Final 2006 AT Handbook 1/12/05 12:06 pm Page 1 Important Your motorhome makes use of many complex systems and services. Please ensure that you have read all instruction manuals carefully, and fully understand all aspects of your vehicle, before driving it on the open road. If you have any queries on the operation of any part of your motorhome please contact your supplying dealer.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 2 Useful Information Model Date Purchased Supplying Dealer Sales Person Telephone Number Tyre Pressure Radio Code Exterior Door Key Number Water Filter Key Number Vehicle Build Number 2
Final 2006 AT Handbook 1/12/05 12:06 pm Page 3 Useful Information Name Phone Number 3
Final 2006 AT Handbook 1/12/05 12:06 pm Page 4 Contents Section Pages 1. Introduction 5 2. Preparing For The Road 6-7 3. External Features 8-9 4. Driving Your Motor Home 10 -11 5. On Site 12 6. Gas: Services 13 -15 7. Gas: Appliances 16 - 25 8. Diesel Heating System 26 - 27 9. Electricity: Services 28 - 38 10. Integrated Entertainment System 39 11. Water: Services 40 12. Water: System 41 - 43 13. Water: Appliances 44 - 46 14. General Care 47 - 48 15.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 5 1. Introduction quoted.This can be found on the nearside plate by the entrance door. Auto-Trail welcomes you to the ranks of Auto-Trail owners. This handbook has been designed to enable you to derive the maximum benefit and enjoyment from your motor home; its information will be beneficial to experienced and new caravanners alike.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 6 2. Preparing For The Road Pre-Load Checklist Roof Rack (If fitted) • Ensure all articles are stowed securely. Do not store tins, bottles or heavy items in overhead lockers. • Secure all bunks. Please be advised that the maximum recommended weight that should be carried on a roof rack is 40kg. Please be advised that in certain climatic conditions the fibreglass roof may become slippery. Please take extreme care when walking on your vehicle roof.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 7 2. Preparing For The Road Tow Bars Various suppliers manufacture tow bars that can be fitted to your Auto-Trail vehicle. Please check with your tow bar supplier that the carrier that you fit to your vehicle meets your requirements, and does not contravene any road traffic regulations. Final Checklist • Secure all loose items. • Close all interior doors. • Place tip up sink in open position.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 8 3. External Features A Exterior door retaining catch when open B Folding step C Fridge vents D Awning light (where fitted) E E Status T.V.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 9 3.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 10 4. Driving Your Motorhome Speed Limits Reversing Always adhere to the speed limits. Proficiency at reversing can only be achieved with practice and should first be attempted in a large open area. Courses are run by many organisations. Driving Abroad Please ensure that you are familiar with the relevant laws and regulations that apply in the countries in which you choose to travel.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 11 4. Driving Your Motorhome Changing a Wheel • Remove wheel trims. Use the wheel brace to slacken off wheel nuts on the wheel to be changed. • Position the jack under the axle or at the appropriate jacking point. • Jack up motor home until the wheel for removal is just off the ground. • Remove wheel nuts and wheel. • Fit the spare wheel (located in the carrier) and reverse the above procedure. • Tighten all nuts equally.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 12 5. On Site Selecting a Pitch Do not pitch in a position in which your vehicle will obstruct others coming in. Try to choose an area that is dry, reasonably level and, preferably, with a hard base. If you have no alternative but to pitch on a slope, ensure that when you leave, you are driving down the slope. It is always good practice to check the wheels of the motor home when parked on a slope or a slippery surface although the brakes are applied.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 13 6. Gas: Services GENERAL INFORMATION Propane There are four gas appliances in the motor home: refrigerator, water heater, hob and oven. Gas flows to a set of safety shut-off valves controlling each appliance.The valves allow isolation of a single appliance without affecting the operation of the other equipment. Propane is supplied in red or partly red bottles that have a female left hand thread connector.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 14 6. Gas: Services Pressure Regulating Device Awning Space LPG Appliance Exhaust Your vehicle is fitted with a bulkhead mounted pressure No danger is caused if the LPG exhaust from the refrigerator vents into an enclosed awning. If totally enclosed, space heaters may produce enough exhaust to pollute an enclosed awning to discomfort levels. In extreme cases, carbon dioxide build up could reach a dangerous level.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 15 6. Gas: Services Ventilation Portable Heaters Low-level ventilations is provided from either the passenger and drivers door, or behind the drivers seat. High-level ventilation is provided by sky lights located in the roof of the vehicle. Never use portable cooking or heating equipment, other than radiant heaters that are not of the direct radiant type, as it is a fire and asphyxiation hazard.