Instruction manual

Maintenance
Maintenance
Whilst your opener does not require any periodic
maintenance, the door that it is fi tted to, does. Your
garage door is a large, heavy, moving object and should be
tested regularly to ensure it is in good condition. A poorly
maintained door could cause fatal or serious injuries or
serious damage to property.
RDO-1v3 has a built in maintenance counter. From factory
this is loaded with 3000 cycles. When this counter expires,
the service yellow LED will light up, At the start of each cycle
the beeper will sound three times. After opening the door
the courtesy light will fl ash and beeper sound fi ve times.
B&D suggests that you contact your nearest Approved
Dealer to perform an door service.
When maintenance counter indicate service is due it can
be reloaded with 3000 cycles by press and holding the
LIMIT SET button on the console.
To ensure a long and trouble free life for your opener the
following is recommended:
Monthly
Disengage the opener and manually operate the door:
The door must be smooth to operate by hand. An
operating force on the bottom rail should not exceed
150N (15kg) force.
Each month check that the opener reverses when the
door contacts a 40mm high object placed on the fl oor
.
NOTE: If the door does not operate smoothly, call your
nearest Approved Dealer.
Yearly
•
•
B&D suggests that you contact your nearest Approved
Dealer to perform an annual door service.
CAUTION: Frequently examine door,
particularly cables, springs and
mountings for signs of wear, damage
or imbalance. Do not use if repair or
adjustment is needed since a fault in the
installation or an incorrectly balanced
door may cause injury.
Adjustments should only be carried out
by experienced persons, as this function
can
be dangerous if not performed under
strict safety procedures.
WARNING! Failure to maintain your
garage door may void the warranty on your
garage door opener.
Date Service by Signature Invoice No. Amount
Service Record
Record any maintenance in the following table to assist in any warranty service.
Diamond PD Power Drive : Instruction Manual
© Copyright June 2012 B&D Doors
23Controll-A-Door
®
Diamond PD - Power Drive Instruction Manual