing to its high gloss properties. To maintain a showroom finish one needs only to wash the caravan regularly with a car shampoo, rinse with cold water and chamois leather off. Do not forget to clean the roof. A good quality non metallic and non-coloured car wax that does not contain white spirit may be applied, which will make washing easier.
5 5.1.3 General Window Catches and Stays Turn catch arm to the vertical position to open. A night vent position is available by locking the catch into the outer catchplate slot. The windows are held open by an adjuster knob, tightening off the knob in a clockwise direction will hold the window open in the desired position. Always ensure knob is unscrewed before closing the window. Failure to do so may cause damage to the window stay arm.
General 5.1.7 5 Hinges and Catches Lightly oil occasionally. Carpets Vacuum periodically to remove grit and to ensure long life. 5.1.8 Free Standing Table ● Maximum load on the table is 50kg. ▲ Do not at any time sit or stand on the table. 5.1.9 Kitchen Chopping Board Care and usage of your hardwood board Please take note of the following points to allow your board to give you a full working life. Before using, wipe clean with a damp cloth then oil with a good vegetable oil, allow to dry overnight.
5 General 5.1.12 For Containers 1. All water remaining in the container should be disposed of so that the container is empty. (If the container is an onboard tank, it should be removed if possible.) 2. The outside of the container should be thoroughly cleansed and washed down to remove any dirt, dust or other contaminant. Water at a suitably hot temperature containing an appropriate detergent is recommended for this purpose. 3. Water should be put in the container, swirled around, then emptied out. 4.
General 5.2 5 FIRE AND SAFETY PRECAUTIONS ▲ Your attention is drawn to the notice affixed in the caravan advising on fire prevention, ventilation and what to do in case of fire. Ensure that the occupants are familiar with escape routes, in case of a fire. 5.2.1 Children ▲ Do not leave children alone in the caravan in any circumstances. When in the caravan ensure that children are supervised at all times. Keep potentially dangerous items out of reach as at home, e.g. matches, medicines etc. 5.2.
5 5.2.6 General Original Equipment Appliances See sections devoted to individual appliances. ▲ Replacement parts for any appliance shall conform to the appliance manufacturer’s specification; and should be fitted by them or an authorised agent. 5.2.7 Portable Appliances ▲ Never use portable cooking or heating equipment, other than electric heaters that are not of the direct radiant type, as it is a fire and asphyxiation hazard. 5.2.
General 5.
5 5.3.1 i. General Lift up Bunk Remove cushions and draw the curtains and close the blind if fitted. ii/iii. Holding bunk in both hands pull it inwards whilst lifting upwards. iv. The bunk mechanism will automatically lock in the up position. v. Release retaining straps on the underside of bunk base. The second half of the bunk base can now be unfolded towards the caravan wall. vi.
General 5.4 WATER SYSTEM - FAULT FINDING 5.4.
5 5.4.4 General FAULT - Water flows from hot tap but has reduced flow from cold Cause Cure Cold water pipe kinked preventing flow Check and re-route if necessary Blockage in cold pipe line Disconnect pipes after 1st Y connector and check up to tap Cold tap not connected Refer to installation instructions Cold tap failed or blocked Disconnect and inspect If a Carver Crystal water service unit is fitted the cartridge is exhausted Replace cartridge 5.4.
General 5.4.8 5 FAULT - Water heater difficult to drain Cause Cure Hot taps not open preventing air entering hot system to let water out. Open taps Air bleed pipe kinked or blocked. Unkink or unblock pipe.
5 General 5.5 ROOM HEATER - FAULT FINDING 5.5.1 FAULT - Heater will not light Symptoms Cause Cure Spark visible No gas. Bottle temperature too low Check bottle and taps. See gas supply notes. Regulator malfunction. See gas supply notes. Overgassed. Refer to lighting instructions. Turn off. Wait 3 mins. Piezo failure. HT lead shorting to earth or broken. Seek service attention. Check and insulate or repair. No spark. 5.5.
5 General 5.6 BRAKE FAULT FINDING CHART - AL-KO 5.6.1 FAULT - Braking is one-sided Cause Cure Incorrect adjustment at wheel. Adjust as described. Brake cable seized. Free off cable or replace. Brake lining contaminated with grease. Replace brake shoe assemblies. 5.6.2 FAULT - The trailer brakes during mild decelerations Cause Cure Shock absorber in overrun device weak or ineffective. Examine and replace if necessary. Brakes overadjusted. Re-adjust as described. 5.6.
5 5.6.6 General FAULT - Trailer brakes inoperative Cause Cure Brakes underadjusted. Check action and rectify. Lining contamination. Replace brake shoe assemblies. Seized cables. Free off or replace. Linings worn out. Replace brake shoe assemblies. 5.6.7 FAULT - Hot brakes Cause Cure Brakes overadjusted. Re-adjust as described. Pull-off spring broken. Replace spring. Seized cables. Free off or replace. 5.6.
General 5 To disarm the Tracker monitor system press the button on the remote control once. The siren will beep once and the Tracker monitor will be disarmed. If already sounding the siren will be silenced. Q I have been pushing my caravan around the car park and the alarm has not gone off? A Please see above.
5 General Q How long will the Tracker system work if the caravan is not connected to a mains supply? A Please see above question. Q How do I know if my Tracker battery is fully charged? A Your Tracker battery will be fully charged as long as you have not had a flat leisure battery and you at regular intervals of between 3 to 6 months connect to a mains hook up. Q My leisure battery went flat; do I need to do anything? A Yes, you must charge the leisure battery by connection to a mains hook up.
General 5 A You need to go to your dealer to purchase a replacement remote. He will de-program your old remote from the alarm then it will never work and at the same time re-program the alarm to the replacement remote Q I only have one Radio Remote. Can I obtain more? A Yes, your dealer will be able to sell you additional remotes and program the system for them.
6 6-2 Index
Index 6 A R Antenna Status 315 .................................................... 4-55 Status 530 .................................................... 4-57 Refrigerators .................................................... 4-17 N97 Model .................................................... 4-28 RM 7390 Model ............................................ 4-17 RM 8550L Model .......................................... 4-21 Registration ........................................................
Bailey Caravans, South Liberty Lane, Bristol BS3 2SS www.bailey-caravans.co.