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 16 7. Gas: Appliances COOKING APPLIANCES Hotplate Your vehicle is fitted with either a Spinflo four gas burner and oven, or three gas burners and one 230V mains hot plate and oven. Pans with a diameter of up to 22cm are suitable for use on this appliance.The pans must not overhang the pan support. The gas burners are adjustable between simmer and full flame, and the oven temperature ranges from 130ºC to 240ºC.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 17 7. Gas: Appliances • The oven shelf is designed to allow good circulation at the rear of the oven and are fitted with a raised bar to prevent trays or dishes making contact with the back of the oven.To remove the shelf, pull forward until it stops, raise the front and remove. Glass: Use warm soapy water or a mild cream cleaner.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 18 7. Gas: Appliances Refrigerator Gas Operation DOMESTIC RM7361 see side panel for description 1 Open the valve of the gas cylinder. Note:The refrigerator is equipped to operate on mains power, DC or liquid gas (propane / butane).The desired power option is selected by means of energy selector switch (A). Energy selector switch (A) has four settings:AC mains power, DC (12V), Gas (liquid gas), OFF. 2 Open the shut-off valve on the gas supply.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 19 7. Gas: Appliances Thetford N150 Fridge Freezer Instructions Selecting Manually Switching on the refrigerator Mains voltage (230V) 1. Open the valve of the gas bottle The LED on the main switch warns you whenever insufficient voltage is available or if a fault occurs. If this happens, the LED will change from green to red and flash once per second and an error code is shown on the LCD display.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 20 7. Gas: Appliances POWERING WITH GAS Important! It is prohibited to use gas to power the refrigerator while you are driving. If a road accident results in fire, there is a danger of explosion. It is prohibited to use gas to power the refrigerator in the vicinity of petrol stations. If it takes longer than 15 minutes to refuel your vehicle, you should switch the refrigerator off using the main switch (A).
Final 2006 AT Handbook 1/12/05 12:06 pm Page 21 7. Gas: Appliances Food Storage Cleaning the Refrigerator Always store food in closed containers. Never put hot food in the fridge, always allow at least 1.5hours cooling first. Clean the inside of the fridge regularly to keep it fresh and hygienic.A cleaning solution of 0.5 litre of warm water and 1 teaspoon of bicarbonate of soda should be used. Cloths should be wrung out after soaking and used to clean the interior of the fridge and the fittings.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 22 7. Gas: Appliances Troubleshooting VEHICLE HEATER If the fridge fails to work, check the following points before calling a technician. The auto heater is based on an extremely efficient heat exchanger consisting of a pair of internally and externally finned aluminium diecastings. • Ensure that the correct procedure has been followed for starting the refrigerator.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 23 7. Gas: Appliances Switching Off • Keep the control knob pressed down for a further 10 seconds to allow the safety pilot to operate. Turn the control switch to 0 (the automatic ignition will switch off at the same time). If the unit is not used for a relatively long period of time, close off at the quick action gate valve on the gas pipe and the gas bottle.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 24 7. Gas: Appliances • Do not obstruct the gap at the bottom of the heater or the outlet grille slots. TRUMATIC C 3402 / C 6002 VEHICLE HEATER Operating Instructions Check that any exterior flue covers are removed. • Heaters should be switched off while the vehicle is in motion. Turn on the gas cylinder and the isolation valve in the gas supply line. • A guard fitted around the heater is recommended where children are present.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 25 7. Gas: Appliances Switching on Depending on the room temperature the heater will automatically select the output of the heater required. Once the room temperature has been reached, the heating will switch off (regardless of the water temperature). • Check that you have a mains supply, and that the fuse spur is switched on. • Turn control ring (b) to required power setting.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 26 8. Diesel Heating System Eberspacher Cobitronic Heater This is a diesel fuelled combination heating system incorporating the latest technology to provide hot water and air heating from the unit located under the vehicle. Diesel is drawn from the vehicles own fuel tank, with the option to combine and utilise mains voltage when available. Heating and Hot Water Button This button is used to turn the heating on or off.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 27 8. Diesel Heating System Frost Setting Settings Button When activated this setting overrides the normal heater operation. A LED next to the button illuminates to show that the frost mode is activated. This setting operates the heating system at approximately 5°C, and periodically operates the water heating to prevent freezing. If the vehicle is on mains hook up then the mains heating is used. If not then the diesel system operates.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 28 9. Electricity: Services GENERAL INFORMATION Connecting and Disconnecting the Battery The electric system in Auto-Trail vehicles makes good use of modern technology. It is centred on the hightech Switchmode power supply system.This 12 V DC charger has been specifically designed for use in a motor home. It is capable of charging the battery safely for long periods without overcharging.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 29 9.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 30 9. Electricity: Services 3. Power Supply Unit - System Operation • Check Residual Current Device operation. 3.1 Introduction Locate the RCD within the PSU and ensure the RCD is switched on (lever in up position). Press the TEST button and confirm that the RCD is turned off (lever in down position). Switch the RCD back to the on position (lever in up position). If the test button failed to operate the RCD see section 3.4.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 31 9. Electricity: Services Installation & Removal Always disconnect the 240v mains supply and turn the PSU charger switch to the OFF (0) position before removing or installing the battery. When connecting the battery, ensure that the correct polarity is observed (black is negative [-] and red is positive [+]) and that the terminals are securely fastened. Crocodile clips must not be used. Warning: Explosive gases may be present at the battery.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 32 9. Electricity: Services Wiring of connecting cable and motor home mains inlet: Pitch outlet supply GENERATORS If a generator is fitted the vehicle must be regularly serviced to achieve the optimum performance. Engine speed is used to govern the output and frequency of the unit in KW and Hz, and if this is allowed to vary beyond a safe level, permanent damage could be caused to certain electronic equipment such as 12 V chargers etc.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 33 9. Electricity: Services Warning: It is essential that connections are made exactly as shown. If the terminal markings are not in accordance with the diagram, they must be ignored. If in doubt, consult a qualified electrician. Overseas Connections Connection to mains voltage overseas requires particular attention. Electricity supplies abroad may be of reverse polarity.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 34 10. Integrated Entertainment System Operating Guide (built in FM modulator) DVD Operation Safety Notice Rotate selector dial (C) to position 1 on the control tower. It is not only illegal, but also highly dangerous for the TV / DVD monitor to be positioned where it can be viewed by the Driver when the vehicle is in motion.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 35 11. Water: Services The motor home is equipped with an under-floor fresh tank, which is insulated on the Frontier range.This is filled through the filler cap sown opposite. If the water pump runs for more than 5 - 10 seconds after you have closed all the taps, it is possible that there is a leak in the system.This should be checked. To fill: If you are experiencing problems contact your Auto-Trail dealer who will be glad to assist.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 36 13. Water: Appliances the appliance wait 5 minutes - then switch on again. TRUMA-ULTRASTORE This is a 10 l capacity liquid gas storage heater. THETFORD CASSETTE TOILET Always read the manufacturers operating instructions prior to starting this appliance for the first time and observe the 'important operating notes'.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 37 13. Water: Appliances Preparing for Use Caution: • Open access door on the side of the vehicle and swing out fresh water fill funnel (if applicable). • Do not add Aqua Kem concentrate or Aqua Kem Bio directly into the toilet bowl while the cassette tank valve blade is closed. • Fill fresh water tank (if applicable) using a hose or a watering can until the water level reaches the neck.The tank capacity is 15 litres.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 38 13. Water: Appliances • Pull apart and change roll. Cleaning and Maintenance • Insert the prongs of the cover into the holder and, whilst holding the bottom and the cover, twist in the opposite direction until locked. No routine maintenance is required for the toilet.The use of Aqua rinse helps to clean and protect the toilet bowl, valve blade and seals during flushing.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 39 14. General Care MOTOR HOME EXTERIOR leather or ‘vyleda’ type cloth. The catches and stays do not need lubricating. Paintwork Removing tar: Use ‘Jove Tar Remover’ on double glazed windows. It is available from most leading car accessory or do it yourself shops such as ‘Halfords’. Do not use petrol or other chemicals without approval. The exteriors of Auto-Trail Motor homes are finished with stoved enamelled aluminium.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 40 14. General Care Vanity Unit Your vehicle is fitted with a vanity bowl. Do not pour very hot water into it as it is made from a moulded polymer material that may deform. Always put cold water in first. Care of Plastic Components The cleaning of any plastic components in the vehicle, e.g. Shower tray, should only be undertaken with mild soapy water.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 41 15. Fire And Safety FIRE AND SAFETY PRECAUTIONS Engine Fires In Case of Fire: • Get every one out of the motor home. • Call the fire brigade. • Turn off outside gas valve, remove cylinders from vehicle and place some distance away if possible. • If it is an electrical fire, always turn off the supply as quickly as possible. • Tackle the fire only if it is safe to do so. If Tackling the Fire: • Tackle from the outside not the inside.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 42 16. Security/Points Of Law SECURITY POINTS OF LAW At Auto-Trail, we have tried to go further than any other motor home manufacturer to protect your investment. The essential law for motor home owners is the Road Traffic Act (1972) and the regulations that followed. Make it difficult for the thief by protecting your motor home and its contents.Always lock all doors and windows when leaving, even for a short time.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 43 17. Winter Laying Up Whether you use your motor home all year round or lay it up for the winter, care should always be taken to ensure your investment is receiving the very best attention. The normal regular maintenance has been covered in the preceding pages. To drain off: The following tips will be helpful for the periods when your motor home is not regularly used. It applies if you store in a compound away from home or in your own drive.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 44 18. Guarantee 1.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 45 19. Annual Check list Auto-Trail Motor Home Annual Checklist. 3. External Doors Introduction Security: Check hinges and catches for satisfactory operation and ensure that the doors are held securely shut when latched. Check that keys and internal latches lock the doors properly. Check that any device designed to hold the door in an open position is fitted correctly and operates positively.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 46 19. Annual Check List Dinette seat and beds: Check seat bases for signs of damage and ensure fixings are secure. Make up the beds according to the manufacturer’s instructions and check for rigidity and safety. Under-floor water tank mountings: Check that the mounting frames are fixed securely to the body. Check that any tank release fastenings are free from rust and corrosion and they operate smoothly.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 47 19. Annual Check List causes sooting and indicates the pressure is too low. If these faults occur, recheck the regulator, cylinders and pipes, adjust as necessary. Hosing and piping: Check flexible hoses for cracking and condition. Check the date stamped on them has not passed. If the expiry date is close or passed, have the hoses replaced. Check all rigid piping for adequate support and any damage.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 48 19. Annual Check Mains system 240V: Inspection and certification of the 240 V system should only be carried out by a qualified electrician who is an approved Contractor of the NICEIC. Filter Pump: When applicable, remove filter, clean and replace. Check the in-line pump for security of fixing and condition. Check that the pump inlets and outlets are clear and not obstructed. Check security of fixing and condition of delivery hose and electric cable.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 49 20. Good Neighbour Guide Motor Caravaners Good Neighbour Code Solid bulky items such as disposable nappies etc must not be put into the chemical closet emptying point or site rubbish bins.Wrap them in a polythene bag and place in designated containers. Household rubbish should be put into the private rubbish collection bins. At a Camp Site On Arrival Park as close to the reception area as possible and report your arrival.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 50 20. Good Neighbour Guide Fire Precautions Wild Camping Read all fire precaution notices and make sure that you and your family are familiar with the locations of hoses, extinguishers and assembly points. Although not compulsory, it is a good idea to carry a 2-kg dry powder fire extinguisher in your motor home. It must comply with BS5423 and be marked 'BSI' or ‘FOC approved’.To comply with BS5423 it must be checked regularly.
Final 2006 AT Handbook 1/12/05 12:06 pm Page 51 20. Good Neighbour Guide All the time your motor home is moving: • Passengers must be wearing seatbelts. • Elevating roofs must be lowered and correctly secured. • Top hinged windows must be closed and secured. • All doors and access lockers for gas containers and chemical toilets must be properly closed. • Exterior steps must be retracted and secured. • Gas appliances must not be used unless the manufacturer states that it is safe to do so.
